NHTSA Complaint #11056772 — 2009 CHEVROLET COBALT SS FUEL/PROPULSION SYSTEM

Complaint Details

ODI Number	11056772
Vehicle	2009 CHEVROLET COBALT SS
Component	FUEL/PROPULSION SYSTEM
Date of Incident	December 26, 2017
Date Filed	December 27, 2017
Mileage	122,000 miles
Crash	No
Fire	No
Injuries	0
Deaths	0
Vehicle Towed	No
State	NC

Consumer Description

THE FUEL LINES THAT ARE WRAPPED IN THE HEAT PROTECTIVE TAPE ON THE DRIVER REAR SIDE JUST AS THEY TURN UP TO GO TO THE FUEL TANK ARE RUSTED OUT BECAUSE THE HEAT SHIELD PROTECTOR HOLDS WATER ON THE FUEL LINES AND NOW MINE ARE RUSTED OUT AND LEAKING FUEL ALL OVER THE GROUND BY MY EXHAUST. THIS IS A MAJOR ISSUE THAT HASN'T BEEN ADDRESSED WITH MANY CHEVY PRODUCTS. NOW IT'S GOING TO COST ABOUT $600 TO REPLACE THE LINES. CHEVY IS NOT TAKING RESPONSIBILITY WITH THIS DEFECT AND COSTING PEOPLE MONEY AND PUTTING LIVES IN DANGER BY HAVING A LEAK PRONE LINE RIGHT BY THE HOT EXHAUST. PLEASE TAKE ACTION ON THIS. I HAD AT LEAST A GALLON SPRAY OUT WHILE DRIVING AND IT CONTINUED TO LEAK WHEN PARKED.

Related Complaints for the 2009 CHEVROLET COBALT SS

Other FUEL/PROPULSION SYSTEM Complaints

#11161868 — December 16, 2018 — FUEL LINE RUSTS THROUGH CAUSING FUEL TO LEAK OUT NEXT TO EXHAUST PIPE. HAPPENS TO EVAP LINE AS WELL. POOR DESIGN IN T...

#11160763 — December 11, 2018 — FUEL LINES UNDER THE CAR, DRIVER SIDE REAR STARTED LEAKING FUEL. THE LINES WERE RUSTED THROUGH AND FUEL LEAKED PAST ...

#11098353 — May 28, 2018 — LEAKING FUEL LINES ABOVE EXHAUST. WHERE THE FUEL LINE COMES DOWN OUT OF THE TANK AND RUNS FORWARD, THERE IS A HOLDER ...

#10895010 — August 11, 2016 — STRONG FUEL ODOR COMING FROM VEHICLE. FUEL DRIPPING FROM BOTTOM OF CAR NEAR FUEL TANK. FOUND FUEL LINES ROTTING AND C...

#10643229 — October 8, 2014 — WANTED TO CHANGE OIL; HAD SMELLED GASOLINE FROM TIME TO TIME; CLOSER INSPECTION SHOWED LEAK AT FUEL TANK AREA. COULD...

Recent Complaints for the 2009 CHEVROLET COBALT SS

#11181202 — SERVICE BRAKES — February 19, 2019 — I WAS DRIVING THE OTHER DAY AND NOTICED THAT ONE OF MY BACK BRAKES WAS STICKING AND SO I TOOK A LOOK AT IT AND FLUID ...

#11161868 — SERVICE BRAKES — December 16, 2018 — FUEL LINE RUSTS THROUGH CAUSING FUEL TO LEAK OUT NEXT TO EXHAUST PIPE. HAPPENS TO EVAP LINE AS WELL. POOR DESIGN IN T...

#11123986 — ELECTRICAL SYSTEM — September 1, 2018 — CONNECTOR FEEDING POWER TO THE A/C-HEATER BLOWER MELTED; CAUSED A CRACKLING SOUND, A SMELL, AND THE FAN TO STOP WORKI...

#11061342 — SEAT BELTS — January 9, 2018 — THE PASSENGER SEAT BELT LIGHT STAY ON ALL THE TIME EVERY ONCE IN AWHILE IT MAY GO OFF BUT IT COMES BACK ON

#10985462 — AIR BAGS — May 12, 2017 — MY AIRBAG LIGHT STARTED RANDOMLY GOING ON AND OFF. I NOTICED THAT IT OFTEN OCCURRED WHEN SOMEONE WAS SITTING IN THE P...