NHTSA Complaint #11595075 — 2017 FORD ESCAPE

Ford Escape 2017 78,831 miles. 5/13/24 Had car inspected at Brannen Ford of Perry. I was concerned that the check engine light was illuminated. The Ford service department noted the Code P0456 but cleared the code and did not advise repair. [XXX] Drove from Georgia to Memphis and began to notice rough crank with cold start only. 5/19/24 In Memphis took to Autozone for a OBD scanner read. Scanner said P0456 and P031. First cylinder is misfiring. 5/20/24 Took to Holt Automotive to investigate code. 5/23/24 Holt referred to Madison Automotive since technician believed the code indicated an engine issue beyond the scope of Holt. 5/23/24 Delivered to Madison Automotive for diagnostics. Ran codes and noted a 2.0L engine. Removed and replaced the ignition coil and relevant spark plug per OBD scanner. Cost $526.39 6/1/24 Took back to Autozone for OBD scan due to check engine light coming on again. Same codes. 6/3/24 Took back to Madison Automotive. Ran codes again and realized, by coincidence, purge valve was bad. Replaced purge valve. Cost $462.47. Could not note the rough start or find a specific leak. Informed that usually leaks only occur with temp change, hence the rough cold crank noted by us. [XXX] Check engine light on again and would not start at gas station. Had to go through manual start process. 6/14/24 Took back to Madison Automotive. They decided to try a cold crank in the morning after it sat unused through the night. White smoke filled the parking lot. Confirmed that defective head gasket is leaking coolant into the cylinders. Recommended replace engine. 6/17/24 Called Ford Motor in Memphis. Told representative of codes and symptoms and was informed of TSB 21-233 which informs Ford of these exact defects. No recall issued as of yet. Since these same issues were noted in the 1.5 L engines and recalls were issued, I am contacting you with the same request to have Ford recall 2.0 L engines from these defective years. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U