NHTSA Complaint #11640484 — 2016 CHEVROLET TRAX

2016 Chevrolet Trax experienced turbocharger failure in June 2024. Initial minor acceleration inconsistencies progressed to dangerous turbulence and power loss during acceleration at both high and low speeds, with check engine light temporarily illuminating. Initial Firestone diagnostic (June 7) documented 'TURBULENCE AS ACCELERATES - CEL BLINKED.' After diagnosis, completed repair June 11. Searched for recalls at time of failure but found none listed. Given 50-minute highway commute and unsafe acceleration issues, immediate repair was necessary. Due to expected dealer costs and wait times, repair was completed at Firestone Complete Auto Care for $3,036.81. Double-checked for recalls after repair with no results. On February 3, 2025, while organizing digital records, discovered original GM Special Coverage Program notice from November 2021 covering turbocharger wastegate actuator linkage issues. Program promises coverage for 10 years/120,000 miles. At 68,283 miles, vehicle is well within coverage period. On February 3, 2025 at 4:19pm, called GM customer service (case #[XXX], 29 minute call). Rep Takesha spoke with supervisor Britney but refused transfer. Put on hold 4 times totaling over 6 minutes. When requesting Special Coverage Program information, rep repeatedly stated 'it was not done at a dealership' over 15 times as blanket response. Initially cited expired bumper-to-bumper warranty from 2019 (irrelevant to Special Coverage). When pressed, shifted to claiming 'no active recalls' for VIN. Stated 'the decision has already been made, and a supervisor will tell you the same decision,' refusing escalation or document review. All attempts to discuss Program terms met with same non-dealer repair response. Refused to provide submission process information or contacts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)