NHTSA Complaint #10395285 — 1999 JEEP CHEROKEE

NO: 08-15-99 SUBJECT: ERRATIC, INTERMITTENT CLUSTER OPERATION/INTERMITTENT AIR BAG WARNING LIGHT. DATE: MAY 21, 1999 THIS BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN NUMBER 08-20-98 REV. A, DATED OCTOBER 2, 1998, WHICH SHOULD BE REMOVED FROM YOUR FILES AND NOTED IN THE BOUND TECHNICAL SERVICE BULLETIN BOOK, PUBLICATION NUMBER 81-699-99003. THIS IS A COMPLETE REVISION TO THE PROCEDURE. OVERVIEW: THIS BULLETIN INVOLVES INSTALLING A REPAIR HARNESS CONTAINING A REVISED INSTRUMENT CLUSTER CONNECTOR. SYMPTOM/CONDITION: SOME VEHICLES MAY EXHIBIT AN INTERMITTENT ILLUMINATION OF THE AIR BAG WARNING LIGHT OR AN INTERMITTENT TACHOMETER OR SPEEDOMETER DROP OUT. AN AIRBAG ELECTRONIC CONTROL MODULE (AECM) FAULT CODE -"NO CLUSTER CCD BUS " MESSAGE WILL BE PRESENT. DIAGNOSIS: USING THE DRB III, READ AND RECORD ALL ACTIVE AND STORED FAULT CODES IN THE AECM. THIS CONDITION IS CAUSED BY MINOR OXIDATION OF THE BUS CIRCUIT TERMINALS AT THE INSTRUMENT CLUSTER CONNECTOR. ELECTRICAL TERMINALS WILL SHOW SIGNS OF OXIDATION, WHICH WILL APPEAR AS DARKENED LINES OR MARKS ON THE CLUSTER MALE TERMINALS. THESE OFTEN APPEAR AS GRAY OR BLACK MARKS RATHER THAN THE APPEARANCE OF OXIDATION OR CORROSION USUALLY ASSOCIATED WITH HIGHER CURRENT CARRYING CIRCUITS. THIS CONDITION WILL SET A "NO CLUSTER CCD BUS" MESSAGE. THE FAULT CODE WILL USUALLY BE STORED AND NOT ACTIVE. THIS TECHNICAL SERVICE BULLETIN WILL NOT ADDRESS FUEL OR OIL PRESSURE GAUGE ISSUES. IF THIS FAULT CODE IS PRESENT, EITHER ACTIVE OR STORED PERFORM THE REPAIR PROCEDURE. THIS SERVICE BULLETIN IS COMMON WITH ALL JEEPS. THERE ARE MANY JEEP OWNERS WITH THIS VERY PROBLEM. *TR