NHTSA Complaint #10413839 — 2006 FORD FREESTYLE

EARLY JULY 2010 CAR WOULD SURGE AFTER STARTED WHEN PLACED INTO DRIVE OR REVERSE. JULY 17,2010 ABOUT 95 DEGREES AMBIENT. DRIVING 55 MPH CAR STARTED TO LOSE POWER AND STALL. RESTARTED AND IT WENT INTO LIMP MODE WITH CHECK ENGINE LIGHT AND OCCASIONAL SURGES. I FOUND A FORD DEALER ABOUT 5 MILES AWAY. DIAGNOSIS WAS A BAD MASS AIR FLOW SENSOR. REPLACED AND WE WERE ON OUR WAY AGAIN. EARLY JUNE 2011 IT WAS SURGING AFTER STARTING WHEN PLACED IN DRIVE OR REVERSE. JUNE 11,2011. CAR STALLED AND WENT INTO LIMP MODE AGAIN WITH CHECK ENGINE LIGHT ON. BOUGHT A NEW MASS AIR FLOW SENSOR, INSTALLED IT MYSELF AND CLEARED THE CODE. JULY 5,2011 WHILE DRIVING TO BALTIMORE AT 65 MPH AND 100 DEGREE AMBIENT, CAR STALLED, RESTARTED AND IT WENT INTO LIMP MODE WITH CHECK ENGINE LIGHT ON. I FOUND A PARKING LOT WITH SHADE AND LET IT IDLE FOR ABOUT 20 MINUTES. SHUT IT OFF AND RESTARTED. CHECK ENGINE LIGHT WAS OFF AND IT RAN FINE TO BALTIMORE. THIS APPEARS TO BE AN ISSUE WITH THE MASS AIR FLOW CIRCUIT. NHTSA CANNOT IGNORE THIS FLAW. *KB