NHTSA Complaint #10244907 — 1997 FORD EXPLORER

I BOUGHT A 1997 FORD EXPLORER ON FEBRUARY 23, 2008. ON OCTOBER 3, 2008 I USED MY EXPLORER TO JUMP ANOTHER VEHICLE. I HAD THE NEGATIVE CABLE GROUNDED TO A BRACKET RIGHT NEXT TO THE BATTERY (THE MOST OBVIOUS PLACE TO GROUND TO). WHILE TRYING TO JUMP THE OTHER VEHICLE FUEL STARTED LEAKING FROM THE FUEL LINES THAT ARE ATTACHED TO THAT BRACKET. THE FUEL LINES WERE MELTED BECAUSE OF JUMPING ON THAT BRACKET AND THERE WAS FUEL RUNNING OVER THE JUMPER CABLES AND DOWN THE SIDE OF THE ENGINE. I COULD HAVE BEEN SERIOUSLY INJURED BUT MOST LIKELY KILLED IF THE JUMPER CABLES SPARKED. I WAS LOOKING ON THE INTERNET TO SEE HOW MUCH IT WOULD COST TO HAVE THE FUEL LINES REPLACED AND I STUMBLED ACROSS A RECALL STATING THAT ON MY SPECIFIC EXPLORER " THE ENGINE FUEL LINES CAN BE DAMAGED IF THE VEHICLE IS JUMP STARTED AND THE GROUND CABLE IS ATTACHED TO THE FUEL LINE BRACKET THAT IS LOCATED NEAR THE BATTERY. SINCE THE BRACKET IS NOT GROUNDED, THE STAINLESS STEEL FUEL LINE BRAID COULD ACT AS A GROUND POTENTIALLY OVERHEATING THE PTFE INNER LINER OF THE FUEL LINE RESULTING IN DAMAGE TO THE FUEL LINE. CONSEQUENCE: THE FUEL LINES CAN LEAK, AND IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD POTENTIALLY RESULT. REMEDY: DEALERS WILL INSTALL A WARNING LABEL ON THE FUEL LINE BRACKET ADVISING OWNERS NOT TO USE IT FOR A JUMP START GROUND." I WENT AND CHECKED TO SEE IF THERE WAS ANY KIND OF WARNING AND THERE WAS, BUT IT WAS NOT ON THE FUEL LINE BRACKET LIKE THE RECALL SAID THE DEALERSHIP SHOULD DO, IT WAS ON THE FUEL LINES AND TUCKED UP BEHIND THAT BRACKET WHERE IT WAS IN NO WAY VISIBLE UNLESS YOU KNEW IT WAS THERE. SO NOW IM GOING TO HAVE TO PAY $608.05 FOR FUEL LINES BECAUSE FAULKNER-CIACCO FORD DEALERSHIP DID NOT SERVICE MY EXPLORER CORRECTLY. I CALLED FORD MOTOR COMPANY ASKING IF THEY WOULD PAY FOR IT AND THEY SAID THAT THEY CANT DO ANYTHING ABOUT IT. I BELIEVE FORD, OR THE DEALER SHOULD HAVE TO PAY SINCE THE WARNING LABEL WAS NOT CORRECTLY PLACED ON MY VEHICLE. THE FORD RECALL # IS 98S09. *TR