NHTSA Complaint #11553175 — 2012 JEEP COMPASS

The rear suspension crossmember and suspension control arm rotted out on my 2012 Jeep Compass. Also, cross member cracked. Two repair shops inspected the damage and told me that I should be very careful driving the vehicle to get it repaired because there wasn't much hold the rear wheel on. They both said that the problem cause cause a catastrophic failure, which would lead to the rear wheel falling off. At highway speeds this might cause a serious accident. Both repair shops also said they have seen a lot of Jeeps with this type of rust damage. The steel used for the components must have been inferior or the factory rust protection on these components was inadequate. There are probably thousands of older jeep models (Compass, Patriot, etc.) driving around in a dangerous condition. The only warning that I got was a slight squeaking noise when I went over bumps. The sound would be fairly normal for an eleven year old vehicle. But, I decided to get under the car and spray some liquid lubricant to try to eliminate the squeak. The crack in the crossmember was up high on the underside of the car and it was difficult to see. Luckily, I noticed that the component was entirely cracked in two pieces. The second repair shop told me that Jeep extended the warranty on the components to 10 years. This was due to the large number of similar issues reported. Although the 10 year period ran out in my case in September 2022, I still plan to contact Jeep to see if they will reimburse me for a portion of the repair. But, I believe that a recall should be issued before some Jeep owner is seriously injured due to this problem. The repair cost is in the thousands of dollars. I have attached a photo showing the crack in the crossmember.