NHTSA Complaint #11700638 — 2021 CHEVROLET TRAILBLAZER

The issue is the yellow engine light lit up on the dash of my 2021 Trailblazer in late August of 2025. At the same time, the cluster displayed the message "Engine Power is Reduced". Over the next few weeks my car engine would randomly stall out while I was driving! As you can imagine, this is a very unsafe driving condition. My car stalls and I'm in traffic and have no ability at all to control the vehicle. This happened at least 4 times to me. When I checked the On Board Diagnostic codes on my vehicle the system reported back U060F (Mass Air Flow Sensor). I searched online for this condition with 2021 Trailblazers and found GM Service Bulletin number 22-NA-008, dated March of 2022. This Service Bulletin clearly shows that Chevrolet were well aware of a problem years before it occurred to my vehicle. So, in October I took my car to Bowman Auto Center, explained all of the above to them, and I mentioned the Service Bulletin that I found. Their investigation found that, indeed, the cause of my engine stalling was broken wires to the Mass Air Flow sensor (MAF sensor). Bowman repaired my car and billed me $364.44 as shown on the attached 2-page Repair Order. I tried to make the case with the Bowman Service Department that this should be a warranty repair, and paid by GM. Bowman responded that it was only a Service Bulletin from GM for the issue, and the customer is responsible for payment. I am astonished that repair of this product Design Failure, which results in an unsafe driving condition, would be paid for by the customer! The reason I call it a Design Failure is because NO wiring should break during the life of a vehicle. Engines rock and move, and the Trailblazer design should have compensated for this engine movement by having a sufficient slack loop designed into the wire harness leading to the Mass Air Flow sensor. I filed a case with Chevrolet, number 80982656, but they declined my request for reimbursement $$.