NHTSA Complaint #11706591 — 2019 TOYOTA RAV4

While traveling back from out of state, the fuel sensor and fuel gauge failed causing me to run out of gas when the fuel gauge stated I had just a tick under a 1/4 tank of gas left and the app read 35 miles left. While driving on freeway at freeway speed, the car sputtered, bogged down and then stalled, placing me in a very dangerous situation broken down on the shoulder of the freeway in the desolate country at night with semi trucks and cars flying by at estimated between 70-80 mph. While stalled and waiting for help, all the lights except the hazard flashers went out. The Sheriff assisted and added 2 gallons of gas that finally got the car restarted and I was able to get to the gas station which was 1 mile ahead of where I had been stranded. I kept filling the gas tank not allowing it to go under 1/2 tank on the fuel gauge the remainder of the trip home. I took the car to Tansky Sawmill Toyota for service, who thought it was a fuel sensor in fuel tank, which had to be dropped, resulting in a tube from the fuel sender being disconnected and not taking fuel from the other side of the tank and corrosion was cleaned out. They had to go through electrical system to check the fuel gauge which had corrosion on the electrical harnesses and sensors not caused by water or rodents - still unknown cause - resulting in $6500.00 to replace both electrical harnesses 82152-0R370 wire FR Door LH and 82141-oRB80 wire Instrument Panel! Known Toyota defect as the 2019 Rav4 Hybrids have already been recalled. Issues of this type with the regular Rav4s are posted all over the online Toyota boards. My platinum extended warranty on my well cared for 2019 RAV4 with 45,131 miles (purchased at 3 year lease end) refused to all of the charges and the dealership did not budge, sticking me with 6 hours of diagnostic fees over what the warranty allowed in the sum of $1014.37. These harnesses need recalled so no one else is stranded in a very dangerous place on the side of the freeway!