2016 KIA SPORTAGE Engine Problems

The contact owns a 2016 Kia Sportage. The contact stated that while driving at 55 MPH, the transmission failed to properly change gears. The contact stated that the check engine warning light was illuminated and there was smoke coming from the engine compartment. The vehicle was towed to the residence. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 180,000.

The contact owns a 2016 Kia Sportage. The contact stated that while driving at an undisclosed speed, several warning lights illuminated, and the engine seized. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 116,124.

WAS DRIVING ALL OF A SUDDEN, THE CAR STARTED KNOCKING MAKING NOISE, THE OIL LIGHT CAME ON, THE ENGINE LIGHT CAME ON AND WHITE SMOKE WAS COMING FROM MY TAIL PIPE. I HAD AN OIL CHANGE, BUT THAT DIDN'T DO THE TRICK, THE ENGINE LIGHT STILL COMES ON, MY CAR DRIVES VERY SLOW NOW. I'M AFRAID TO TAKE IT OUT ON THE ROAD

La guagua se apagó corriendo motor trancado quiero saber si tiene recall de la bomba de aceite es una kia sportage 2016 motor gdi [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2 problems occurred within 1 month from each other: - Kia Sportage engine started to randomly stall. I needed to do a full stop in the middle of the road and restart the car to continue driving. I had 3 stalls happen within 2 weeks before I had time to take it to the dealer. The Kia Dealer held it for over a week and drove it but could not find any issues. They mentioned low oil, which was strange considering I recently replaced it. I also forced the dealer to do ignition tuning which seemed to have resolved the issue. - In a month after the first problem with stalling I experienced issues with the engine of unknown origin (so far). This happened this week. While going downhill cruise control shut off. After that the engine started to decelerate and the amber blinking engine light came off. Transmission started...

On Sunday, June 1, 2025, I was leaving work and was exiting I97 to enter on 695 and and I accelerated to proceed on 695 and my vehicle lost power, the engine light along with the oil indictor came on, and making a loud knocking sound. The vehicle was towed and taken to the mechanic and the code read, "Knock sensor." The knock sensor was replaced at $301.85. I was able to drive the vehicle without any problems until Wednesday, June 3, 2025, when going to a doctor's appointment the vehicle's engine came on along with the oil indicator and the power was reduced and I had to pull over again with the same experience. The vehicle was again tested for codes and it then read Camshaft Sensor. This vehicle did not have any ill-performance, bells, dings, whistles or indicator lights until it was actually happening. According to the certified...

Me and my family were on the way to the beach, as I accelerated on the interstate got to 65 mph, engine light started blinking, car instantly slowed down. Got off on next exit, to check and see what was going on, car started hesitating after acceleration. Was able to get it to an autoshop (O'Reilly's) diagnosis shows knock sensor failure and they told me it has to do with the safety recall, didn't even know the car had a recall on it.

Have approx 101000 miles on car. It had 54202 when i bought it from A Kia dealer in Gastonia NC who was forced out of ownership because of fraud. The car has been serviced regularly and engine oil changed between 3-5ooo miles. I have put approximately 57000 miles since 2017. I have never had an issue with car until Christmas Eve 2024 when after leaving stop sigh and a turn around panel oil light came on and as i was looking for place to pull over all lights started Flashing and car completely went dead. Had to struggle to steer off road. Dead checked oil level good had it changed less than month temperature was normal Car dead and would not crank. Had to pay 200 on Christmas Eve to get towed to my son’s house which was approximately 15 miles. I had driven over 200+ miles averaging 60-70 mph....

Vehicle went from operating fine to a flashing yellow engine light. Within minutes, the vehicle could not be safely driven. There was a knocking and vibration from the engine.

AS WE WERE DRIVING MY NIECE HOME FROM SCHOOL ABOUT A BLOCK FROM HER HOUSE, THE CAR STARTED LOOSING POWER AND WHEN WE PULLED OVER TO LET HER OUT, THE CAR SHUT OFF ON ITS OWN AND WOULD NOT START BACK ON. WE WAITED A WHILE AND TRIED TO TURN IT BACK ON, BUT IT DID NOT DO ANYTHING. THERE WERE NO MESSAGES OR ANYTHING SAYING SOMETHING WAS WRONG

The contact owns a 2016 Kia Sportage. The contact stated while driving approximately 65 MPH, the vehicle suddenly lost motive power and stalled. During the failure, the check engine warning light illuminated. The vehicle was later towed to the local dealer who diagnosed and determined that the engine had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not contacted. The failure mileage was 110,000.

