NHTSA Complaint #10468038 — 2003 HYUNDAI SANTA FE

THE RIGHT FRONT ROCKER ARM RUSTED OUT CAUSING THE RIGHT FRONT WHEEL TO NO LONGER BE PROPERLY SUPPORTED. THE LOWER SUPPORT ARM IS NO LONGER FASTENED TO THE FRONT SUPPORT FRAME. THIS CAUSED THE ALIGNMENT TO BE OFF, IMPROPER AND EXCESSIVE TIRE WEAR (REPLACED TIRES WELL BEFORE THE WARRANTY WAS UP). HYUNDAI HAD A RECALL FOR THIS PROBLEM ON OTHER MODELS (FRONT SUB-FRAME) BUT NOT ON SANTA FE'S (ONLY REAR TRAILING ARM WAS INCLUDED IN THE RECALL). WHEN EXPERIENCING ISSUES IN MULTIPLE VEHICLES FOR THE SAME REASON, BUT DIFFERENT LOCATIONS, ALL LOCATIONS SHOULD BE CHECKED AND NOT ONLY THE ONLY THAT IS PROMINENT. A 5 MINUTE ADDITIONAL INSPECTION VS. THE ULTIMATE WORSE CASE SCENARIO OF A DEATH, SEEMS LIKE A NO BRAINER. HYUNDAI KNEW THIS COULD BE A PROBLEM AND REFUSED TO ADDRESS IT. THIS HAS NOW COST US ALMOST $3000 IN REPAIRS THAT COULD HAVE BEEN AVOIDED. THE MECHANIC THAT FOUND THE PROBLEM WILL NOT LET THE VEHICLE BE DRIVEN FROM HIS SHOP, AS IT IS TOO DANGEROUS. THE WORST PART IS IF THAT IF THIS FAILURE HAD OCCURRED WHILE TRAVELING OVER THE HIGHWAY, IT COULD HAVE RESULTED IN A SEVERE CRASH, WHICH AS YOU KNOW COULD RESULT IN SERIOUS INJURY OR DEATH. HYUNDAI WAS NOT INTERESTED IN HEARING ABOUT THE PROBLEM WHEN WE CONTACTED THEM. *TR