NHTSA Complaint #10161382 — 1997 FORD F-150

I OWN A 1997 F-150 . I PURCHASED THIS TRUCK FROM A PRIVATE PARTY WHEN IT HAD 52,000 MILES. THE TRUCK NOW HAS ABOUT 90K MILES. ON MAY 16 I STARTED THE VEHICLE AND HEARD A RAUCOUS NOISE FROM THE ENGINE COMPARTMENT. ON MAY 17TH I HAD THE TRUCK TOWED TO AUTO SPECIALTIES, AN INDEPENDENT REPAIR SHOP. THEY IDENTIFIED THE NOISE AS A BENT CONNECTING ROD. THEY DISCOVERED STEAM COMING FROM THE TAILPIPE AND BELIEVE COOLANT SEEPED INTO THE CYLINDER THROUGH A BLOWN HEAD GASKET. I ASKED HOW THIS COULD HAVE HAPPENED. THEY SAID PROBABLY OVERHEATING. YET, IN THE ENTIRE TIME I OWNED IT, THE TEMPERATURE GAUGE HAS NEVER REGISTERED HIGH, NO STEAM AROSE FROM THE ENGINE AREA. I HAVE ALWAYS CHANGED THE OIL EVERY 3K MILES. I HAVE ALWAYS MAINTAINED CORRECT FLUID LEVELS. I HAVE NEVER TOWED ANYTHING WITH THIS TRUCK AND NEVER CARRIED ANYTHING MORE THAN A HALF-TON LOAD. I ALWAYS LET IT WARM UP AND DRIVE IT GENTLY WHILE IT IS WARMING UP. IN ADDITION, THE TRUCK SPEED CONTROL DEVICE WAS REPLACED BY THE LOCAL FORD DEALER ON SEPT. 14, 2005. IN THEIR INSPECTION OF THE VEHICLE THEY UNCOVERED NO PROBLEMS WITH COOLING OR OVERHEATING. THIS IS THE FIRST FORD I HAVE OWNED, THE FIRST AMERICAN CAR. I HAVE OWNED 1 MITSUBISHI AND 2 TOYOTA PICKUPS WHICH I BOUGHT SECOND HAND. I OWNED THEM UNTIL THEY HAD OVER 125K MILES AND THEY NEEDED NO REPAIRS OTHER THAN NORMAL MAINTENANCE. I HAVE DRIVEN A PRE-OWNED INTEGRA TO OVER 140K MILES WITHOUT PROBLEMS AND A HONDA CIVIC WHICH I DROVE FROM 60K-120K WITHOUT THE SLIGHTEST PROBLEM. A TRUCK WITH 90K MILES SHOULD NOT NEED A NEW ENGINE. BY JUST ABOUT ANY MAKER STANDARDS THE ENGINE SHOULD LAST OVER 200K MILES. I HAVE CONTACTED FORD CUSTOMER SERVICE AND SPOKE WITH CHARLES WHO SAID FORD WAS NOT RESPONSIBLE FOR THE PROBLEM, SINCE THIS PROBLEM WAS NOT PART OF A RECALL. SHOULDN'T FORD BE CONCERNED ABOUT A LEMON, EVEN IF IT IS NOT A COMMON PROBLEM? I BELIEVE FORD SHOULD REPLACE THE ENGINE, SINCE ITS FAILURE IS PREMATURE. *JB