NHTSA Complaint #10308935 — 2005 CHEVROLET SILVERADO 1500

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE DUAL CLIMATE CONTROL ON THE AIR CONDITIONING/ HEATING SYSTEM FAILED ON AN INTERMITTENT BASIS; WHEN HE HAD THE HEAT ON, ONE SIDE WOULD BLOW HOT AIR AND THE OTHER SIDE COLD AIR AND THE SAME FAILURE OCCURRED WHEN THE AIR CONDITIONER WAS ON. HE HAD TO DRIVE ONTO THE EMERGENCY LANE, TURN OFF THE ENGINE, AND RE-START THE VEHICLE. THE DEALER REFUSE TO INSPECT THE VEHICLE SINCE THE WARRANTY WAS NO LONGER VALID. THE ELECTRICAL CONNECTOR ON THE FLOORBOARD WOULD ALSO FAIL CAUSING THE FAN TO STOP WORKING; THE HEATING SYSTEM/AIR CONDITIONING SYSTEM WOULD NOT FUNCTION WITHOUT THE FAN. HE REPLACED THE CONNECTORS AT HIS EXPENSE TWICE AND THE CONNECTOR FAILED AGAIN. HE CALLED THE MANUFACTURER AND A REPRESENTATIVE TOLD HIM THAT THEY COULD NOT ASSIST HIM. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 61,000. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.