NHTSA Complaint #10885345 — 2008 INFINITI G35

I HAVE A 2008 INFINITI G35 VEHICLE. I RECENTLY DISCOVERED A RUST HOLE IN THE LOWER RIGHT PASSENGER DOOR FRAME. I TOOK MY VEHICLE TO INFINITI OF SCOTTSDALE WHERE I PURCHASED THE CAR TO HAVE THEM INSPECT AND EXPLAIN HOW THIS RUST HOLE HAPPENED. I'VE TAKEN GREAT CARE OF THIS CAR AND HAVE IT ROUTINELY SERVICED AND WASHED AND PARKED IN THE GARAGE. THE INFINITI DEALER SUGGESTED I REPORT THE RUST HOLE TO INFINITI CONSUMER AFFAIRS - WHICH I'VE DONE. INFINITI CONSUMER AFFAIRS THEN SENT ME BACK TO INFINITI OF SCOTTSDALE TO HAVE REPAIRS MADE ON THE CAR. UNFORTUNATELY, IT WAS DISCOVERED THAT THE RUST HOLE IN THE DOOR WAS JUST THE "TIP OF THE ICEBERG" IN TERMS OF RUST DAMAGE TO MY VEHICLE. THE DEALER BODY SHOP FOUND THAT THE RAINWATER DRAIN LINES FOR THE VEHICLE WERE IMPROPERLY ROUTED BY THE MANUFACTURER AND WATER HAS BEEN DRAINING DIRECTLY INTO THE FRAME RESULTING IN NEARLY HALF OF THE VEHICLE BEING RUSTED OUT. THE COST TO REPAIR THE VEHICLE NOW VASTLY EXCEEDS THE LIMITED FUNDS APPROVED BY INFINITI CONSUMER AFFAIRS. I'M TOLD THAT BECAUSE MY WARRANTY ON THE CAR JUST EXPIRED THIS LAST NOVEMBER, THERE IS NOTHING THAT INFINITI CONSUMER AFFAIRS CAN DO TO FURTHER HELP. THE VEHICLE ONLY HAS 63,000 MILES ON IT AND I'M STILL FINANCING IT AND YET IT NOW IS HALF-RUSTED DUE TO CIRCUMSTANCES OUTSIDE OF MY CONTROL. I'M CONCERNED ABOUT THE OPERATIONAL SAFETY OF DRIVING A CAR WITH THIS MUCH RUST. I USE MY VEHICLE TO ROUTINELY TRANSPORT MY YOUNG CHILDREN TO AND FROM SCHOOL AND TO THEIR SPORTS ACTIVITIES. I'M ALSO CONCERNED THAT EVEN IF REPAIRS COULD BE MADE, THIS DAMAGE SIGNIFICANTLY IMPACTS THE POTENTIAL RESALE VALUE OF THE VEHICLE. I WOULD HOPE THAT A DEFECTIVE MANUFACTURING EVENT WOULD HAVE BEEN CORRECTED AND THAT MY CAR WOULD EITHER BE FIXED OR REPLACED IN ORDER TO NOT COMPROMISE MY SAFETY AND THE SAFETY OF MY FAMILY.