2002 SUBARU WRX Suspension Problems

CONTROL ARMS WERE RECALLED IN 2011 FOR RUST ISSUES AND FAILURE ON THE HANGER BRACKETS. GOT THE PARTS CHECKED AT THE TIME OF THE RECALL BY A CERTIFIED SUBARU DEALERSHIP, THE DEALERSHIP SPRAYED A "RUST PROOFING" AGENT ON THE CONTROL ARMS. THREE YEARS LATER I WAS DRIVING DOWN MY ROAD AND LOST CONTROL OF THE VEHICLE COMPLETELY. THE DRIVER SIDE LOWER CONTROL ARM HAD RUSTED THROUGH AND BROKEN AT THE HANGER BRACKET. SUBARU OF AMERICA WILL NOT COVER THE REPAIRS AS THE RECALL HAD BEEN PERFORMED ALREADY (EVEN THROUGH IT DID NOT PREVENT THE ISSUES FROM HAPPENING). *JS

REFERENCE: RECALL NO. 11V-464, NHTSA CAMPAIGN NO. 11V464000 THE CORROSION DISCOVERED IN MY SUBARU 2002 WRX IS FAR MORE EXTENSIVE THAN THAT COVERED BY THE RECALL RESULTING IN CITYSIDE SUBARU DEALERSHIP (1-761-641-1900) IDENTIFYING THE VEHICLE NOT SAFE TO DRIVE. THEIR ASSESSMENT OF THE DANGEROUS RUSTING, ROTTING AND NECESSARY REPAIRS IS QUOTED HERE (I CAN PROVIDE A FACSIMILE OF THEIR ASSESSMENT UPON YOUR REQUEST). THERE IS EXTENSIVE RUSTING AND ROTTING AS WELL AS PARTS THAT HAVE ALREADY BROKEN. THE FOLLOWING IS QUOTED FROM THE CITYSIDE SUBARU DEALERSHIP INVOICE NUMBER[XXX]' TECHNICIAN STATES: VEHICLE HAS FAILED RECALL INSPECTION OF FRONT LOWER CONTROL ARMS DUE TO RUSTING. SUBFRAME IS ALSO ROTTED AND WILL NEED TO BE REPLACED. TECHNICIAN RECOMMENDS: ADDITIONALLY UPON REPLACEMENT OF CONTROL ARMS AND SUBFRAME BOTH LEFT AND RIGHT SWAYBAR LINKS ARE BROKEN $295 FRONT KNUCKLES, WHEEL BEARINGS AND INNER AND OUTER TIE ROD ENDS ARE ROTTED AND WILL NEED TO BE...

DRIVING SOUTHBOUND ON I-55 FOR MORNING COMMUTE IN THE LEFTMOST LANE WHEN WITH NO DISCERNIBLE CAUSE THE CAR BEGAN TO DRIFT BACK AND FORTH ACROSS THE CENTER LANE AND LEFT LANE. THE CAR MINIMALLY RESPONDED TO ANY STEERING INPUTS. I HAD TO CRANK THE WHEEL ALMOST A TURN AND A HALF TO GET MY CAR OVER TO THE SHOULDER. FORTUNATELY, THERE WERE NO CARS NEAR ME WHEN THIS HAPPENED SO I DID NOT STRIKE ANY VEHICLES. I GOT THE CAR TOWED TO A LOCAL SHOP AND THE SERVICE PERSON QUICKLY GLANCED AROUND UNDERNEATH IT AND IMMEDIATELY NOTICED THAT THE CONTROL ARM HAD RUSTED THROUGH ON THE PASSENGER SIDE. I CAME BACK LATER THAT DAY AND THEY SHOWED ME THE CAR ON THE LIFT WHERE BOTH CONTROL ARMS WERE THOROUGHLY RUSTED AS WELL AS THE SUBFRAME. I PAID TO GET THE ONE REPAIRED BUT STILL DON'T DRIVE THE CAR AS I...

I OWNED THE CAR FOR 5K MILES AND THE FRONT WHEEL BEARINGS ARE BAD. THIS IS AN EXPENSIVE REPAIR FOR A 2 YEAR OLD CAR. I SEARCHED THE INTERNET AND FOUND THIS TO BE A COMMON PROBLEM FOR SUBARUS. THE DRIVETRAIN IS NOISY, SO IT IS HARD TO DETECT DURING NORMAL DRIVING AND CAN REALLY DAMAGE THE CAR IF NOT FOUND. *JB