NHTSA Complaint #10482564 — 2003 FORD TAURUS

ENTERED HIGHWAY ON-RAMP. AS I MERGED ONTO HIGHWAY AT APPROXIMATELY 55 MPH, I NOTICE THAT THE CAR WAS ACCELERATING FASTER THAN USUAL FOR THE AMOUNT OF THROTTLE I WAS USING. I TOOK MY FOOT OFF THE THROTTLE COMPLETELY AND THE CAR CONTINUED TO SLOWLY BUT STEADILY ACCELERATE. WITHOUT PLACING MY FOOT ON THE THROTTLE, I CONTINUED DOWN THE HIGHWAY TO THE NEXT EXIT. AS I APPROACHED THE LIGHT AT THE END OF THE EXIT, I BEGAN BRAKING. FEELING THE ENGINE FIGHT THE BRAKES, I MOVED THE SHIFT LEVEL INTO NEUTRAL AND BROUGHT THE CAR TO A STOP ON THE SHOULDER OF THE EXIT. AS SOON AS I PLACED THE SHIFT LEVER INTO NEUTRAL, ENGINE RPM SHOT UP AS IF THE ACCELERATOR WAS BEING DEPRESSED. REPEATEDLY PRESSING AND UN-PRESSING THE ACCELERATOR PEDAL DID NOT NOTHING, NOR WAS THE PEDAL STUCK ON THE FLOOR MAT. I TURNED THE CAR OFF AND PLACE THE SHIFT LEVER INTO PARK. STARTING THE CAR AGAIN RESULTED IN THE SAME BEHAVIOR: ENGINE RPM SHOT UP EVEN THOUGH THE ACCELERATOR PEDAL WAS NOT DEPRESSED. I TURNED THE CAR OFF AND OPENED THE HOOD. I IDENTIFIED THE THROTTLE BODY AND NOTICE THAT A PLASTIC CLIP HAD BECOME DISLODGED FROM THE POINT WHERE THE THROTTLE CABLE ENTERS THE THROTTLE BODY. AFTER SEVERAL MINUTES OF REINSERTING AND WIGGLING THE CLIP, I WAS ABLE TO GET IT TO STAY IN ITS PROPER PLACE, AND THEREAFTER, THE THROTTLE BEHAVED NORMALLY. I CAREFULLY DROVE TO THE NEAREST FORD DEALERSHIP WHERE THEY REPLACED THE FOLLOWING PART: YFIZ*9A825*CA ACTUATOR ASY. I HAVE THIS INVOICE AVAILABLE IF YOU NEED IT. I HAVE NOT EXPERIENCE ANY OTHER ISSUES WITH THE THROTTLE. *TR