NHTSA Complaint #11657864 — 2020 KIA NIRO

What component or system failed or malfunctioned, and is it available for inspection upon request? The component that failed was the Hydraulic Clutch Actuator, which is part of the hybrid transmission system. This component was already replaced in May 2024 under recall SC276, but it failed again. The vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? The failure significantly affects the vehicle’s drivability. The most noticeable issue is a loud, explosive-like sound during operation and a slipping sensation, especially when braking at low speeds on city streets. The vehicle feels unstable and difficult to control during these episodes. This creates a serious safety risk for me and for others on the road. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, it was inspected by a Kia dealership authorized by the manufacturer as part of recall SC276 in Colorado. It was later inspected again in February by Kia Serramonte in California for the same issue, but the problem still persists. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there are currently no warning lights illuminated. However, the vehicle shows abnormal behavior such as jerking, loss of power, and a noise similar to an explosion. These symptoms first appeared before the recall in 2024, and then reappeared in August 2024, just a few months after the repair until now. Due to financial limitations, I was only able to take the vehicle in for service in November 2024, and finally left it at the dealership in February 2025. The so-called “repair” lasted two months, but the dealership refused to take responsibility. I had to pay $3,188 out of pocket, and even after that, nothing was fixed — the vehicle remains defective.