NHTSA Complaint #11452410 — 2012 KIA SORENTO

The contact owns a 2012 Kia Sorento. The contact received a recall notification for NHTSA Campaign Number: 20V750000 (Engine). The vehicle was taken to the local dealer for the recall repair in January 2020. The dealer inspected the vehicle and diagnosed that no issues were found. The contact stated that while driving approximately 35-40 MPH, the vehicle decelerated to 20 MPH inadvertently. The contact depressed the accelerator pedal however, the vehicle would not exceed 40 MPH. The check engine warning light was illuminated. The contact was able to continue to drive the vehicle. The vehicle was taken to a second dealer (Ed Voyles Kia of Smyrna - Atlanta 2145 Cobb Pkwy SE, Smyrna, GA 30080) where it was diagnosed that the knock sensors malfunctioned and caused the vehicle to go on limp mode; however, the vehicle was not repaired. The contact stated that the failure reoccurred while driving. The vehicle was taken back to the first dealer who updated the Knock Sensor Detection System (KSDS) software; however, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed that the engine needed to be replaced. The dealer sent a diagnostic report to the manufacturer; however, the manufacturer declined to cover the engine replacement under NHTSA Campaign Number: 20V750000 (Engine) because the vehicle was out of warranty. A case was opened. The vehicle was not repaired. The failure mileage was approximately 112,705.