1995 NEW FLYER D60HF — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
4
Recalls
1
Service Bulletin
0
Investigations
Overview of the 1995 NEW FLYER D60HF
The 1995 NEW FLYER D60HF has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 4 recall campaigns affecting this vehicle, covering issues with STEERING, WHEELS, EXTERIOR LIGHTING. 1 technical service bulletin have been issued by NEW FLYER INDUSTRIES LTD for this model year.
Recalls for the 1995 NEW FLYER D60HF
NHTSA has recorded 4 recalls for the 1995 NEW FLYER D60HF, potentially affecting up to 5,678 vehicles.
Recall 07V268000 — STEERING
| 1,768 vehicles affected
Defect: ON CERTAIN TRANSIT BUSES, THE U-JOINT ASSEMBLIES HAVE INADEQUATE SPLINE ENGAGEMENT ON ONE OF THE TWO END YOKES.
Consequence: EXCESSIVE PLAY IN THE STEERING SYSTEM COULD DEVELOP AND, IF NOT CORRECTED, CAUSE A LOSS OF STEERING CONTROL WHICH COULD RESULT IN A CRASH.
Remedy: THE U-JOINT ASSEMBLY WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JUNE 10, 2007. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4874.
View full details →Recall 04V042000 — WHEELS
| 782 vehicles affected
Defect: ON CERTAIN TRANSIT BUSES, THE CENTER AXLE WHEEL END BRAKES MAY NOT RELEASE AFTER BEING PARKED FOR AN EXTENDED PERIOD OF TIME.
Consequence: THE DRIVER COULD LOSE CONTROL OF THE VEHICLE WHEN DRIVING AWAY FROM A PARKED POSITION, WHICH COULD RESULT IN A CRASH.
Remedy: NEW FLYER WILL INSTALL AN ADDITIONAL AIR SYSTEM R14 RELAY VALVE, #4 NOTCH AUTOMATIC SLACK ADJUSTERS, AND TYPE 30 LONG STOKE BRAKE CHAMBERS ON THE CENTER AXLE; THE LOGIC CONTROL MODULE WILL BE REPROGRAMMED, ADD NEW ABS COMPONENTS (SENSORS, SPEED...
View full details →Recall 07V068000 — EXTERIOR LIGHTING
| 1,707 vehicles affected
Defect: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES.
Consequence: THE STANDARD REQUIRES THAT THE DECELERATION LAMP IS A SOLID LIGHT RATHER THAN A FLASHING LIGHT.
Remedy: DEALERS WILL REWIRE THE ELECTRICAL SYSTEM TO REMOVE THE FLASHING FUNCTION OR INSTALL A NEW PROGRAMMABLE LOGIC CONTROLLER (PLC) WHICH WILL MAKE THE LAMPS BURN STEADY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2007. OWNERS MAY CONTACT NEW...
View full details →Recall 07V012000 — EQUIPMENT ADAPTIVE/MOBILITY
| 1,421 vehicles affected
Defect: ON CERTAIN TRANSIT BUSES EQUIPPED WITH LIFT-U WHEELCHAIR LIFTS, IT IS POSSIBLE FOR A PERSON TO WEDGE THEIR FEET UNDER THE SOLID BAR BARRIER LINKAGE.
Consequence: WHILE SITTING IN A WHEEL CHAIR A PERSON WITH NO SHOES AND DOES NOT HAVE CONTROL OF THEIR FEET, COULD TWIST THEIR FEET AND GET IT FORCED UNDER THE LINKAGE WHICH COULD RESULT IN AN INJURY.
Remedy: LIFT-U IS CONDUCTING THIS RECALL (PLEASE SEE 06E-093). OWNERS WILL RECEIVE A FREE REPAIR KIT ALONG WITH INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNERS MAY CONTACT LIFT-U AT 209-838-2400 OR NEW FLYER AT 204-934-4876.
View full details →Owner Complaints for the 1995 NEW FLYER D60HF
No complaints have been filed with NHTSA for the 1995 NEW FLYER D60HF.
Safety Rating for the 1995 NEW FLYER D60HF
NHTSA has not yet tested the 1995 NEW FLYER D60HF in its New Car Assessment Program.
Technical Service Bulletins for the 1995 NEW FLYER D60HF
NEW FLYER INDUSTRIES LTD has issued 1 technical service bulletin (TSBs) for the 1995 NEW FLYER D60HF. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
1749B — POWER TRAIN:AXLE ASSEMBLY
INFORMATION ON REPLACING THE SPIGOT BEARINGA ND GEAR-TO-CASE BOLTS ON HF REAR DIFFERENTIAL ON D60HF MODELS. *TT
NHTSA Investigations for the 1995 NEW FLYER D60HF
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the NEW FLYER D60HF
- 1990 NEW FLYER D60HF — 0 complaints
- 1991 NEW FLYER D60HF — 0 complaints
- 1992 NEW FLYER D60HF — 0 complaints
- 1993 NEW FLYER D60HF — 0 complaints
- 1994 NEW FLYER D60HF — 0 complaints
- 1995 NEW FLYER D60HF (current)
- 1996 NEW FLYER D60HF — 0 complaints
- 1997 NEW FLYER D60HF — 0 complaints
- 1998 NEW FLYER D60HF — 0 complaints
- 1999 NEW FLYER D60HF — 0 complaints
- 2000 NEW FLYER D60HF — 0 complaints
Other NEW FLYER Models
- NEW FLYER XD60 — 5 total complaints
- NEW FLYER D40LF — 4 total complaints
- NEW FLYER XT40 — 3 total complaints
- NEW FLYER D60LFR — 2 total complaints
- NEW FLYER GE40LF — 2 total complaints
- NEW FLYER C40FLR — 1 total complaint
- NEW FLYER C40LF — 1 total complaint
- NEW FLYER XCELSIOR — 1 total complaint