NHTSA Complaint #11271348 — 2002 FORD F-250

2002 F-250 7.3L DIESEL. DRIVING DOWN THE HIGHWAY PULLING A HORSE TRAILER ENGINE JUST COMPLETELY STALLED WITHOUT WARNING. I LOST ALL STEERING AND BRAKES. I PUT IT IN NEUTRAL AND RESTARTED WHILE COASTING. DROVE ANOTHER FEW MILES AND IT STALLED AGAIN. WOULD NOT START AGAIN AFTER THAT. THIS HAPPENED ON A REMOTE HIGHWAY AT NIGHT. HAD A WRECKER TOW US TO A DIESEL SHOP WHO REPORTED TRUCK STARTED FINE NEXT DAY. WENT AND PICKED IT UP AND IT STUTTERED A FEW TIMES ON THE WAY HOME BUT DID NOT STALL. A FEW MONTHS LATER, ENGINE STALLED AT A RED LIGHT IN HEAVY TRAFFIC BUT STARTED BACK UP. TOOK IT TO MY MECHANIC WHO READ A CAM POSITION SENSOR CIRCUIT FAULT ON THE COMPUTER. REPLACED CAM POSITION SENSOR. A FEW MONTHS LATER, STALLED AGAIN AT AN INTERSECTION. I COASTED TO THE SIDE OF THE ROAD AND HAD IT TOWED TO MY MECHANIC. UPON ARRIVING AND UNLOADING FROM WRECKER. TRUCK STARTED UP. STARTED TO DRIVE IT HOME AND STALLED AGAIN HALFWAY THERE ON A BUSY RURAL ROAD WITH NO SHOULDER. CALLED WRECKER AGAIN AND TOWED TO DIFFERENT DIESEL SHOP. REPLACED CPS AGAIN AND TRUCK STARTED FINE. TOOK IT HOME AND RAN IT AT IDLE UNTIL ENGINE TEMP WAS NORMAL. ENGINE STALLED AGAIN AND WOULD NOT START. WAITED ABOUT 2 HOURS AND IT STARTED UP JUST FINE AND RAN AT IDLE FOR ONE HOUR WITHOUT STALLING. CURRENT CPS WAS FROM FORD DEALER (THE GREY ONE) BUT APPARENTLY THE SAME PROBLEM AS THE ONE INVOLVED IN NHTSA ID: EA06012 RECALL FROM 2006 IS STILL A PROBLEM. IT COULD STALL WITHOUT WARNING IN THE MIDDLE OF AN INTERSECTION AND CAUSE A SERIOUS CRASH. THIS IS A SERIOUS SAFETY ISSUE!!