NHTSA Complaint #11329102 — 2017 FORD ESCAPE

THIS ISSUE OCCURRED WHILE PARKED IN THE DRIVEWAY. CRANKED THE CAR AS NORMAL AND THE CAR STARTED SHAKING AND SHUDDERING AT IDLE, REVVED THE ENGINE A FEW TIMES AND IDLE BECAME NORMAL. AFTER DRIVING OFF THE CHECK ENGINE LIGHT CAME ON AFTER ABOUT A MILE OF DRIVING AND FOR ABOUT 12HRS. EACH TIME THE CAR WAS CRANKED THE CHECK ENGINE LIGHT CAME ON, BUT AFTER ABOUT A 12 HR. PERIOD IT DID NOT COME BACK ON. SINCE THIS OCCURRED ON 06/04/20 EVERY TIME THE ENGINE WAS CRANKED FOR THE FIRST TIME IN THE MORNING OR AFTER IT HAS BEEN PARKED FOR SEVERAL HOURS AND THEN CRANKED BACK UP...THE SHUDDERING AND SHAKING OCCURRED EACH TIME, BUT THE CHECK ENGINE LIGHT HAS NOT COME BACK ON. I MADE AN APPOINTMENT WITH THE FORD DEALER I PURCHASED THE ESCAPE FROM FOR 10AM ON 06/15/2020. AFTER AN HOUR AND A HALF WAIT THE SERVICE TECH INFORMED ME THAT THE ENGINE BLOCK (AND AN ADDITIONAL 4 PAGES OF PARTS) WERE GOING TO HAVE TO BE REPLACED. HE ALSO SAID SOME OF THESE PARTS ARE LIKELY TO BE BACK ORDERED BECAUSE OF THE HIGH INCIDENCES OF THIS ISSUE/PROBLEM. HE STATED THAT ONE SIDE OF THE ENGINE BLOCK WAS COOLING OFF FASTER THAN THE OTHER WHICH CAUSED THE ALUMINUM ENGINE BLOCK TO WARP AND IT IS ALLOWING COOLANT TO LEAK INTO THE CYLINDER TUBES THAT WILL EVENTUALLY CAUSE ENGINE FAILURE. WITH ONLY 27,381 MILES ON IT THESE REPAIRS ARE COVERED UNDER WARRANTY, BUT I'M WORRIED ABOUT THE RELIABILITY IN THE FUTURE AFTER WHAT'S BASICALLY AN ENGINE REBUILD. WHAT MAKES ME ANGRY IS AFTER JUST A LITTLE RESEARCH I FIND THAT FORD HAS KNOWN ABOUT THIS ISSUE FOR YEARS, BUT HAS FAILED TO ISSUE A RECALL OR AT THE VERY LEAST INFORM CURRENT OWNERS THAT THERE IS POTENTIALLY A SEVERE FLAW IN THEIR ENGINE DESIGN. *TR