NHTSA Complaint #10196202 — 1995 CHEVROLET CAVALIER

I BOUGHT A 1995 CHEVROLET CAVALIER NEW, IN JULY 1995. I HAD THE FOLLOWING MAJOR REPAIRS DONE ON THE CAR. ON 8/97 -ENTIRE EXHAUST FROM CONVERTER BACK BAD BAFFLED UNDER WARRANTY. ON 10/97-SERPENTINE BELT/ROTORS/ALTERNATOR & RECALL ON HAZARD LIGHTS UNDER WARRANTY. 4/00-HEAD GASKET,SEAL,OIL,FILTER,COOLANT;RECALL ON COVER,SHIELD,RETAINER,SEALANT (DEALER COVERED COSTS UNDER A SPECIAL POLICY ADJUSTMENT. 4/00-EGR VALVE 10/00-ADJUST SERPENTINE BELT;REPLACE SERPENTINE BELT 10/01-REPLACE BACK BRAKE PADS,CLEAN FRONT PADS 05/02-REPLACE FAN BELT & TENSIONER;RECALL ON IGNITION SWITCH 06/02-BROKEN FORWARD CLUTCH HOUSING,CLUTCH,GASKETS,FLUID,LEFT FRONT AXLE ASSEMBLY 07/02-REPLACE BATTERY,BAD CELL DUE TO CAR SITTING FOR SO LONG DURING PREVIOUS REPAIR 12/03-WATER PUMP, HEAD GASKET, THERMOSTAT,OIL,FILTER,COOLANT $461.79-50% OF BILL REIMBURSED BY CHEVROLET UPON WRITTEN REQUEST 07/03-REAR BRAKES; 08/04-RESISTOR (BLOWER MOTOR, 09/04-ALTERNATOR 07/05-FRONT ROTORS & PADS; 06/06-REAR BRAKE LINE 06/07-WON'T PASS STATE INSPECTION-FRAME RUSTING OUT. REAR BUMPER SUPPORT FRAME MUST BE REPLACED TO PASS INSPECTION, MORE FRAME REPAIR WILL LIKELY BE NEEDED FOR NEXT INSPECTION;HEAD GASKET IS STARTING TO SEEP AGAIN THIRD HEAD GASKET. I CONTACTED CHEVROLET TWICE BY THEIR E-MAIL SITE IN THE PAST 2 WEEKS AND HAVE HAD NO RESPONSE. SITE CLAIMS RESPONSE WILL BE WITHIN 48 HOURS. I ASKED FOR REPAIR COSTS FOR REAR FRAME SUPPORT, HEAD GASKET OR A VOUCHER FOR CREDIT TOWARD A NEW/NEWER VEHICLE. POINTED OUT THE PROBLEM OF THE THIRD HEAD GASKET, THAT FRAME RUSTED ON A CAR ONLY 12 YEARS OLD THAT JUST LAST MONTH TURNED 72,000 MILES. ALSO, POINTED OUT THAT WHEN I BOUGHT THE CAR THE DEALER RECOMMENDED A PROTECTIVE UNDERCOUNTS WHICH I AGREED TO. WHEN I READ THE OWNER'S MANUAL IT STATED NOT APPLY *AK