NHTSA Complaint #10079103 — 2001 VOLKSWAGEN NEW BEETLE

THE REAR DISC BRAKE PADS (BOTH SIDES) COMPLETELY WORN OFF/OUT AT 25,000 MILES ON 2001 VW NEW BEETLE. THE WORN OUT PADS ALSO DAMAGED BOTH REAR HUB/ROTOR ASSEMBLIES, WHICH ALSO HAD TO BE REPLACED BY THE CONSUMER, AT THE CONSUMERS COST. THIS CAR HAD BEEN IN FOR ITS 20,000 MILE CHECK UP TO THE DEALERSHIP, AND THE FEMALE OWNER HAD ASKED ABOUT REAR BRAKE NOISES THAT CONCERNED HER. THE DEALERSHIP ASSURED HER THAT EVERYTHING WAS OK, BUT SOMETIMES IT WOULD JUST NORMALLY MAKE SOME NOISES. A FEW THOUSAND MILES LATER THE PADS AND ROTORS ARE COMPLETELY SHOT AND WE HAVE TO PICK UP THE TAB AS THE CAR IS NOW NO LONGER UNDER WARRANTY. VW HAS HAD A TECHNICAL SERVICE BULLETIN(TSB#4602-01 DATED 04-02), I RECENTLY FOUND OUT, CONCERNING THIS PARTICULAR PROBLEM WE EXPERIENCED:BRAKE PADS(REAR) APPARENT PREMATURE WEAR. I MENTIONED THIS FACT TO BOTH THE DEALERSHIP IN RACINE, WI AND VW AT THEIR 1-800-822-8987 "CUSTOMER CARE" CARE NUMBER WHEN SPEAKING TO MR KEN PARROTT. IT WAS TO NO AVAIL. THE DEALERSHIP SERVICE DEPT PERSON FELT THIS WAS "NORMAL" THOUGH I CONTESTED THAT OPINION. THE VW PERSON, MR PERROTT, SAID HE COULDN'T EVEN LOOK INTO THE MATTER AS THE WORK WAS PERFORMED AT A NON VW DEALERSHIP, THOUGH IT WAS A CERTIFIED NAPA AUTOCARE SERVICE CENTER THAT DID THE REPAIR WORK. HE, MR PARROTT, ALSO STATED IF I HAD TAKEN IT IN TO A VW GARAGE WAS NO GUARANTEE THEY WOULD PAY FOR MY EXPENSES EITHER. I ASKED ABOUT "OPENING A CASE" W/VW AND HE SAID THE CONVERSATION WE WERE HAVING INITIATED IT AND WHEN I HUNG UP(I ASKED HIM ABOUT THIS) THAT THE CASE WOULD BE CLOSED, AS FAR AS THEY WERE CONCERNED. BUT NOT AS FAR AS I AM CONCERNED. *AK