The engine knocks took it to the auto mechanic and needs a new engine. Have to pay for this and reading on line it is a well known issue

I was driving down the road on 4/18/2024 and my engine locked up. I got it off the road as far as I could, but was very dangerous spot. All maintenance has been done on this SUV. I had it towed to a local independent shop where I was informed it was locked up. No warning light came on. I just lost all power and coasted to the side of the road. It is available for inspection at the shop it was towed to. No repairs have been done at this time.

My car shut off in the middle of getting off a highway ramp. Completely shut down, had to push it to the side of the road in the middle of an off ramp/intersection.

Engine started to knock started having power loss and is no longer able to drive

I brought my 2016 Kia Sportage into Spitzer Kia because when stopped and in drive with my foot on the brake the vehicle shakes/vibrates a little. I HAVE NO WARNING LIGHTS ON. I had a tune up approximately a month earlier. Advisor James Martin at Kia said it needed a tune up because the previous tune up wasn't official Kia parts. I told James I need the old parts back so I can bring them back to the previous mechanic for reimbursement, James said okay. They did the tune up and the issue was still present. James said Kia will have a master technician service the vehicle. James called me back late on a Monday night and told me the cylinder dry and wet readings and will call me back first thing Tuesday morning with an estimate, he was on speaker phone so me and my wife heard what he...

Vehicle recall was addressed, yet problem persisted which was an engine oil leak/burn. Oil continued to leak/burn and caused engine problems. Cylinder 1 misfire was most recent, lost of acceleration, a/c failure, burning of engine coolant. All regular maintenance has been performed, 2nd set of new spark plugs within 12 months were installed a week ago. I have spent over $500 in the last few months alone trying to "maintain" my vehicle. Mechanic also stated these failures could lead to catalytic converter damage/failure. I have asked dealership & Kia separately to facilitate this repair before total failure to ensure my safety. They refused. Vehicle finally had the engine failure while driving in the center lane at highway speed on I95, this put my life in danger and Kia did not seem to think that was important. My vehicle had to be towed to a dealership at my expense, a rental...

This car was driven by a 17 year old high school student. Car with high oil consumption engine resulting in engine seizure 4/2022. Engine unseized and consumption of 1qt oil every 1,000 miles deemed "within normal limits" per Kia of America policy (Ganley Kia in Mentor Ohio). Kia corporate offices contacted with no resolution. From 4/2022 to 8/2023, car was driven only 2.5 non freeway miles to high school and home. It continued to consume oil resulting in adding and checking oil weekly despite low mileage driving. The car finally developed a lower engine knock at complete engine failure 8/2023. We sold it to [XXX] for $700.00. The manufacturer (Kia) of the car is fully aware of the defective engine design, the high oil consumption, and potential eventual engine failure. The car has poor resale and trade in value. Kia should be investigated for safety and ethical concerns. We were...

The contact owns a 2016 Kia Sportage. The contact stated while driving 25 MPH, the vehicle hesitated while accelerating. The contact stopped at a stop sign and the vehicle became inoperable. The check engine warning light was illuminated. The vehicle was towed to a dealer. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.

The contact’s son owns a 2016 Kia Sportage. The contact stated that while attempting to drive, the vehicle failed to accelerate, lost motive power, and stalled. The contact was unaware if a warning light was illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the engine needed to be replaced. The engine was replaced, but the failure recurred. Additionally, the dealer informed the contact that there was rod bearing failure and that the catalytic convertor had melted. The manufacturer was contacted and informed the contact that the knock sensor update was not completed. No additional assistance was provided. The failure mileage was approximately 106,000.

The contact owns a 2016 Kia Sportage. The contact stated while driving approximately 35 MPH, he heard an abnormal knocking sound coming from the engine compartment, and the vehicle started losing motive power. The contact depressed the accelerator pedal; however, the vehicle was still losing motive power. The contact stated that the check engine warning light was illuminated. The contact pulled off the road and the vehicle stalled. The contact stated that he was able to restart the vehicle and shift into drive; however, the vehicle would not accelerate above 20 MPH. The contact drove the vehicle to an independent mechanic who diagnosed the vehicle and found metal shavings in the oil pan. The contact was advised by the mechanic that the engine and the catalytic converter needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately...

