2005 NISSAN TITAN Engine Problems

Engine stalled while driving then would crank but not start

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 60 MPH, HE HEARD AN ABNORMAL SOUND COMING FROM THE VEHICLE. THERE WAS NO WARNING LIGHT ILLUMINATED. THE CONTACT CONTINUED DRIVING TO HIS DESTINATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE MANIFOLD GASKET NEEDING TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.

THEIR IS A CURRENT RECALL ON THE FUEL SYSTEM FOR THE GAUGE READING INCORRECTLY AND COULD CAUSE AN ACCIDENT. MY TRUCK IS HAVING THAT ISSUE, BUT MY VIN SHOWS NOT TO BE UNDER THAT RECALL. I AM ALSO HAVING ENGINE PROBLEMS THAT I ALSO BELIEVE TO BE DUE TO A FAILING FUEL PUMP OR POSSIBLY ONE OF THE OTHER MANY PROBLEMS WITH ENGINE PERFORMANCE ON THIS MODEL TITAN. I DON'T UNDERSTAND WHY THE RECALL FOR THE FUEL GAUGE PROBLEM IS NOT COVERING MY VEHICLE , I HAVE HAD MANY PROBLEMS WITH MY NISSAN TITAN SINCE I BOUGHT IT BRAND NEW AND ABSOLUTELY NO HELP FROM NISSAN TO FIX FAULTY PARTS, INCLUDING THE VALVE COVER THAT IF CLOGGED WILL ALLOW ENGINE OIL DOWN INTO THE VALVES AND CYLINDER AND CAUSE SMOKING PROBLEM, AND EVENTUALLY RUIN THE ENGINE CYLINDER. MY TITAN WILL NOT TAKE FUEL AND STARTS STALING OUT AT 2000 RPM...

CRACKED EXHAUST MANIFOLD FOUND BY DEALER ON AN INSPECTION BUT HAS BEEN CRACKED FOR SEVERAL YEARS. WHEN I RESEARCHED THE CRACK I FOUND IT TO BE AN ISSUE WITH NO RECALL.

FOR THE PAST THREE MONTHS, I'VE SPENT OVER $3,000 DIAGNOSING AND "FIXING" ERRONEOUS WARNING LIGHTS. THIS PAST WEEK, MY TRUCK (2005 TITAN) WOULD NOT START. THE FIRST TIME, IT JUST CRANKED THE STARTER, BUT WOULD NOT ENGAGE. NOW, I CAN TURN THE IGNITION TO START AND THE STARTER WON'T EVEN ENGAGE (NO "CLICKING" NOISE, NO NOISE WHATSOEVER). IT WILL START AFTER SEVERAL ATTEMPTS, BUT I HAVE TO WAIT AT LEAST 2-3 MINUTES BETWEEN EACH ATTEMPT. I'VE REPLACED THE ECM (AT MY OWN EXPENSE) AND IT STILL DOES NOT START PROPERLY. IT APPEARS (FROM READING ONLINE POSTS IN TITAN FORUMS) THAT THE ISSUE IS THE IPDM (INTELLIGENT POWER DISTRIBUTION MODULE). THE SYMPTOMS ALL LINE UP. I FEEL LUCKY THAT MY ENGINE HAS NOT COMPLETELY STOPPED WHILE DRIVING (YET). THIS IS AN UTTER HAZARD AND NEEDS TO BE ADDRESSED BEFORE SOMEONE LOSES THEIR LIFE BECAUSE NISSAN WILL NOT ADDRESS THE IPDM PROBLEM...

TAKITA RECALL I'M HAVING THIS PROBLEM SINCE I BOUGHT THIS VEHICLE TOOK IT BACK TO DEALER CALL NISSAN NOW A SOLUTION TO FIX ANY THING BASICALLY EVERY TIME I START MY VEHICLE IS MAKING A TICK TICK SOUND THOUGH IT WAS MY EXHAUST TOOK IT TO MY MECHANIC AFTER A PERIOD OF TIME HE FINALLY SAID IT WAS MANIFOLD IT HAS A CRACK I THINK IT'S A MANUFACTURER DEFECTIVE PART SO HERE I AM PLEASE HELP .NOTE 05 NISSAN TITAN LE...

DRIVER/ PASSENGER SIDE EXHAUST MAINIFOLDS CRACKING EVERY 20,000 MILES CAUSING EXHAUST LEAKS IN CAB OF TRUCK..

