NHTSA Complaint #10159883 — 2000 VOLKSWAGEN PASSAT

9/2003: HEADLIGHTS AIMED INCORRECTLY; ROAD WASN'T ILLUMINATED. WITHIN 2 WKS, 1 OF THE BULBS BURNED OUT. WITHIN A WEEK OF THE 1ST, THE 2ND BULB BURNED OUT. COST TO HAVE HEADLIGHTS REPOSITIONED & BULBS REPLACED: $267. 9/2003: REAR TAIL LIGHT OUT. COST TO HAVE BULB REPLACED BY MECHANIC: $32.50. 11/2003: BOTH REAR WINDOWS OFF TRACK. COST TO TEAR DOORS APART & FIX: $159.75. 12/2003: ELECTRICAL PROBLEMS WITH FRONT POWER WINDOWS. NEVER KNOW IF WINDOW WILL GO UP OR DOWN. 2004: HAD CAR IN FOR (AT LEAST) 3 DIFFERENT DASHBOARD WARNING CODES. ONE HAD SOMETHING TO DO WITH FUEL, OR THE FUEL TANK OR SOMETHING. AFTER SOME TRIAL AND ERROR ON MY MECHANIC'S PART, DISCOVERED THAT UNSCREWING AND TIGHTLY RESCREWING GAS CAP FIXED THE PROBLEM. COST TO DIAGNOSE AND "FIX": $165. HAD (AT LEAST) TWO OTHER WARNING CODES IN 2004 THAT REQUIRED ME TO TAKE THE CAR IN. 6/24/2005: HAD BEEN HEARING CRUNCHING SOUND FROM FRONT RIGHT PORTION OF CAR THAT WAS PARTICULARLY APPARENT WHEN HITTING A POTHOLE, A DIP IN THE ROAD OR ATTEMPTING A TIGHT 360 TURN. MECHANIC (SPECIALIZING IN EUROPEAN CARS) IDENTIFIED A BAD CONTROL ARM. COST OF REPAIR & ALIGNMENT: $713.70. COST OF RENTAL CAR: $100.88. TOTAL: $814.58. NOTE: THE LEFT SIDE HAS BEEN MAKING THE SAME SOUND SINCE 12/2005. HAVE NOT YET REPAIRED IT. 10/24/05: CAR STARTED GOING DEAD INTERMITTENTLY. THE CAR HAD LESS THAN 60000 MILES ON IT. REPLACED BATTERY FOR $106.50. 1/2006: TEMP GAUGE MAXED OUT, COOLANT BOILED OVER, SMOKE & STEAM ISSUED FROM HOOD IN LESS THAN 8 MINUTES AT IDLE. COOLED CAR FOR 2L HOURS, REPLACED COOLANT AND DROVE TO MECHANIC, WHO REPLACED THERMOSTAT, WATER PUMP & TIMING BELT. COST: $725. 2/2006: BRAKES ARE SPONGY AND PROVIDE NO RESISTANCE UNTIL NEARING THE FLOOR. MECHANIC SAYS ROTORS AND BRAKE PADS ARE FINE. 6/2006: TRANSMISSION GETS STUCK IN 1ST GEAR. MUST STOP THE CAR, TURN IT OFF AND THEN RESTART. THIS IS AN ELECTRICAL PROBLEM AND IS GOVERNED BY THE COMPUTER. COST TO FIX: UNKNOWN. 6/2006: FRONT WINDOW NOW OFF TRACK. HAVE NOT YET FIXED IT. *NM