2004 YAMAHA FZ6 Electrical System Problems

AT 9M MILES, MY 2004 YAMAHA FZ6 BEGAN TO EXHIBIT THE FOLLOWING: 1) AFTER APPROXIMATELY 30 MINUTES OF OPERATION, ERRATIC AND PROLONGED PERIODS OF ROUGH IDLE AT 500 RPMS INSTEAD OF THE NORMAL 1300 RPMS 2) MOTOR WOULD STALL DURING GEAR CHANGES, EVEN AT HIGHWAY SPEEDS 3) DURING THESE TIMES, THE SMELL OF GASOLINE WAS NOTICEABLE. CHANGING THE SPARK PLUGS SEEMED TO FIX THE PROBLEM TEMPORARILY, BUT THEY SOON REAPPEARED. AT 12M MILES, THE BIKE WAS TAKEN TO THE YAMAHA DEALER TO BE FIXED BUT THEY COULD FIND NOTHING WRONG WITH IT. I WENT NEXT TO AN INDEPENDENT MOTORCYCLE MECHANIC WHO ALSO COULD FIND NOTHING WRONG. HE SUGGESTED THAT IT WAS PROBABLY AN ELECTRICAL PROBLEM AND COULD BE EXPENSIVE TO FIX AND I SHOULD TAKE IT TO A DIFFERENT DEALER. HE ALSO QUESTIONED IF THE "CHECK-ENGINE" LIGHT HAD COME ON WHICH WOULD HAVE REGISTERED SPECIFIC TROUBLE CODES, BUT I TOLD...

THIS COMPLAINT IS IN REGARDS TO THE 2004 YAMAHA FZ6 THROTTLE POSITION SENSOR. AFTER THE MOTORCYCLE WARMS UP (APPROXIMATELY 50 MILES OF RIDING), IT WILL STALL OUT AND/OR SPUTTER WHEN THE CLUTCH IS ENGAGED AND/OR SHIFTED INTO NEUTRAL. LAST JULY IT STALLED OUT IN THE MIDDLE OF A RIGHT HAND TURN AROUND A RED LIGHT, RESULTING IN THE BACK TIRE LOOSING TRACTION AND CAUSING A CRASH. I WAS MINIMALLY INJURED, BUT THE BIKE SUFFERED SOME EXTERIOR DAMAGE. AFTER SOME RESEARCH I HAVE FOUND THAT THERE IS A PROBLEM WITH THE THROTTLE POSITION SENSOR. THIS PART WAS FIXED UNDER WARRANTY, BUT SEEMS TO BE AN ISSUE WITH MOST OWNERS OF THE 2004-05 FZ6.*JB

MOTORCYCLE RANDOMLY WILL NOT IDLE AND STALLS BETWEEN SHIFTS. HAS HAPPENED 5 OR 6 TIMES. DEALER SAYS DESCRIBED SYMPTOMS CANNOT NOT BE DIAGNOSED WITHOUT FAULT CODES. FAULT CODES ARE NOT STORED UNLESS CERTAIN "IDIOTIC LIGHTS" COME ON DURING FAILURE. *NM

BIKE STALLS WHEN CLUTCH IS PULLED IN. RPM'S DROP TO ZERO. WAS ALMOST RUN OVER BY TRAFFIC BEHIND ME WHEN ENGINE STALLS. INJURED MYSELF (FOOT/ANKLE) WHEN TRYING TO PUSH THE BIKE OFF THE ROAD (SO I WOULDN'T BE RUN OVER). I'VE BEEN TOLD BY MANY FZ6 RIDERS THAT MANY OF THE FZ6 BIKES HAVE DEFECTIVE THROTTLE POSITIONING SENSORS (TPS) AND THAT YAMAHA HAS NOT RECOGNIZED THE PROBLEM. I BELIEVE IT TO BE A VERY SERIOUS SAFETY ISSUE. SOONER OR LATER, SOMEONE IS GOING TO GET RUN OVER BECAUSE OF THIS DEFECTIVE SENSOR. *NM

2004 YAMAHA FZ6 5K+ MILES. WHEN CRUISING AND KEEPING THE ACCELERATOR CONSTANT, ONE EXPERIENCES SUDDEN CHANGES IN ENGINE-TO-TRANSMISSION POWER FEED: THE BIKE SUDDENLY STARTS TO ACCELERATE OR SLOW DOWN. ONE MUST COMPENSATE CONSTATNLY FOR THAT ERRATIC ENGINE BEHAVIOR, WHICH TAKES AWAY FROM PAYING ATTENTION TO THE ROAD. IF DOWNSHIFTING, UPSHIFTING OR CLUTCH DISENGAGEMENT IS PERFORMED DURING THE ENGINE FALTERING, THE RESULT IS A STALLED OUT ENGINE UNLESS SHIFTING IS PERFORMED VERY QUICKLY. STALLING OUT WHILE DOWNSHIFTING FOR A FULL STOP AT AN INTERSECTION GETS DICEY GIVEN THE AMOUNT OF OIL/WATER USUALLY FOUND AT STOP LINES AND THEIR APPROACHES. THIS PROBLEM TENDS TO APPEAR AFTER ABOUT 20-30 MINUTES OF ENGINE OPERATION AT ALL SPEEDS, TEMPERATURES OF ENGINE OPRATION. IT CLUTCH IS DISENGAGED, THE ENGINE IDELS DOWN TO 400-500 RMP (INSTEAD OF THE USUSAL 11-12K) AND INVARIABLY STALLS. STARTING THE BIKE RIGHT BACK DOES NOT ALLEVIATE THE SITUATION. THE ONLY REMEDY I...