THE IPDM (INTELLIGENT POWER DISTRIBUTION MODULE HAS FAILED FOUR TIMES ON THIS VEHICLE. WHEN FAILURE OCCURS THE VEHICLE WILL STALL, NOT CRANK,AND RUNS ROUGH. THIS HAS HAPPENED IN TRAFFIC MANY TIMES WITH THESE FAILURES. THIS CREATES A HAZARDOUS SITUATION. I NEVER KNOW WHEN THIS FAILURE IS GOING TO OCCUR. THERE SEEMS TO BE SOMETHING CAUSING THESE PREMATURE FAILURES OF THIS MODULE.

WHEN EXITING HIGHWAY ENGINE QUIT RUNNING. FUEL TANK SHOWED 1/4 TANK LEFT. HIGHWAY SUPPORT VEHICLE STOP TO HELP, GAVE ME SOME GAS, ABOUT 1 GALLON. STILL WOULD NOT START, HAD VEHICLE TOWED. PUT 2 MORE GALLONS OF FUEL IN TANK, VEHICLE STARTED. FOUND A NHTSA CAMPAIGN ID NUMBER 10V074000, FOR 2005-2009 TITAN'S FOR THIS EXACT SAME PROBLEM, BUT FOR SOME REASON MY TITAN IS NOT COVERED EVEN THOUGH IT'S A 2005. I HAVE CALLED MY LOCAL DEALER AND NISSAN CUSTOMER SERVICE WITH NO HELP. JUST ASKING WHY MY TITAN IS NOT COVERED? I HAVE UPLOADED A FILE OF THE CAMPAIGN ID NUMBER.

I TOOK MY TRUCK TO YOUNGBLOOD NISSAN IN SPRINGFIELD AND THEY SAID THAT THEY CANT FIXED MY RECALL BECAUSE OF THE LINES WERE RUSTED SOMETHING LIKE THAT AND IS GOING TO CHARGE ME 1200.00 BUT THE RECALL SHOULD COVERIT

WHILE DRIVING ONE THE HIGHWAY I NOTICED MY VEHICLE START TO SHUTTER AND SHUT DOWN AS IF IT RAN OUT OF GAS. MY FUEL GAUGE SAID HALF A TANK SO I DIDN'T THINK IT WAS THE PROBLEM UNTIL I WALKED TO THE GAS STATION TO FILL UP A GAS CAN. I PUT 2 GALLONS OF GAS INTO MY FUEL TANK THAT SAID I HAD A HALF A TANK. I STARTED MY TRUCK AND IT STARTED. SINCE THAT INCIDENT IT HAS HAPPENED 3 TIMES, THE MOST RECENT BEING YESTERDAY 07/02/18. I REPLACED THE FUEL PUMP TODAY IN HOPES THAT IT FIXES THE PROBLEM.

2005 NISSAN TITAN 121K MILES. CRACKED EXHAUST MANIFOLD CAUSING A EXHAUST LEAK. THERE IS A STRONG EXHAUST SMELL IN THE CAB WHEN TRAVELING AT SLOWER SPEEDS (UNDER 35MPH). IT HAS BEEN SO BAD AT TIMES IT MAKES YOU LIGHT HEADED AND SICK TO YOUR STOMACH. THIS COULD CAUSE SOMEONE TO PASS OUT WHILE DRIVING CAUSING THEM TO LOOSE CONTROL OF THEIR VEHICLE. DEFIANTLY A SAFETY HAZARD! ALSO CAUSING A DECREASE IN GAS MILEAGE AS WELL AS A LOUD KNOCKING/PUFFING NOISE UPON ACCELERATION. I HAVE SEARCHED THE INTERNET FINDING 100'S IF NOT 1000'S OF COMPLAINTS ABOUT THIS! WHY HAS THIS NEVER BEEN RECALLED? THE SAFETY ISSUE ALONE SHOULD WARRANT A RECALL, ITS OBVIOUSLY A FAULTY COMPONENT!

