NHTSA Complaint #10554145 — 2003 VOLVO XC90

I WAS NOT AWARE OF THE DESIGN DEFECT IN SUN ROOF & THE WATER DAMAGES THAT RESULT IN ELECTRICAL ISSUES. I HAD ALWAYS PARKED MY VEHICLE IN COVERED PARKING UNTIL MOVING THIS YEAR IN JANUARY. I HAD TAKEN MY CAR IN TO HAVE A TUNE UP IN NOV 2012 AT WHICH TIME I WAS GIVEN AN ESTIMATE OF REPAIRS NEEDED IN MY CAR. MY CAR REMAINED PARKED FOR MOST OF 2013 DUE TO HAVING MOVED I WASN'T ABLE TO AFFORD REPAIRS. THE REPAIRS WHERE INNER&OUTER TIE RODS,BALL JOINTS, MOUNTS, ARM BUSHINGS, ROTORS & BREAK PADS. THE ABOVE AFOREMENTIONED WHERE MADE. FOLLOWING REPAIRS I WASHED MY CAR AND DROVE OUT OF TOWN 4TH JULY WEEKEND FROM LOS ANGELES TO JAMESTOWN CALIFORNIA. ONCE I ARRIVED MY CAR REMAINED PARKED UNTIL RETURNING HOME JULY 7TH. SHORTLY AFTER STARTING MY CAR THE DASH GAUGES STARTED TO FLASH ON/OFF AND EVENTUALLY WENT OUT. AT THE TIME I HAD MY PORTABLE GPS, A/C WAS WORKING & I HAD USE OF WINDOWS (ROLLING UP & DOWN). I KNEW I HAD A FULL TANK OF GAS CAUSE I HAD FUELED UP PRIOR TO ARRIVING AT DESTINATION. BEING I WAS IN THE MIDDLE OF KNOW WHERE WITHOUT CELL PHONE SERVICE I DROVE AS FAR AS I COULD BEFORE I THOUGHT I MAY NEED GAS. WHEN I STOPPED TO GET FUEL I WAS NOT ABLE TO OPEN THE DOOR TO REFUEL WITH GAS. I BROKE THE CLIPS ON THE DOOR ALLOWING ME TO ACCESS AND FUEL TANK AND REFILL WITH GAS. IT WAS SUNDAY AFTER A MAJOR HOLIDAY AND THERE WAS A LOT OF TRAFFIC, THE ONLY VOLVO DEALERSHIP I PASSED WAS CLOSED AND I JUST WANTED TO GET HOME. SO I CONTINUED TO DRIVE AND WAS JUST GETTING ONTO THE GRAPEVINE AND TRAFFIC REALLY BACKED UP. THERE WAS A FIRE THAT HAD BEEN BURNING ON THE MOUNTAIN TO THE RIGHT AND HELICOPTERS WHERE DUMPING WATER ON THIS ONGOING FIRE. AROUND THIS TIME I NOTICED THE A/C HAD QUIT WORKING AND WAS BLOWING HOT AIR. I TRIED TO ROLL MY WINDOWS DOWN AND THEY WHERE INOPERABLE. TRAFFIC WAS AT A CRAWL AND THERE WAS NO PLACE TO PULL OVER. WORST NIGHTMARE EVER. *TR