I bought the car last year from Hardy Chevrolet in Dallas carfax report stated no open recalls in fact there was 3 the previous owner didn’t get repaired from 2018 and because of that one of the recalls the knock sensor is what seized up my motor and Kia has denied to fix it I’ve been without a car for 2 months neither Kia or hardy Chevrolet will help fix my vehicle if I had known about the recalls I would have had them fixed but Kia didn’t notify me of the recalls I was told by Kia the recalls got mailed to the previous Owner and it’s not there place to fix the problem and also hardy Chevrolet said it’s not there problem the carfax said no recalls but they sold me a car with 3 open recalls and now I’m out of a car also my car has...

The contact owns a 2016 Kia Sportage. The contact stated that while the vehicle was parked, there was oil leaking onto the ground. The oil warning light was illuminated. Additionally, the windows failed to roll down as needed. The dealer was made aware of the failure and scheduled an upcoming appointment for the diagnostic test. The dealer advised the contact to add oil to the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,025.

While driving in highway we noticed a fuel smell. After a little came from front area (hood area) and heard a blast underneath. At the same time the car abruptly stopped in the highway (HOV lane). We also noticed fireballs shooting downward from underneath the car. We had no options but to call fire brigade to stop the fire. Later we had to tow the car to home. I called a mechanic to evaluate the situation and he informed us the engine of the vehicle has been ceased as a result. We have to bear a significant cost for the repairs. We are still suffering emotional stress as a result of this unexpected incident.

I was driving with my cruise control set at 70 mph, on Highway 95 ( the speed limit ) While driving my vehicle suddenly dropped to 40 mph, all dashboard lights began to flash. I had problems with the steering as I attempted to pull over. I had a tractor trailer behind me on a major highway. When I came to a complete stop, my engine light kept flashing. I drove my car to the KIA dealership in GA, where they determined my engine failed ( software issues ) There were no prior warnings. My vehicle had been serviced just a few weeks prior. KIA is fully aware of these ongoing engine failures according to my local KIA dealer rep.

purchased the car 4 months ago & was given the car with a bad gas pressure relay . So the gas & oil was spilling on top of my motor cause inhalation gas fumes & car smoking . The car could have caught on fire at any given moment . The engine or motor was not checked properly before the car was ok’d for me to drive to & from work everyday . The entire motor was covered in gasoline .

Called local Kia dealer about part because my engine light is on and black liquid is dripping from underneath the front end. The dealer in Iowa said the Kia corporation in CA has no remedy or part so they can’t help me and they hope I don’t catch on fire. This is my only means of transportation and my teenager drives it occasionally. Hoping I don’t catch on fire is unacceptable. I am also paying $393 a month for a car payment for a car I can’t drive or if I do, I risk injury or death.

Motor just stopped working - went into limp mode. I got it towed to a mechanic that said it’s got an engine knock and the whole motor needs replaced. It was just about to catch fire, luckily I did not drive the car and had it towed. It’s at 82,000 miles, so it should NOT be blowing up on me this young.

The Vehicle Stalled on Tuesday while turning on to incoming traffic no lights were on the dashboard no indication it just stalled then stopped I had to get towed to my house. Wednesday I took it to Kia dealership there are 2 other recalls that needed to be done the Canister and Software update for Ticking Noise. Which I started to experience on my way to the shop on Wednesday. They were suppose to do both recalls they only performed one stated that the problem is the Engine Long Block. I contacted Kia after to inform them of what the Kia dealership diagnosed the problem to be. They stated that they couldn't do anything because the software update wasn't done in 2018 and I didn't get the vehicle until 2020. In which I explained they said well the person who had the car didn't take care of it so it's...

I received an interim recall notice in March 2022, it is now August 2022 and the remedy part is still unavailable for vehicle this shouldn't take this long. Kia stated I can still drive my car and watch for indicators but that seems really unsafe if there is a chance of possible engine fire. It shouldn't take this long for a remedy to be available.

This Recall has been ongoing since February 2022. In my travels I see hundreds of new KIA Sportages on the road but they can't come up with a single fuse to keep me from burning alive in my car? I am 70 years, working part time and need my job. I won't take the risk of transporting clients in my Sportage because of the potential danger and my employer is becoming impatient with this situation. My car sits out in the hot sun baking all summer because if it catches fire while in my garage I'm guessing my homeowner's insurance wouldn't pay because I KNEW there was a potential for fire. We are only weeks away from winter and do I scrape snow and ice off of my car at my age because KIA is busy cranking out new cars without a thought for the ones they have already put...

The contact owns a 2016 Kia Sportage. The contact stated while driving approximately 25 MPH, there was a knocking and squeaking sound coming from the front and the rear of the vehicle. The check engine warning light was illuminated. Additionally, there was oil leaking from the vehicle. The vehicle was diagnosed with asphalt in the exhaust system. The dealer replaced the brake lining. The manufacturer was notified of the failure. The approximate failure mileage was 55,000.