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A DEALER (RIVERHEAD NISSAN, 1800 OLD COUNTRY RD, RIVERHEAD, NY 11901, (631) 369-0600) WHO STATED THAT THEY REPAIRED THE VEHICLE WITH A WARRANTY REPAIR CONCERNING THE EXHAUST MANIFOLD. THE CONTACT REPORTED TO THE DEALER AND THE MANUFACTURER THAT THE REPLACEMENT PART FAILED AGAIN AND WAS UNCERTAIN IF THE MANUFACTURER WOULD PROVIDE A SOLUTION WITH NO RECALL CAMPAIGN. THE WARRANTY REPLACEMENT PART PROVIDED NO SOLUTION AND, A FEW YEARS LATER, THERE WAS A CRACK AND LEAK WHICH FROM THE EXHAUST MANIFOLD. IN ADDITION, THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V517000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISOCNNECT.

EXHAUST MANIFOLD CRACKED AT LESS THAN 85000 MILES

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO MELLOY NISSAN (LOCATED AT 7707 LOMAS BLVD NE, ALBUQUERQUE, NM 87110) WHERE IT WAS DIAGNOSED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE CONTACT REPAIRED THE VEHICLE HIMSELF; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE LOST POWER WHILE AT A STOP. THERE WERE NO WARNING INDICATORS ILLUMINATED. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE RADIATOR AND TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 134,000.

MY NISSAN TITAN HAS ROUGHLY 31,000 MILES ON IT OVER THE LAST 12 YEARS . THE EXHAUST MANIFOLD IS CRACKED . I DID A SEARCH TO SEE IF THIS WAS A KNOWN PROBLEM AND THERE ARE TONS OF COMPLAINTS AND PICTURES ON THE INTERNET SO I WAS AMAZED TO SEE THAT THERE ARE NO RECALLS . MANY PEOPLE HAVE HAD THE ISSUE TAKEN CARE OF UNDER THE 8 YEAR 80,000 MILE EMISSIONS WARRANTY . THE ONLY PROBLEM IS MANY PEOPLE ( INCLUDING MYSELF ) ARE PAST THE 8 YEARS EVEN THOUGH WAY UNDER THE MILEAGE . MY TRUCK IS PRACTICALLY BRAND NEW INSIDE AND OUT AND HAS BEEN SPARINGLY USED AND STILL NOW I HAVE HARMFUL EXHAUST FUMES LEAKING OUT AND THE TRUCK IS ROBBED OF POWER .

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT OBSERVED AN ABNORMAL ODOR INSIDE THE VEHICLE WITHOUT WARNING. IN ADDITION, THE CONTACT NOTICED A FRACTURE WITHIN THE EXHAUST MANIFOLD/PIPES, WHICH LEAKED FUMES BACK INTO THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 189,963.

CRACKED EXHAUST MANIFOLDS. NISSAN HAS A POOR DESIGN AND I HAVE CHECKED ON LINE AND 100'S OF OTHERS HAVE COMMENTED ABOUT THE CRACKED EXHAUST MANIFOLDS. THESE ARE A SAFETY CONCERN AS I CAN SMELL THE EXHAUST GAS AROUND THE FRONT OF THE TRUCK, INSTEAD OF IT BEING PROPERLY TRANSFERRED OUT THE EXHAUST SYSTEM AS DESIGNED. NISSAN IS NOT SUPPORTING THE REQUIRED REPLACEMENT WHICH SHOULD BE FREE. THE REPAIR COST ARE IN THE THOUSANDS NOT ACCEPTABLE WHEN IT IS NISSAN POOR DESIGN ALL ALL TRUCKS WITH THESE MANIFOLDS ARE AFFECTED.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 45 MPH, THE ENGINE STALLED WITHOUT WARNING THE FAILURE WAS PERSISTENT. THE CONTACT ALSO STATED THAT THE VEHICLE FAILED TO INCREASE SPEED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 122,000. UPDATED 04/10/17 LJ *CN

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE EXHAUST MANIFOLD WAS LEAKING FUMES IN THE ENGINE COMPARTMENT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE EXHAUST MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE AT ANY SPEED, THE VEHICLE LEAKED FUEL AND EXHAUST FUMES EMITTED. THE VEHICLE WAS DRIVEN TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE MILEAGE WAS 63,000.

"TAKATA RECALL" CRACKED MANIFOLDS BANK 1

EXHAUST MANIFOLD CRACKED AT ABOUT 75,000 MILES.

