NHTSA Complaint #11316816 — 2012 KIA OPTIMA

I WAS DRIVING AND HEARD SOME KNOCKING AND SMELLED AN EXHAUST LIKE SMELL, AFTER GETTING OFF THE HIGHWAY AND STOPPING AT A STOP LIGHT, THE CAR WOULD NOT ACCELERATE PASS 25 MPH WHEN PRESSING ON THE GAS PEDAL AND WOULD STUTTER & HESITATE. I STOPPED FOR A DIAGNOSIS AT THE CLOSEST CAR SHOP. AFTER THEIR EVALUATION THEY THOUGHT IT COULD BE THE TRANSMISSION BUT SINCE THEY WERE A OIL CHANGE & TIRE SHOP THEY COULD NOT HELP. SINCE THE CAR WAS DRIVABLE, I THOUGHT I COULD MAKE IT BACK HOME VERY SLOWLY, I DROVE NO MORE THAN AN 1/2 MILE AND COULD NOT ACCELERATE PASS 10 MPH. I PARKED THE CAR AND HAD IT TOWED TO ANOTHER AUTO REPAIR SHOP 3 MILES AWAY. OUTCOME, THEY RESEALED TIMING COVER WHICH INCLUDED REPLACEMENT OF FRONT CRANK SEAL, VALVE COVER GASKET AND CLEANED RESIDUAL ENGINE OIL FROM ENGINE. ALSO, RESEALED LOWER OIL PAN AND REPLACED OIL AND AIR FILTER AND CLEANED RESIDUAL ENGINE OIL. EVEN AFTER THIS REPAIR, THEY TEST DROVE THE CAR AND VERIFIED THE CAR WOULD NOT ACCELERATE PASS 30 MPH AND WOULD STUTTER AND HESITATE. THEY INFORMED ME THAT IT MAYBE THE HYBRID SYSTEM. I WENT ONLINE REGARDING THE HYBRID SYSTEM(STILL UNDER THE FACTORY WARRANTY OF 100,000)AND NOTICED A RECALL ON THE NON-HYBRID KIA OPTIMA WITH MY SAME EXPERIENCE. I HAD IT TOWED TO THE DEALERSHIP CLOSE TO MY HOUSE. THE DEALERSHIP PERFORMED A DIAGNOSIS AND THEIR FINDINGS WERE 'COULD NOT DUPLICATE CUSTOMER'S CONCERN AT THIS TIME, THERE WAS NO OIL LEAK FOUND ON THE ENGINE AND VEHICLE DRIVE PROPERLY DURING ROAD TEST.' MY CAR HAS BEEN SITTING FOR OVER 11 MONTHS. I DID TAKE IT TO THE DEALERSHIP RECENTLY FOR INSPECTION & EMISSION, PASSED AS CAR HAD LESS THAN 5,000 MILES FROM LAST SERVICE. HOWEVER,ON THE WAY HOME, 1.2 MILES AWAY, THE HYBRID SYSTEM WARNING LIGHT CAME ON 'SAFELY STOP AND DO NOT DRIVE'. I PUT ON THE HAZARD LIGHTS AND MADE MY WAY HOME AS I WAS HALF-WAY, THE CAR HAS BEEN SITTING SINCE. PLEASE RECALL'MAKE THIS RIGHT