2002 MERCURY SABLE Suspension Problems

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT WHILE REVERSING OUT OF THE DRIVEWAY, THE FRONT DRIVER'S SIDE TIRE EXPLODED. THE SUSPENSION COIL SPRING ON THE DRIVER'S SIDE FRACTURED AND SLASHED THE TIRE CAUSING THE TIRE TO EXPLODE. THE CONTACT STATED THAT THE SUSPENSION NEEDED TO BE REPLACED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC BUT WAS NOT DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 37,500.

ON 2/6/2017 MY 2002 MERCURY SABLE WAGON WITH 63512 MILES ON IT THE FRONT SPRING BROKE TORE THE INSIDE OF TIRE APART NOT SURE WHAT ELSE WAS DAMAGED AT THIS POINT . MY CAR BEING IN VERY GOOD CONDITION NOT YOUR TYPICAL N.Y RUST NOT A ISSUE THIS IS A VERY DANGEROUS DESIGN DEFECT.

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. UPON STARTING THE VEHICLE, IT WOULD NOT MOVE. THE FAILURE OCCURRED WITHOUT WARNING. UPON INSPECTION, THE FRONT COIL SPRINGS FRACTURED AND DETACHED, DAMAGING THE FRONT DRIVER SIDE TIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 04V332000 (SUSPENSION), BUT THE VIN WAS EXCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000.

OUR 2002 SABLE WAS BROUGHT IN FOR AN EMERGENCY BRAKE CABLE ISSUE. WHILE WORKING ON THE REAR BRAKES, THE MECHANIC NOTICED THAT A REAR SUSPENSION SPRING WAS BROKEN. HE SAID WE WERE VERY LUCKY IT DID NOT RUPTURE THE TIRE. WE HAD BOTH REAR SPRINGS REPLACED, BECAUSE WE DID NOT KNOW WHAT CAUSED IT TO BREAK. AFTER THAT WORK WAS DONE THE CAR NEEDED TO BE ALIGNED, AND THAT IS WHEN THEY NOTICED THAT A FRONT SUSPENSION SPRING WAS EVEN MORE SEVERELY BROKEN THAT IS WHEN WE SEARCHED FOR POSSIBLE BULLETINS OR RECALLS. THERE WERE MANY COMPLAINTS ABOUT 2002 SABLE SPRING BREAKAGE, AND SOME ACTUALLY RUPTURING TIRES. THERE IN FACT WAS A RECALL ISSUED FOR 2001 MERCURY SABLES WITH SPRING BREAKAGE PROBLEMS, BUT NOT FOR 2002S. WE KNOW IN FACT THAT THE SAME PART IS USED ON 2001 AND 2002S. SO, FOR SAFETY REASONS WE HAD NO CHOICE BUT TO...

APPROXIMATELY 39,000 MILES. NO RUST CAR. RUBBING NOISE AND ALL TIRES WITH HISTORY OF LOSING AIR. WHILE REPLACING ALL TIRES, WHEEL TECH NOTICED RIGHT REAR COIL SPRING WAS FRACTURED AND COMPLETELY WORE OFF INTERIOR TIRE RIDGE. PLACED DOUGHNUT TIRE ON AND ADVISED I TAKE TO MECHANIC TO HAVE ALL SPRINGS FULLY CHECKED. CAR CURRENTLYAT MECHANIC SHOP THIS EVENING. RIGHT REAR COIL SPRING DEFINITELY FRACTURED. SEEMS MANY REPORTS OF SAME NATURE ON THIS MODEL. WHY NO RECALL ON REAR COIL SPRINGS WITH SO MANY COMPLAINTS? RUBBING SOUND FROM BENEATH CAR HAS BEEN NOTED AND TIRES CONSTANTLY NEEDED AIR. OTHER ISSUE(S): 1) IGNITION EXTREMELY HARD TO TURN.2) ACCELERATOR SEEMS TO STICK UPON ATTEMPTING TO DECELERATE BY LETTING UP FOOT PRESSURE. I INHERITED THIS CAR FROM MY DECEASED FATHER. I WAS ALWAYS CONCERNED THAT HE ACCELERATED TOO QUICKLY FROM A STOPPED POSITION. FATHER TOOK DOWN A LARGE CONCRETE PLANTER DUE TO THIS TYPE...

AS I WAS BACKING MY CAR OUT OF THE DRIVEWAY, I HEARD A NOISE AND THEN A HISS. THEN THE CAR RESISTED FURTHER MOTION. THE RIGHT FRONT TIRE WAS COMPLETELY FLAT. I TRIED TO REINFLATE IT BUT COULD NOT. I REMOVED THE FRONT WHEEL AND MOUNTED THE MINI SPARE TIRE. THERE WAS A COMPLETE CIRCUMFERENTIAL TEAR OF THE TIRE SIDEWALL NEAR THE TREAD. I ASSUMED IT WAS A SPONTANEOUS FAILURE OF THE TIRE. WHEN I BOUGHT NEW TIRES TODAY AT COSTCO, THE MECHANIC SAID HE COULD NOT PUT THE RIGHT FRONT WHEEL ON THE CAR BECAUSE A PIECE OF BROKEN SPRING WAS PROJECTING OUTBOARD AND HITTING THE SIDEWALL OF THE NEW TIRE. INSPECTION SHOWED THE LEFT FRONT COIL SPRING WAS ALSO BROKEN BUT THE POINTED END WAS AIMED INWARD. THE INFERIOR COIL WAS BROKEN OFF AND WAS LOOSE BUT COULD NOT BE EASILY REMOVED FROM THE STRUT. I TOLD THE...

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, A TIRE BECAME FLAT WITHOUT WARNING. THE CONTACT DID NOT SPECIFY WHICH TIRE BECAME FLAT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER AND DRIVER SIDE COIL SPRING WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. WHILE DRIVING IN REVERSE. THE FRONT PASSENGER SPRING AND STRUT FRACTURED. THE CONTACT MENTIONED THAT THE FRONT PASSENGER WHEEL WAS DAMAGED DUE TO THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN VERIFIED THE FAILURE OF THE FRONT PASSENGER SPRING AND STRUT. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 112,867.

PER EA08018 FRONT RIGHT COIL FRACTURED UPON BACKING UP, RIPPED DEEP HOLE IN NEWER TIRE CAUSING FLAT. *TR

WHILE VEHICLE WAS SITTING UNATTENDED IN A PUBLIC PARKING LOT THE DRIVERSIDE COILOVER SPRING FAILED. THE RESULTS WAS SUSPENSION AND TIRE DAMAGE TOTALING THE VEHICLE. *TR

AS I TRIED TO PULL FORWARD FROM A PARKING SPOT, I NOTICED THE VEHICLE WOULD NOT HARDLY MOVE FORWARD, AND A VERY LOUD GROANING NOISE WAS PRESENT. I COULD NOT TURN THE WHEEL, AND AS I TRIED TO BACK UP, I HEARD A LOUD POP. UPON FURTHER INSPECTION, I NOTICED THAT THE LEFT FRONT TIRE HAD BLOWN, AND THE LEFT FRONT SPRING WAS BROKEN AND STICKING INTO THE TIRE ON THE INSIDE! THE SPRING DID NOT LOOK RUSTY OR EXCESSIVELY DIRTY. *TR

BACKED THE SABLE TO THE END OF MY DRIVEWAY, WAS MOVING VERY SLOWLY, WHEN A LOUD BANG WAS HEARD UNDER THE CAR. UPON INSPECTION, THE DRIVERS SIDE FRONT COIL SPRING HAD BROKEN AND A JAGGED EDGE OF THE BROKEN COIL SPRING PUNCTURED THE TIRE. I CONTACTED MY LOCAL DEALER WHO SAID THERE WAS NO RECALL ON THE SPRING FOR THIS YEAR AND MODEL. I THEN DID SOME RESEARCH ON THE INTERNET AND DISCOVERED THAT THIS IS A FAIRLY COMMON OCCURRENCE ON THIS CAR AND THE SIMILAR FORD TAURUS. *TR

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, AN ABNORMAL NOISE FROM THE FRONT END OF THE VEHICLE. THE CONTACT INDICATED THAT THE DRIVER'S SIDE COIL SPRING WAS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT NOTIFIED THE MANUFACTURER OF THE DEFECT BUT NO SOLUTION WAS OFFERED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE NHTSA CAMPAIGN 04V332000 (SUSPENSION) THE CONTACT STATED THE VEHICLE EXPERIENCED THE SAME DEFECT LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 109,000.

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT WHILE BACKING THE VEHICLE OUT OF THE GARAGE, THE FRONT DRIVER'S SIDE SUSPENSION COIL SPRING SUDDENLY FRACTURED AND PUNCTURED THE SIDE TIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 105,000. *TR

I MOVED THE CAR IN MY DRIVEWAY AND THE LEFT FRONT SPRING BROKE AND WENT THROUGH THE TIRE SIDEWALL. IF THIS HAD HAPPEN AT HIGHWAY SPEED OR EVEN LESS THE CAR COULD HAVE GONE OFF THE ROAD AND ROLLED. I HAD THE CAR TOWED AND THE TRUCK DRIVER TOLD ME THIS WAS A COMMON PROBLEM. HE SAID HE RAN INTO A COUPLE TIME A MONTH. I CALLED FORD AND THEY SAID THERE WAS NO RECALL. I KNOW THE CAR IS 11 YEARS OLD, BUT IT HAS VERY LOW MILES AND THE SPRING HAD NO RUST IT LOOKED LIKE NEW. THIS SEEMS TO BE A SERIOUS SAFETY ISSUE PLEASE LOOK INTO IT. *TR

MY CAR WAS PARKED IN THE GARAGE, WHEN I SAT DOWN IN THE SEAT I HEAR A LOUD NOISE, WHICH WAS CAUSED BY THE DRIVER FRONT SIDE COIL SPRING BROKE AND PLUNGED INTO THE TIRE. HAD THIS HAD HAPPENED WHILE DRIVING IT WOULD HAVE MOST LIKE CAUSE A SEVERE ACCIDENT. THE COST TO FIX IT WAS HIGHER AS IT WAS RECOMMENDED THAT BOTH FRONT SPRINGS BE REPLACED FOR SAFETY REASONS. *TR

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT BOTH FRONT COIL SPRINGS WERE FRACTURED AND PUNCTURED BOTH FRONT TIRES. THE CONTACT HAD THE VEHICLE TOWED TO A DEALER FOR REPAIR. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 04V332000 (SUSPENSION) BUT WAS ADVISED THAT THE RECALL ONLY PERTAINED TO THE 2001 MODEL SABLE AND NOT THE 2002 MODEL ALTHOUGH THE VEHICLE WAS MANUFACTURED IN DECEMBER 2001. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 95,000. *TR

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE FRONT DRIVER'S SIDE COIL SPRING FRACTURED AND PUNCTURED THE FRONT DRIVER'S SIDE TIRE. THE CONTACT REPLACED THE COIL SPRING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 190,000. *TR

I STARTED MY CAR AND STARTED TO BACK OUT OF MY GARAGE. I WENT ABOUT 1 FOOT WHEN I HEARD A POP, THEN THE FRONT LEFT SIDE OF THE CAR DROPPED INSTANTLY. THE TIRE WAS FLAT, SO TOOK ANOTHER VEHICLE TO WORK. WHEN I CAME HOME FROM WORK, I JACKED THE CAR UP TO PULL THE TIRE OFF, BUT COULDN'T. AT INSPECTING THE FRONT WHEEL ASSEMBLY IN NOTICED THAT THE COIL SPRING WAS INTO THE TIRE SIDE WALL. NOT KNOWING WHAT HAPPENED, I CALLED MY MECHANIC WHO CAME THE NEXT DAY TO INSPECT THE DAMAGE. HE WAS ABLE TO PULL THE TIRE OFF THE CAR AND WE SAW THAT THE BOTTOM PART OF THE SPRING HAD BROKEN OFF AND WENT INTO THE TIRE. MY MECHANIC SAID BOTH FRONT SPRINGS WOULD HAVE TO BE REPLACED WITH THE TIRE AND STRUT SUPPORT. HE SAID I WAS VERY LUCKY THAT I WAS NOT...

TL* THE CONTACT OWNS 2002 MERCURY SABLE. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN A RESIDENTIAL GARAGE WHEN HE HEARD A LOUD SOUND. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE STRUT SPRING WAS FRACTURED AND HAD PUNCTURED THE FRONT DRIVER'S SIDE TIRE. THE VEHICLE WAS TAKEN TO A REPAIR FACILITY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 95,000. UPDATED 03/15/13*LJ

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT THE VEHICLE MADE A LOUD GRINDING NOISE WHILE REVERSING THEN THE LEFT FRONT END DROPPED. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE LEFT FRONT TIRE WAS FLAT. THE VEHICLE WAS TOWED TO THE MECHANIC AND WAS INSPECTED. THE LEFT FRONT COIL SPRING FRACTURED DUE TO CORROSION AND CUT THE TIRE SIDE WALL. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 55,000.

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT WHILE PARKED, THE COIL SPRING FRACTURED AND PIERCED THE FRONT DRIVER'S SIDE TIRE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO ADVISED THE CONTACT THAT THE FRONT COIL SPRINGS AND THE STRUTS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE DUE TO THE VEHICLE NOT BEING INCLUDED IN ANY RECALLS. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND THE CURRENT MILEAGE WAS 72,800. UPDATED 3/13/13 *CN

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE MADE A LOUD SNAPPING NOISE. THE CONTACT MENTIONED THAT WHILE HE DROVE THE VEHICLE OUT OF THE GARAGE THE PASSENGER FRONT TIRE BLEW. AFTER INSPECTING THE VEHICLE HE NOTICED THAT THE PASSENGER FRONT COIL SPRING BROKEN. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 04V332000 (SUSPENSION: FRONT: SPRINGS: COIL SPRINGS). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT AND MILEAGE WAS 113,000.

FRONT LEFT COIL SPRING FRACTURED WHEN I GOT INTO MY CAR. CAR WAS PARKED. COIL SPRING PENETRATED THE FRONT TIRE AND RUPTURED IT. THIS IS IDENTICAL TO THE FAILURE REPORTED IN 04V332000, BUT MY CAR IS ABOUT 6 MONTHS OLDER THAN THE MANUFACTURING RANGE OF THAT RECALL. *TR

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH IN SNOWY WEATHER, THE CONTACT HEARD A LOUD NOISE FROM THE FRONT OF THE VEHICLE. AFTER INSPECTING THE VEHICLE HE NOTICED THAT THE FRONT DRIVER SIDE TIRE WAS DEFLATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THE COIL SPRING HAD FRACTURED AND PUNCTURED THE TIRE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. THE VIN WAS NOT AVAILABLE.

I WAS BACKING OUT OF MY GARAGE WHEN I IMMEDIATELY BECAME AWARE THE VEHICLE WAS NOT MOVING NORMALLY, THE FRONT DRIVERS SIDE TIRE WAS COMPLETELY FLAT. WHEN I WAS CHANGING THE TIRE I NOTICED THE SPRING HAD BROKEN AND PUNCTURED AND RUINED THE TIRE. THIS EVIDENTLY HAPPENED WHILE THE CAR WAS PARKED IN THE GARAGE AS I HEARD NO NOISE FROM THE BREAKING SPRING OR ESCAPING AIR. I FEEL FORTUNATE THIS HAPPENED IN THE GARAGE AND NOT AT HIGHWAY SPEEDS. *TT

THE FOLLOWING ADDRESSES AN ISSUE I ENCOUNTERED WITH MY VEHICLE, A 2002 MERCURY SABLE. ON JANUARY 12TH, 2012, I WAS DRIVING ON A TWO WAY ROAD DURING A HEAVY SNOWSTORM. I WAS TRAVELING ABOUT 35 MILES PER HOUR, WHICH WAS BELOW THE SPEED LIMIT, DUE TO THE ROAD CONDITIONS. AT THIS TIME, I HEARD A LOUD NOISE AND EXPERIENCED A LOSS OF CONTROL OVER MY VEHICLE. AFTER PULLING OVER, I INVESTIGATED THE NOISE AND DISCOVERED THAT THE FRONT RIGHT TIRE WAS COMPLETELY SHREDDED AND PARTIALLY OFF THE RIM. I TOWED THE CAR TO A REPAIR SHOP AND LEARNED THAT THE SUSPENSION SPRING BROKE AND PUNCTURED THE TIRE AND DAMAGED THE STRUT. THIS IS ALSO A YEAR AND A HALF AFTER I HAD A SIMILAR PROBLEM WITH THE FRONT LEFT SPRING. NEITHER THE STRUT NOR THE TIRES WERE DAMAGED DURING THIS EVENT AT THAT TIME. *TR

DRIVER BACKING OUT OF PARKING SPACE WHEN HEARD METALLIC GRINDING SOUND FOLLOWED BY A BANG. THEN WE HEARD THE SOUND OF METAL ON PAVEMENT. WHEN GOT OUT OF CAR THE DRIVERS SIDE OF THE CAR WAS SITTING SO LOW THAT I COULD NOT GET A JACK UNDER IT. THE DRIVER FRONT TIRE WAS COMPLETELY SHREDDED ON THE INSIDE OF THE WHEEL WELL. IT IS COSTING US $700 TO REPAIR. AS PER ODI RESUME EA 08-18 DOCUMENT UNDER REASON FOR CLOSING THE FOLLOWING SENTENCE APPEARS, "THE COIL SPRINGS IN THE SUBJECT VEHICLES ARE DEFECTIVE." EVEN IF THERE IS NO REAL DANGER TO TRAFFIC SAFETY IT IS STILL AND ISSUE THAT FORD SHOULD BE REQUIRED TO ADDRESS, WE AS THE DRIVING PUBLIC SHOULD NOT HAVE TO PAY HUNDREDS OF DOLLARS TO REPAIR IT. ALSO IF FORD WANTS TO KEEP THEIR CUSTOMERS THEY SHOULD ADDRESS PROBLEMS SUCH AS THIS. WE ARE THINKING OF...

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE NOTICED THAT THE FRONT DRIVER'S SIDE TIRE WAS FLAT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE CONTACT WAS INFORMED THAT THE FRONT DRIVER'S SIDE COIL SPRING FRACTURED AND PUNCTURED THE TIRE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 123,000.

TL* THE CONTACT OWNS A 2002 MERCURY SABLE GS. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THERE WAS A LOUD BANG AND THE FRONT PASSENGER TIRE BLEW. THE CONTACT ALMOST LOST CONTROL OF THE VEHICLE AS SHE MERGED ONTO THE SHOULDER AND ROLLED INTO A DITCH. THERE WERE NO INJURIES AND THE VEHICLE WAS NOT DAMAGED. THE TIRE WAS REMOVED AND THE SPARE WAS INSTALLED. THE VEHICLE WAS THEN TAKEN BACK TO THE DEALER WHERE THE TIRE WAS ORIGINALLY PURCHASED AND AFTER INSPECTION, THE TECHNICIAN ADVISED THAT THE COIL SPRING CAUSED THE TIRE DAMAGE. THE DEALER WAS NOTIFIED OF THE COIL SPRING FAILURE AND ADVISED THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE MANUFACTURER WAS CONTACTED WHO CONFIRMED THAT THERE WERE NO RECALLS AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 113,000.

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT THE VEHICLE WAS NOT BALANCED AND DROPPED TO THE FLOOR ABNORMALLY. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE FRONT COIL SPRING WAS FRACTURED AND CAUSED DAMAGE TO THE BRAKE PAD AND BLOWER. THE FRONT COIL SPRING, BRAKE PAD AND BLOWER WERE REPLACED. AFTER THE REPAIR THE FRONT COIL SPRING FRACTURED A SECOND TIME. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 59,000.

ON MAY 25, 2010, THE LEFT REAR STRUT AND SPRING BROKE, AND PUNCTURED MY TIRE. ONE YEAR LATER, ALMOST TO THE DATE, THE LEFT FRONT STRUT AND SPRING BROKE AND PUNCTURED THAT TIRE ALSO. LUCKILY FOR THE SECOND INCIDENT, THE CAR WAS PARKED. I WOULD HATE TO THINK WHAT MIGHT HAVE HAPPENED HAD I BEEN DRIVING THE CAR AT THE TIME. THE ROD WAS RIGHT INSIDE THE TIRE, AND I'M SURE IT WOULD HAVE CREATED AN ACCIDENT! FORD/MERCURY HAS NO RECALL ON MY VIN, ALTHOUGH THERE ARE RECALLS ON THE FORD TAURUS, WHICH IS BASICALLY THE SAME CAR. IT IS ALSO NOT PART OF THE FORD CUSTOMER SATISFACTION GUARANTEE AS SOME OF THE TAURUS' ARE. I THINK FORD/MERCURY SHOULD HAVE TAKEN THE APPROPRIATE ACTION TO HAVE THESE REPAIRED.

LEFT FRONT SPRING BROKE GOUGING AN 8 INCH TEAR IN TIRE SIDE WALL CAUSING A BLOWOUT AND DAMAGE TO ANTI-LOCK BRAKE SYSTEM. TRANSMISSION MOUNT WAS ALSO DAMAGED. IF THIS HAD HAPPENED AT HIGHWAY SPEEDS, LOSS OF STEERING CONTROL AND BRAKING COULD HAVE CAUSED SERIOUS INJURIES. FORD DENIES ANY RESPONSIBILITY. I WAS TOLD THAT FORD HAD ADMITTED FREQUENT SPRING FAILURE ON ITS 1999 TO 2001 TAURUS/SABLE VEHICLES AND INSTALLED GUARDS TO PROTECT THE TIRES FROM BLOWOUT. THIS IS SECOND SPRING FAILURE IN 2 YEARS. THE FIRST TIME WAS THE RIGHT REAR SPRING BROKE DAMAGING STRUT AND GOUGING TIRE BUT NOT CAUSING DEFLATION. TWO SPRING FAILURES ON THE SAME VEHICLE IN 2 YEARS INDICATE THAT IT IS NOT AN ISOLATED INCIDENT. THIS IS TIME BOMB WAITING FOR SOMEONE TO GET SERIOUSLY INJURED.

WHILE ATTEMPTING TO BACK OUT OF MY GARAGE, THE COIL SPRING ON THE FRONT DRIVER SIDE STRUT BROKE AND SHOT INTO MY FRONT TIRE, PUNCTURING AND IMMEDIATELY FLATTENING MY TIRE. THE SPRING WAS EMBEDDED IN THE TIRE SO FAR THAT THEY WERE UNABLE TO REMOVE THE TIRE TO PUT ON THE SPARE. THE CAR HAD TO BE FORCED IN REVERSE FAR ENOUGH BACK TO BE ABLE TO HOOK IT ONTO THE TOW TRUCK WHICH SHREDDED THE FRONT TIRE. HAD TO HAVE FRONT SPRINGS, STRUTS, ABS SPEED SENSOR, ALIGNMENT AND NEW TIRE PUT ON THE VEHICLE. VERY LUCKY THAT THIS INCIDENT HAPPENED IN MY GARAGE AND NOT OUT ON THE ROADWAY. *TR

TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH ATTEMPTING A TURN WHEN SUDDENLY THERE WAS A LOUD NOISE COMING FROM OUTSIDE OF THE VEHICLE. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND NOTICED THAT THE REAR OF THE VEHICLE SLIGHTLY COLLAPSED IN A TILED POSITION TOWARDS THE PASSENGER SIDE. THE VEHICLE WAS DRIVEN AT AN EXTREMELY LOW SPEED RATE TO THE NEAREST DEALER FOR DIAGNOSIS. THE REAR PASSENGER SIDE COIL SPRING FRACTURED, AND WAS REPLACED. MOST RECENTLY, THE CONTACT STATED THAT THE FRONT DRIVER SIDE COIL SPRING COMPLETELY FRACTURED AND CAUSED THE TIRE TO EXPLODE. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED BY AN INDEPENDENT MECHANIC. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000. UPDATED 3/14/11 *CN UPDATED 12/14/11 *CN

BACK SPRINGS BOTH BROKE ON 2002 SABLE..HAD TO GET FIXED TO PASS INSPECTION......IN JAN 2009 FRONT SPRING BROKE AND PUNCTURED MY LEFT FRONT TIRE..I UNDERSTAND FORD HAD RECALLS OR SAFETY ISSUES W/SPRINGS FOR 1999,2000,2001 & 2003 BUT NOT MY 2002..I HAVE TRIED W/FORD TO NO AVAIL FOR RESOLUTION WITH THIS ISSUE TO NO AVAIL....I HAVE READ MANY COMPLAINTS ON INTERNET FOR SAME EXACT PROBLEM I HAVE HAD W/2002 VEHICLES..HOW DID FORD SKIP THE 2002 MODELS? *TR

2002 MERCURY SABLE LS PREMIUM, 64,000 MILES. THE SPRINGS BROKE IN THE FRONT WHEEL ASSEMBLY. CAUSED TIRE RIP AND COST $1,100 IN REPAIRS. *TR

I DRIVE A 2002 MERCURY SABLE THAT WAS PURCHASED A FEW MONTHS AGO. WE ARE A FAMILY OF THREE THAT DOESN'T DRIVE OFTEN OR LIKE A NASCAR DRIVER. BUT LAST WEEK WHILE REVERSING, MY TIRES BLEW. WE WERE GOING TO PUT THE SPARE ON WHEN WE NOTICED THAT THE STRUT/SPRING THAT PUNCTURED AND BLOWN THE TIRE. WE ARE SO THANKFUL THAT WE WERE NOT ON THE INTERSTATE WHEN THIS HAPPENED BECAUSE WE COULD'VE BEEN KILLED. NOT ONLY THAT, BUT WE ARE SPENDING HUNDREDS OF DOLLARS ON THIS ISSUED THAT SHOULD BE RECALLED! I HAVE DONE SOME RESEARCH ON THIS CAR AND NOTICED THAT THIS IS A COMMON PROBLEM FOR MANY OWNERS OF THE MERCURY SABLE ANAD FORD TAURUS. IT IS NOT RIGHT FOR A COMPANY TO THINK THAT THEY CAN GET AWAY WITH THIS. OUR FAMILY WAS HIT HEAD ON, ON THE INTERSTATE A YEAR AGO ADN COULD'VE DIED!! WE...

HI I AM WRITING ABOUT MY 17-YEAR-OLD SON'S CAR. IT IS A 2002 MERCURY SABLE. HE HAD A BLOW-OUT 4 NIGHTS AGO WHICH PROMPTED HIM TO CALL AAA TO CHANGE IT AT 11:30 P.M. THE NEXT DAY WE WENT TO GET A NEW TIRE FOR THE FRONT PASSENGER SIDE, THEY PUT A NEW TIRE ON IT, WE PAID THEM AND PROCEEDED TO BACK OUT OF THE DRIVEWAY AND THE TIRE WENT FLAT. THE MECHANIC THEN TOOK THE TIRE OFF AND TOLD US WE HAD A BROKEN COIL SPRING THAT WAS PUNCTURING THE TIRES. WE THEN TOOK THE CAR TO THE GARAGE TO HAVE THIS SPRING REPLACED FOR $150 AND UPON DRIVING THE CAR INTO THE SHOP THE OTHER SIDE BROKE AND PUNCTURED THE LEFT TIRE. SO NOW MY BILL IS UP TO $300 ALREADY AND HE HASN'T EVEN CHECKED THE REAR COILS YET. IT IS VERY FRUSTRATING TO ME TO...

I DRIVE A 2002 MERCURY SABLE. I WAS TURNING LEFT INTO A GAS STATION DRIVEWAY AND I HEARD A LOUD METAL SOUND, AS LOUD AS A GUNSHOT. I GOT OUT OF THE CAR AND LOOKED UNDERNEATH AND ALL AROUND THE AREA ADJACENT TO THE CAR BUT I COULD NOT SEE ANYTHING. I WAS ABLE TO DRIVE THE CAR TO A REPAIR SHOP WITHOUT INCIDENT, BUT EVERY TIME I WENT OVER THE SLIGHTBEST BUMP, THE CAR SOUNDED LIKE IT WAS GOING TO FALL APART (LOTS OF METAL SCRAPING NOISES). THE REPAIR SHOP SAID THAT MY FRONT COIL SPRINGS HAD BROKEN AND THAT I WAS LUCKY THAT THE SPRING HAD NOT PUNCTURED MY TIRE. THE MECHANIC CALLED FORD TO CHECK ON A RECALL FOR THE SPRINGS BECAUSE HE SAID THAT THIS WAS A VERY COMMON PROBLEM FOR FORD/MERCURY CARS. FORD INFORMED HIM THAT MY CAR WAS NOT INCLUDED IN THE RECALL. I...

WHILE HAVING TIRES ROTATED AT SAM'S CLUB, THE TECHNICIAN NOTIFIED ME THAT BOTH REAR SPRINGS WERE BROKEN. *TR

MY HUSBAND MERELY SAT IN OUR CAR AND WE HEARD A TERRIBLE NOISE FROM THE BACK - IT WAS THE SPRINGS BREAKING. WE SPENT $400.00 TO REPAIR BOTH REAR SPRINGS. A MONTH LATER, I TOOK THE CAR IN FOR NEW TIRES AND THE DRIVERS-SIDE FRONT SPRING BROKE. WE ENDED UP REPLACING SPRINGS, SHOCKS, AND MOUNTING HARDWARE FOR A TOTAL OF $650. FORD HAS RECALLED THE 1998-2001, BUT THIS PROBLEM OBVIOUSLY IS STILL NOT FIXED AND THE 2002 SHOULD BE RECALLED AS WELL. *TR

REGULAR DRIVING. BOTH OF THE REAR SUSPENSION COILS SNAPPED AND THE FRONT COILS APPEAR TO BE ON THEIR WAY AS WELL. *TR

FRONT PASSENGER SIDE SPRING BROKE WHILE DRIVING THE CAR OUT OF THE GARAGE. THE BROKEN SPRING CUT A 4 INCH GASH IN THE TIRE AND CAUSED A FLAT. THERE WAS NOT AN ACCIDENT BECAUSE WE WERE DRIVING SO SLOWLY IN THE GARAGE BUT THE TIRE BLEW SUDDENLY AND COULD HAVE POTENTIALLY CAUSED AN ACCIDENT. TO THE BEST OF MY KNOWLEDGE SPRINGS ARE NOT SUPPOSED TO BREAK HOWEVER THE TOW TRUCK DRIVER, TIRE SALESMAN, AND SEVERAL DEALERS ALL REPORTED IT AS A COMMON PROBLEM WITH THE MODEL CARE I WAS DRIVING. REPLACED BOTH SPRINGS & STRUTS IN THE FRONT AND TIRE $730.00. I WAS ADVISED THAT THE REAR SPRINGS SHOULD BE SAFE BECAUSE I HAVE A WAGON AND THEY ARE A DIFFERENT PART. *TR

THE REAR COIL SPRING ON MY 2002 MERCURY SABLE IS BROKEN AND NEEDS TO BE REPLACED. MY SON ALSO HAS A 2002 MERCURY SABLE AND HE HAD A SIMILAR PROBLEM WITH A BROKEN REAR COIL SPIRNG. PLEASE CHECK THE REPLACEMENTS ON THE FORD TARAUS AND MERCURY SABLES AND I AM SURE YOU WILL FIND THERE IS A DEFECT PROBLEM. THIS IS A SAFTEY DEFECT AND NEDS TO BE ADDRESSED. THANK YOU!