THE EXHAUST MANIFOLDS ARE FAULTY AND CRACK ALLOWING DEADLY CARBON MONOXIDE EXHAUST GASES TO ENTER THE CAB OF THE TRUCK WHILE THE VEHICLE IS IN OPERATION. THIS COULD CAUSE THE DRIVER TO LOSE CONSCIOUSNESS AND CRASH. IT WAS ONLY AFTER MY 6TH LONG ROAD TRIP (3+ HOURS DRIVING) DID I DISCOVER I WAS BEING POISONED BY CARBON MONOXIDE. I TOOK MY TRUCK TO AN EXHAUST REPAIR COMPANY AND AS SOON AS I MENTIONED MY VEHICLE THE TECHNICIAN TOLD ME HE WAS 99% SURE I HAD A CRACKED MANIFOLD. HE LATER CONFIRMED THIS WITH A DIAGNOSTIC TEST WHICH REVEALED BOTH MANIFOLDS CRACKED AND LEAKING EXHAUST FUMES INTO THE CAB. THIS COULD HAVE KILLED ME JUST SITTING IN A PARKING LOT! I THOUGHT I WAS JUST GETTING BAD HEADACHES FROM THE LONG DRIVE AND MY NAUSEA WAS FROM THE EXTREME HEADACHES. AFTER THIS HAPPENING SO MANY TIMES I KNEW THERE HAD TO...

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THERE WERE FUMES COMING FROM THE VEHICLE CAUSING THE CONTACT TO BECOME NAUSEOUS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WERE TWO CRACKS ON THE MANIFOLD AND IT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 155,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING, THERE WAS AN ABNORMAL NOISE COMING FROM THE EXHAUST MANIFOLD. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE EXHAUST MANIFOLD AND THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.

HI, I HAVE A 2005 NISSAN TITAN AND THE EXHAUST MANIFOLD HAS CRACKED IN THE SAME SPOT TWICE NOW AND IT IS BEFORE THE CAT SO THAT MEANS ITS NOW A GROSS POLLUTER. THE PROBLEM IS YOU GET IT FIXED AND THEY PUT THE SAME PART BACK ON THAT CRACKS AGAIN BECAUSE THEY HAVEN'T CHANGED THE DESIGN. THERE ARE 3 OTHER TITANS IN MY TOWN AND ALL OF US HAVE THE SAME STORY. ALSO THE SWAY BAR MOUNT ON ALL OF OURS ARE BROKE WITCH RESULTS IN VERY POOR HANDLING. I HOPE IT CAN BE RECALLED BEFORE SOMETHING SERIOUS HAPPENS. THANK YOU.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE TRAVELING 40 MPH, THE VEHICLE STALLED AND THE BRAKES AND STEERING SEIZED. THE CONTACT STATED THAT THE FAILURE RECURRED THREE TIMES IN A FIVE MILE SPAN AND NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS DETERMINED THAT THE ELECTRONIC CONTROL MODULE FAILED. THE DEALER STATED THAT THERE WAS A RECALL FOR THE ECM UNDER NHTSA CAMPAIGN NUMBER: 10V517000 (ENGINE AND ENGINE COOLING); HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 124,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THERE WAS A STRONG ODOR OF FUEL PRESENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEED, THE ENGINE STALLED WITHOUT ANY WARNINGS. THE CONTACT MENTIONED THAT THE VEHICLE WAS EXHIBITING THE SAME FAILURES LISTED IN RECALL NHTSA CAMPAIGN NUMBER: 10V517000 (ENGINE AND ENGINE COOLING). THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE ENGINE CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 137,000.

THE OTHER DAY I WAS SITTING IN TRAFFIC FOR ALMOST 30 MIN STOPPED WITH THE ENGINE RUNNING (LOTS OF CHRISTMAS TRAFFIC ON THE 5 SOUTH FREEWAY), I PUT THE TRUCK IN PARK BECAUSE I NOTICE AN ACCIDENT. I HAD MY WINDOWS UP AND MY CABIN AIR ON. THEN A FEW MIN LATER I STARTED FEELING DIZZY ALMOST FAINTING. THE CAR NEXT TO ME SAW THAT I WAS STRUGGLING, CAME TO MY WINDOW AND ASKED ME IF I WAS OK. I ROLLED DOWN MY WINDOW AND HE NOTICED THE SMELL OF EXHAUST INSIDE MY TRUCK. AFTER MY HEADACHE WENT AWAY. I WENT TO THE DEALERSHIP AND THEY TOLD ME BOTH OF MY EXHAUST MANIFOLDS WERE CRACKED AND THAT'S HOW THE EXHAUST WAS ENTERING NEAR THE FRONT CABIN. *TR

