NHTSA Complaint #11384224 — 2013 CHEVROLET SONIC

MY 2013 CHEVY SONIC DEVELOPED TICKING SOUND SHORTLY AFTER I BOUGHT IT AT 60000 MILES. THE TICKING GOT WORSE OVER TIME AND THEN CHECK ENGINE LIGHT CAME ON. I SCANNED THE CODES AND MULTIPLE FOUR CODES WERE FOUND. P0171, P0496, P1101, AND P2270. AFTER DOING SOME RESEARCH IT SEEMED TO BE THAT MOST CRUZE, SONIC, AND TRAX VEHICLES ALL HAD THE SAME ISSUES. I TOOK IT TO THE DEALER FOR DIAGNOSTICS AND WAS INFORMED THE VEHICLE NEEDED A NEW INTAKE MANIFOLD, PURGE VALVE, PCV HOSE, AND VALVE COVER. THEY CALLED THE DEALERSHIP TO SEE IF THERE WERE ANY RECALLS AND THE ONLY ONE WAS THE VALVE COVER BUT WOULD HAVE TO PAY FOR DIAGNOSTICS TO SEE IF THEY WOULD COVER IT OR NOT. THE BREATHER DIAPHRAGM IN THE VALVE COVER GOES BAD DUE TO A FAULT INTAKE MANIFOLD ON THESE VEHICLE MODELS. THERE IS A LITTLE ORANGE GASKET IN THE MANIFOLD THAT GOES BAD AND CAUSES THE DIAPHRAGM TO GO OUT RESULTING IN HAVING TO REPLACE THE ENTIRE SYSTEM. THE INTAKE MANIFOLD NOT ONLY CAUSES GHAT ISSUE BUT CAUSES THE CAR TO GET JUMPY AT STOPS AND STALLING OUT. HAVE ALMOST HAD A FEW PEOPLE REAR END ME DUE TO THIS. THE PURGE VALVE GOES OUT AS WELL AND WHEN AT THE FUEL PUMP THE CAR WILL HESITATE TO CRANK OR RUN AT VERY LOW IDLE SHUTTING OFF MULTIPLE TIMES BEFORE IT STARTS UP AND THEN RUNS ROUGH UNTIL A DECENT AMOUNT OF FUEL HAS RAN THROUGH THE ENGINE. THE CAR WOULD NOT GET ENOUGH FUEL WHEN AT STOPS OR ON HIGHWAYS AND WOULD ALSO JUST LOSE FUEL AND CUT THE ENGINE OFF. THOSE COMPONENTS HAVE SINCE BEEN REPLACED BY MYSELF AND NO MORE ISSUES. CHEVY WILL NOT RECALL THE PARTS THAT ARE CAUSING THE ISSUES AND THEREFORE THERE IS A SAFETY ISSUE WHEN OUT ON THE HIGHWAYS.