NHTSA Complaint #11490223 — 2016 CHEVROLET VOLT

While on a road trip, we were traveling on a rural highway at roughly 55 mph. We received a warning message on the dashboard stating that "Propulsion power was reduced" and the engine began running rough, with surging noticeable based on throttle position. We also noted that engine temperature was rising above what was typical for the vehicle. The vehicle was able to maintain highway speed, and we were able to limp the vehicle to a safe location. Based on a web search, we were able to diagnose the issue (a failed EGR valve) as well as a way to limp the vehicle to a local dealership. They made a change that allowed us to limp home safely (unplug the EGR valve's electrical connector and replace the blown fuse under the hood). The vehicle was taken to a Chevy dealership when we made it home. The failure we had diagnosed was confirmed, and the component was replaced. The repair was not covered under warranty, and cost a significant sum to repair (1139.91). Additionally, this appears to be a very, very common failure for this make and model of vehicle- to the point where there is so much demand for this repair to be performed that these components (the EGR valve specifically) are difficult to obtain from Chevy. Additionally, the failure mode is such that when the EGR valve fails, it pulls excessive currents, and blows a fuse that also controls a number of important engine cooling components, leaving engine cooling significantly compromised. If we had been going faster, or if the weather was warmer, or if the load inside the vehicle was heavier, it would have been easy to overheat the gas engine and leave us stranded. I am concerned about the incidence rate of the failure, (based on online reports) the relative small number of miles on the vehicle when the failure occurred, (~57k) and the possible knock-on effect of the failure of the gas engine's ability to cool itself due to a relatively unrelated failure.