WHILE DRIVING DOWN THE HIGHWAY THE TRUCK STALLED AND LOST ALL POWER. AFTER GETTING TO THE SHOULDER OF THE HIGHWAY, THE TRUCK STILL HAD BATTERY POWER AND WANTED TO CRANK TO START BUT ACTED LIKE IT WASN'T GETTING GAS. AFTER CALLING AROUND WE DETERMINED THRU A NISSAN SERVICE ADVISOR THAT WE SHOULD TRY FILLING THE TANK WITH GAS, EVEN THOUGH I WAS TELLING HIM IT READ BETWEEN A QUARTER AND HALF A TANK. AFTER PUTTING IN 5 GALLONS AND TURNING THE KEY AND CRANKING IT A FEW SECONDS, IT STARTED RIGHT UP. IT HAS DONE THIS AT VARIOUS TIMES SINCE THIS FIRST OCCURRENCE AND CONTINUES TO VARY. I NOW HAVE TO KEEP NO LESS THAN HALF A TANK OF GAS AT ALL TIMES OR I WILL SUDDENLY LOSE POWER AND HAVE TO PULL OFF. NISSAN HAS A VOLUNTARY SAFETY RECALL CAMPAIGN 2005-2009 ARMADA AND TITAN FUEL GAUGE INACCURACY, CAMPAIGN ID#R1010...

EXHAUST FUMES IN CABIN DUE TO CRACKED EXHAUST MANIFOLDS. I ONLY USE THE TRUCK FOR FAMILY TRIPS, AND ON THE LAST TRIP I NOTICES A TICKING NOISE COMING FROM THE ENGINE, ESPECIALLY WHEN COLD, I ALSO NOTICED EXHAUST FUMES IN THE CABIN WHEN THE TRUCK WAS AT A LIGHT OR A LONG STOP SIGN. I AM THE FIRST OWNER OF THIS TRUCK AND AFTER SOME RESEARCH IT LOOKS LIKE THIS IS A COMMON PROBLEM WITH NISSAN TITANS BUT THE WORST PART IS THAT THE REPLACEMENTS HAVE THE SAME ISSUE, SO NOW I CAN NOT USE THIS VEHICLE. LOOKING TO SEE WHAT IS THE BEST PERMANENT SOLUTION. *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STARTED TO MAKE A TICKING NOISE AND FUMES EMITTED INTO THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND FOUND THE CATALYTIC CONVERTER WAS PLACED NEXT TO THE EXHAUST MANIFOLD CAUSING THE EXHAUST MANIFOLD TO FRACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 70,112.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE TRAVELING 55 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER A REMEDY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 91,000.

WAS ACCELERATING AFTER COMING TO A STOP AT A STOP SIGN. GOT UP TO ABOUT 15 MPH WHEN ALL OF A SUDDEN THE ENGINE DIED IN THE MIDDLE OF TRAFFIC. TRIED TO RESTART BUT COULD NOT. COASTED INTO A SIDE STREET. FUEL GAUGE INDICATED THAT THE VEHICLE STILL HAD 1/8 OF A TANK OF FUEL. AFTER PUTTING IN ABOUT A HALF OF A GALLON OF GASOLINE WAS ABLE TO GET TO A GAS STATION. ONCE TRUCK WAS FULL IT RAN WITH NO PROBLEM. A WEEK LATER I RAN THE FUEL DOWN TO THE SAME AMOUNT (1/8) WHERE THE TRUCK HAD DIED BEFORE. THIS TIME I HAD A SPARE GAS CAN WITH ME. THE VEHICLE DIED AGAIN. *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THERE WAS A FUEL ODOR PRESENT INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE EXHAUST MANIFOLD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THERE WERE STRONG FUMES EMITTING FROM THE VEHICLE UNDERNEATH THE HOOD WHICH ENTERED THROUGH THE AC OR HEATING SYSTEM INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE EXHAUST MANIFOLD NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED AND THE FAILURE RECURRED. THE CONTACT CONTINUED TO SMELL STRONG FUMES INSIDE THE VEHICLE INTERMITTENTLY. THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE EXHAUST MANIFOLD NEEDED TO BE REPLACED AGAIN. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT EXHAUST FUMES WERE EMITTED INTO THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE EXHAUST MANIFOLD FAILED. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE EXHAUST MANIFOLD TAIL PIPE WAS FRACTURED DUE TO DEFECTIVE WELDING AND CAUSED THE TAIL PIPE TO MELT THE REAR BRAKE WIRES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 88,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR AXLE LEAKED ONTO THE BRAKES AND THE EXHAUST MANIFOLD WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE MANIFOLD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A MANUFACTURER'S RECALL FOR THE SUSPENSION. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 12,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 60 MPH, THE WARNING LIGHT ILLUMINATED AND THE CONTACT SAW A CRACK IN THE MANIFOLD. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THE VEHICLE BEGAN LOOSING POWER AND THE EXHAUST MANIFOLD WAS CRACKED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND IT WAS DETERMINED THAT BOTH THE LEFT AND RIGHT MANIFOLDS NEEDED TO BE REPLACED BECAUSE OF A LEAK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 160,000.

