NHTSA Complaint #11719217 — 2020 RAM 1500

My 2020 Ram 1500 equipped with the 5.7L HEMI eTorque system has experienced repeated failures of the charging system due to the belt starter generator (BSG) / 48-volt hybrid system. The vehicle has shut off unexpectedly while driving in traffic, resulting in sudden loss of engine power and loss of power steering assist. This created a dangerous situation where I had limited ability to control the vehicle and had to coast to the side of the road. The truck has also stalled at low speeds and intersections, requiring a restart while in traffic. When the failure occurs, warning messages related to the charging system or hybrid system may appear, and the vehicle becomes difficult to maneuver due to loss of steering assist. The underlying cause has been identified as failure of the eTorque belt starter generator (BSG) and/or associated 48-volt system components. The vehicle’s 12-volt battery is no longer properly charged, leading to repeated dead battery conditions. I am currently forced to recharge the battery daily to keep the vehicle operational. Replacement parts for this system (Mopar part number 68623194AC or superseding versions) are on national backorder with no estimated availability. My vehicle has been affected for approximately five months, leaving it unreliable and unsafe to operate. This defect creates a serious safety hazard because the vehicle can lose propulsion and steering assist without warning while in motion, increasing the risk of a crash. I am reporting this issue so that NHTSA can investigate potential safety defects in the eTorque hybrid system used in Ram 1500 vehicles.