NHTSA Complaint #10479443 — 2004 VOLVO V70

TL* THE CONTACT OWNS A 2004 VOLVO V70. WHILE PARKED, THE CONTACT NOTICED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE TECHNICIAN RECOMMENDED UPDATING THE SOFTWARE. THE SOFTWARE WAS UPDATED HOWEVER AFTERWARD, THE CHECK ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. ADDITIONALLY, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE CONTROL ELECTRONICS MODULE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT TO NO AVAIL. THE CONTACT INFORMED THE DEALER THAT THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE DEALER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE TECHNICIAN THEN REPLACED THE FUEL PRESSURE SENSOR. THE FAILURE WAS REMEDIED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. ..UPDATED 11/29/12 *BF THE CONSUMER STATED DURING THE LATTER PART OF 2011, THE "CHECK ENGINE' LIGHT CAME ON AND WOULD GO OFF INTERMITTENTLY. JUNE 30, 2012 THE VEHICLE WOULD NOT START. A MECHANIC DETERMINED THERE WAS AN INTERNAL FAULT IN THE CEM MODULE. IT WAS REPLACED BUT, DID NOT REPAIR THE VEHICLE. THE VEHICLE SHUT OF WHILE MAKING A TURN ON AUGUST 21, 2012. THERE WERE NO CODES DISPLAYED. THE CONSUMER REQUESTED THE FUEL SENSOR TO BE CHECKED. IT WAS FOUND TO BE THE REASON FOR THE FAILURE AND REPLACED AT A COST OF $375. THE CONSUMER REQUEST THAT RECALL 181 BE REQUIRED TO EXPAND ITS COVERAGE. UPDATED 12/4/2012 *JS