FOR THE LAST YEAR I HAD HEARD A NOISE THAT SOUNDED LIKE AN EXHAUST LEAK. SMELLED FUMES INSIDE THE CAR. DEALER CONFIRMED MANIFOLD WAS CRACKED, BUT SINCE THE CAR HAD 82000 MILES ON IT, THEY WOULD NOT REPLACE IT. *TR

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE INTERIOR CABIN WOULD BECOME FILLED WITH EXHAUST FUMES. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING AND WAS ADVISED THAT THE EXHAUST MANIFOLD WAS DEFECTIVE. THE DEALER REPLACED THE EXHAUST MANIFOLD BUT THE REPAIR DID NOT REMEDY THE ISSUE. THE DEALER REPLACED THE EXHAUST MANIFOLD FIVE MORE TIMES BUT THE DEFECT WAS NOT REMEDIED. THE FAILURE MILEAGE WAS 170,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE EMITTED A LOUD NOISE. UPON INSPECTION, IT WAS FOUND THAT THE EXHAUST MANIFOLD WAS CRACKED. THE CONTACT ALSO MENTIONED THAT EXHAUST FUMES WERE SMELLED WHILE IN THE CABIN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 112,000.

VEHICLE EXHAUST MANIFOLDS ON BOTH SIDES CRACKED. *TR

EXHAUST MANIFOLD CRACKS. THE EXHAUST MANIFOLDS ON NISSAN TITANS ARE DEFECTIVE. IT IS WELL DOCUMENTED THAT THE MAJORITY OF OWNERS OF TITANS HAVE, HAD OR WILL HAVE THE ISSUE OF A CRACKED EXHAUST MANIFOLD. THIS IS A DANGEROUS SITUATION, AS AN EXHAUST LEAK COULD INTRODUCE CARBON MONOXIDE INTO THE CABIN AREA WITH IS LETHAL. THERE ARE FORUMS THAT THIS ISSUE IS DISCUSSED WELL IN DETAIL REQUIRING THE OWNER TO FOOT THE BILL FOR REPLACEMENT AT A PRICE AROUND $2500.00. IF YOU CONTACT NISSAN, THEY WILL NOT ACKNOWLEDGE THAT IT IS A DEFECT, EXCEPT IN REALITY THEY KNOW BECAUSE THEY HAVE MADE SUBSEQUENT CHANGES ON NEWER MODELS TO ADDRESS THE ISSUE. THEY DON'T WANT TO TAKE RESPONSIBILITY FOR EARLIER MODELS. YOU WILL NOT KNOW IF CARBON MONOXIDE HAS ENTERED THE CABIN AND COULD KILL YOU IN MINUTES. THIS IS A SERIOUS SAFETY ISSUE. A RECALL NEEDS TO BE ISSUED IN ORDER...

THE PASSENGER SIDE EXHAUST MANIFOLD DEVELOPED A CRACK AND LEAKS EXHAUST FUMES. WE HAD THE TRUCK INTO THE DEALERSHIP SEVERAL TIMES COMPLAINING OF AN EXHAUST LEAK; HOWEVER, THE SERVICE DEPARTMENT ADVISED THEY COULD NOT LOCATE ANY LEAKS. WE HAD A FAMILY MEMBER, WHO IS A MECHANIC, LOOK AT THE TRUCK RECENTLY AND HE LOCATED THE CRACK IN THE UNDERSIDE OF THE EXHAUST MANIFOLD. THIS CONDITION COULD LEAK EXHAUST FUMES INTO THE PASSENGER COMPARTMENT OF THE VEHICLE CAUSING A DANGEROUS SITUATION. *TR