NHTSA Complaint #11292271 — 2015 FORD FUSION

TL* THE CONTACT OWNS A 2015 FORD FUSION. WHILE DRIVING 25 MPH, THE DRIVER'S SIDE BRAKE LINE MALFUNCTIONED. THE BRAKE PEDAL WAS VERY LOOSE AND TRAVELED TO THE FLOORBOARD. THE CONTACT WAS ABLE TO PULL INTO A PARKING LOT AND BUMP AGAINST A CURB TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO REPAIRED THE DRIVER'S SIDE BRAKE LINE THAT WAS LEAKING BRAKE FLUID. THE FAILURE RECURRED WITH THE PASSENGER SIDE BRAKE LINE, WHICH WAS ALSO REPAIRED BY THE SAME MECHANIC. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED. THE MECHANIC CHANGED A COIL PACK ON CYLINDER NUMBER FOUR ON THE ENGINE, BUT THE FAILURE RECURRED THE FOLLOWING. THE CONTACT STATED THAT THE ENGINE SHOOK AND EXCESSIVE SMOKE POURED OUT OF THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO RIVERSIDE FORD (2089 RIVERSIDE DR, MACON, GA 31204, (478) 464-2900) WHERE THEY CHANGED A SPARK PLUG ON CYLINDER NUMBER FOUR. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE DEALER FOUND COOLANT IN THE ENGINE WITH THE FLUID ENTERING THROUGH THE CYLINDER NUMBER FOUR BLOCK. THE DEALER QUOTED THE COST TO REPLACE THE ENTIRE ENGINE. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE CONTACT RESEARCHED THE FAILURE AND FOUND THAT IT OCCURRED MANY TIMES WITH A POSSIBLE ENGINE DESIGN CRACK. THE MANUFACTURER DID NOT ASSIST AND REFERRED THE CONTACT TO NHTSA. THE BRAKE FAILURES WERE REPAIRED. THE FAILURE MILEAGE WAS 86,000. *LN