NHTSA Complaint #11634518 — 2016 CHEVROLET SILVERADO 3500

On [XXX] while traveling down [XXX] in VA I experienced a catastrophic Bosch CP4 Fuel Pump Failure. Vehicle was towed to Marion Auto Group in Marion, VA and kept for 5 weeks to repair fuel system. We paid $6,500 once we were told the repairs were complete and picked the vehicle up. Within 50 miles of driving, the fuel system error lights/codes began again and the service engine light came on. We called Marion Auto Group, they told us it was warranted for 24 months for parts and labor. We could take it to any Chevy dealer and have it looked at. We made an appt with our local Chevy dealer, Joe Bowman Chevrolet in Harrisonburg, VA. They kept the vehicle for approximately 5-6 weeks. Told us daily about the faulty repairs that Marion Auto Group had made, corrected the faulty repairs, with pictures, videos and even a coffee cup full of bad bolts and weld pieces that they replaced. Marion Auto Group agreed to pay Joe Bowman Chevrolet $5,500 in reimbursement for the work they performed to correct Marion Auto Groups work. When I got in the truck to bring it home and started it, the service engine light came on. They pulled it back in the shop, ran a diagnostic and said we needed some type of sensor ($900) so we scheduled an appt to have that done. Then we took the truck to Tennessee, fuel system failure lights and codes immediately came on. When I stopped to eat, it wouldn't start back. Took the truck to Tarr Chevrolet in Jefferson City TN, they diagnosed it as needing a new fuel line (from prev faulty fuel system) changed it ($1,700) and we headed back home with all the fuel system warning lights flashing again. Took it back to Joe Bowman Chevrolet in Harrisonburg where it's been sitting for over 7 weeks while GM decides if they should cover the entire new fuel system that it needs again ($19,000) because it's never been properly repaired since the initial catastrophic failure. Almost 7 months and $14,,600 in previous repairs.......Please HELP US! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT