1984 MERCURY CAPRI — Problems, Recalls & Safety Data

Recall 07E064000 — FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

October 15, 2007 | 34,000 vehicles affected

Defect: CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

Consequence: A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.

Remedy: FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.

View full details →

Recall 92V063000 — SEAT BELTS:FRONT:ANCHORAGE

September 29, 1992 | 306,000 vehicles affected

Defect: THE PLASTIC SLEEVE IN THE FRONT SAFETY BELT TONGUE ASSEMBLY WHICH RETAINS THE LOCK BAR CAN DETERIORATE FROM PROLONGED EXPOSURE TO SUNLIGHT AND BECOME DISPLACED, CAUSING THE TONGUE TO DETACH FROM THE SAFETY BELT WEBBING.

Consequence: IF THE TONGUE DETACHES FROM THE SAFETY BELT WEBBING, THESAFETY BELT WOULD NOT ATTACH TO ITSELF, RESULTING IN INCREASED RISK OF INJURYTO THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR VEHICLE CRASH.

Remedy: FORD WILL REPAIR THE SAFETY BELTS EXPERIENCING THIS CONDITION REGARDLESS OF VEHICLE AGE OR CONDITION.

View full details →

Recall 84V119000 — FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

December 3, 1984 | 85,000 vehicles affected

Defect: THE SECONDARY THROTTLE SHAFT MAY, WITH ACCUMULATED MILEAGE, BECOME CONTAMINATED AND MAY STICK IN A PARTIALLY OPEN POSITION WHILE DRIVING.

Consequence: CONSEQUENCE OF DEFECT: THIS STICKING COULD RESULT IN A FASTER SPEED THAN INTENDED, POSSIBLY RESUTLING IN AN ACCIDENT.

Remedy: THE PRIMARY TO SECONDARY THROTTLE CLOSURE LINK ON THE CARBURETOR WILL BE REPLACED FREE OF CHARGE.

View full details →

Recall 83V134000 — SEAT BELTS:FRONT:ANCHORAGE

December 22, 1983 | 530,000 vehicles affected

Defect: THE BOLTS THAT ATTACH THE D-SHAPED RING FOR THE SHOULDER BELT ARE INADEQUATELY SUPPORTED BY THE MATERIAL IN WHICH THEY ARE MOUNTED. THE ATTACHMENT DOES NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES".

Remedy: DEALERS WILL INSTALL NEW ATTACHING HARDWARE TO IMPROVE THE STRENGTH OF THE MOUNTING.

View full details →