NHTSA Complaint #10232970 — 1989 FORD E150

NHTSA CAMPAIGN ID# 91V146000 REFERS TO A SAFETY RECALL FOR A FAULTY DUAL FUEL TANK SELECTOR VALVE IN FORD ECONOLINE VANS EQUIPPED WITH DUAL FUEL TANKS BUILT BETWEEN 1989 AND 1991 AND OTHER SIMILAR MODELS . I HAVE CONTACTED FORD TO INVESTIGATE , BUT THERE ARE NO RECORDS THAT CONFIRM OR DISAFFIRM MY VEHICLE'S INCLUSION IN THIS RECALL. BASICALLY, I DON'T KNOW IF MY VAN WAS AFFECTED BY THIS RECALL AND IF ANY RECALL SERVICES WERE PERFORMED. I AM EXPERIENCING A FAULT IN THE DUAL FUEL TANK SYSTEM. IT SEEMS THAT THE FUEL SELECTOR VALVE WILL NOT SWITCH TO THE MAIN TANK, AND WHEN FILLED, THE MAIN TANK WILL FLOW PAST THE FILLER CAP AND CAUSES A FUEL LEAKAGE, WHICH CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION. I CONTACTED A LOCAL FORD DEALER WHO ADVISED ME THAT NO RECALL SERVICE CAN BE PERFORMED TO REMEDY THIS PROBLEM BECAUSE MY VIN# DOES NOT REGISTER IN THE FORD RECALL DATABASE. AGAIN, FORD CANNOT CONFIRM OR DISAFFIRM ANY RECALL SERVICES PERFORMED ON MY VEHICLE. I AM NOT THE ORIGINAL OWNER OF THIS VEHICLE SO I DO NOT HAVE ANY SERVICE RECORDS PRIOR TO 2005. IN AN ATTEMPT TO CORRECT THIS CONCERN, I HAVE ALREADY REPLACED THE SECONDARY FUEL PUMP, AS ADVISED BY MY LOCAL MECHANIC. I HAVE ALSO OVERHAULED BOTH FUEL TANKS TO CHECK FOR CLOGGING, OR ANY FOREIGN MATERIALS, AND I HAVE REPLACED SEVERAL SEALS AND MISC. HARDWARE IN THE FUEL SYSTEM. THIS CONCERN HAS BEEN A PROBLEM SINCE I PURCHASED THE VEHICLE IN 2005. I AM ONLY ABLE TO OPERATE MY VEHICLE ON THE AUXILLARY (REAR) FUEL TANK WITH A 13 GALLON CAPACITY. WHEN THE SELECTOR SWITCH IS ON THE FRONT TANK, THE VEHICLE WILL EVENTUALLY STALL AS IF IT IS OUT OF FUEL. WHEN THE FUEL SELECTOR SWITCH IS SET TO THE REAR TANK, I AM ABLE TO OPERATE THE VEHICLE NORMALLY WITH THE EXCEPTION OF THE LIMITED RANGE DUE TO THE SMALL AUXILLARY FUEL TANK. *TR