2008 AIRSTREAM BASE CAMP Tires Problems

HAULMARK TRAILER WITH HI-RUN LQ229 TIRES SIZE 205/75/D15 TIRES WORE OUT IN LESS THAN 3000 MILES. ALTHOUGH INFLATED PROPERLY A LARGE BUBBLE DEVELOPED ON THE SIDE OF THE TIRE. THE BUBBLE BURST SOON AFTER DEVELOPING BUT THE TIRE STILL HELD AIR. BOTH TIRES WERE REMOVED AND REPLACED TO PREVENT A LIKELY BLOWOUT. CLOSER INSPECTION OF THE TREAD SHOWED THE TIRE THAT DID NOT HAVE THE BUBBLE HAD WORN ALMOST ALL THE WAY DOWN TO THE BELTS ON THE INSIDE EDGE OF THE TREAD. NOT SURE IF THIS WAS BECAUSE OF TRAILER AXLE ALIGNMENT OR INTERNAL DEFECT OF THE TIRE. MAKE AND MODEL OF TRAILER AND TIRE ARE NOT ON ANY OF THE LISTS SO I HAD TO CHOOSE SOMETHING. TRAILER IS A HAULMARK 6X12 CARGO SINGLE AXLE. TIRE IS HI-RUN LQ229 205/75D15. *TR

I EXPERIENCED A TIRE FAILURE ON 9/1/08 ON HWY 44 IN MO. THE TIRE WAS ON A TRAILER PURCHASED 3/20/08. THE TIRE PRESSURE HAD BEEN CHECKED PRIOR TO DEPARTURE, AS IT HAD BEEN ON THE DAY OF THE TRIP ORIGIN. TIRE AIR PRESSURE WAS ADJUSTED ON THE DAY OF DEPARTURE, BUT NO AIR NEEDED TO BE ADDED ON THE DAY OF THE FAILURE. THE TRAILER IS TYPICALLY LOADED TO CAPACITY, SO I AM CAREFUL TO MONITOR TIRE PRESSURE (40 PSI PER THE OWNERS MANUAL). WHEN THE TIRE DEFLATED, IT WAS REPLACED WITH THE SPARE. THE FAILED TIRE APPEARED TO HAVE DEFORMED AFTER OVERHEATING, BUT AS NOT PUNCTURED. I CONTACTED THE TRAILER MAKER, AND THEY IMMEDIATELY OFFERED TO SEND A SET OF THE OPTIONAL WHEELS OFFERED FOR THE TRAILER, AND I WAS TO RETURN THE ORIGINALS. THE SPARE TIRE I HAD INSTALLED AT THE TIRE FAILURE WAS RETAINED, AND IT WAS...

TL*THE CONTACT OWNS A 2008 AIRSTREAM CLASSIC LIMITED (NA). THE VEHICLE HAS GOODYEAR MARATHON TIRES, SIZE 225/75R/15 (NA). ALL FOUR TIRES WERE DEFECTIVE. THERE WAS EXTENSIVE TREAD BELT SEPARATION, WHICH RESULTED FROM BOTH THE DESIGN AND MANUFACTURER DEFECTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE FOUR DEFECTIVE TIRES WERE REPLACED. THE MANUFACTURER AGREED TO REIMBURSE THE REPLACEMENT TIRES. THE FAILURE MILEAGE WAS 6,900 AND CURRENT MILEAGE WAS 18,000. UPDATED 12-04-08 *BF AIR WAS SEEPING INTO THE LINER OF THE TIRE. THE SECOND FAILURE WAS NOTICED ON THE LEFT REAR TIRE WHICH WAS DELAMINATING. THE THIRD TIRE FAILURE WAS INSTANT BLOWOUT. UPDATED 12/10/08.*JB