The contact owns a 2016 Kia Sportage. The contact stated while driving approximately 70 MPH, she noticed that the vehicle was losing power. The contact stated that she was able to pull off the roadway to assess the vehicle. The contact stated that no warning lights were illuminated. The contact stated that she then attempted to restart the vehicle and the engine would not turn over; however, the vehicle regained electrical power. The contact stated that she then had her vehicle towed to an independent mechanic where it remained. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The dealer was not notified; however, the manufacturer was made aware of the failure but offered no assistance. The failure mileage was 105,000.

The contact owns a 2016 Kia Sportage. The contact stated while driving 65 MPH, she heard an abnormal noise coming from the vehicle. The contact stated no warning light was illuminated. The contact was able to drive to her destination. The contact took the vehicle to local dealer, where it was diagnosed with needing the engine to be replaced. The vehicle was not repaired but was pending repairs. The VIN was included in NHTSA Campaign Number: 22V051000 (Service Brakes, Hydraulic). The manufacturer had been informed of the failure. The failure mileage was approximately 123,000.

The contact owned a 2016 Kia Sportage. The contact stated her son was driving approximately 35 MPH when smoke came from under the hood of the vehicle. The check engine warning light was illuminated. The driver pulled over safely and removed himself from the vehicle. The vehicle became totally engulfed in flames and was destroyed. The state police arrived on the scene and attempted to extinguish the fire with a fire extinguisher but were not successful. The fire department arrived on the scene shortly afterward and extinguished the fire. The local police filed a report. There were no injuries sustained. The approximate failure mileage was 118,860.

Received a recall notice stated "An Engine compartment fire may occur in the area where the Hydraulic Electronic Control Unit is located in your vehicle. The exact cause of fire remains unknown. However, it is believed that the HECU may experience an internal electrical short circuit that could result in overcurrent. An electrical short circuit in the HECU increases the risk of an engine compartment fire while the vehicle is parked or driving. A fire increases the risk of injury. Out of an abundance of caution, park your vehicle outdoors and away from other vehicles or structures until you have the recall repair performed." Yet, with this kind of instruction, KIA offered NO temporary replacement vehicle like a rental car. I called KIA corporate directly, spoke with their consumer department and also a supervisor. No one could offer any date for the fix or assistance with a rental car or...

The contact owns a 2016 Kia Sportage. The contact stated that the check engine warning light was illuminated. The contact received notification of NHTSA Campaign Number: 22V051000 (Service Brakes Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted but vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact was concerned about a possible vehicle fire. The manufacturer was not made aware of the issue. The failure mileage was approximately 61,000. Parts distribution disconnect.

The contact owns a 2016 Kia Sportage. The contact stated while driving approximately 55 MPH, there was a knocking sound coming from the vehicle. The contact stated that the vehicle started losing motive power, without warning. The contact pulled over to the side of the roadway. The contact checked and became aware that there was no oil in the engine. The contact was unable to restart the vehicle. The vehicle was towed to an independent mechanic and diagnosed with engine failure. The vehicle was not repaired. The dealer and manufacturer were contacted and the contact was informed that an unnamed recall repair was not performed and no assistance would be provided. The failure mileage was 90,000.

I was driving on interstate and with no sound or warning light my car just shut off. Lucky I was able to get it off the side of the road. Tired to restart the car it would not start the engine was locked up. Had it towed home. Sent kia a email they said take it to my local Kia dealership to get it kia certified on what's wrong with it. Did so Kia said it was a turned or spun rod bearing. But denied to fix it because the knock sensor was not installed if I don't get a letter or a recall on it how was I suppose to know. As I done some research I see it's a very big problem with kia 2.4 l engines if it was a safety issue why was I not aware until this happened to my car. As its happened to...

I WAS DRIVING IN TOWN WHEN ALL OF A SUDDEN MY CAR STOPPED ,I GOT MY CAR TOWED TO MY HUSBANDS BUSINESS AND AFTER THAT I TOWED IT TO THE KIA DEALERSHIP ,WHERE I WAS TOLD MY CAR DID NOT HAVE A RECALL DESPITE THE RECALLS ON THIS VEHICLE AND UPON READING MORE INTO IT I SEE THAT IT DOES HAVE A RECALLS ON ENGINE FAILURE,mY CAR STOPPED ON A VERY BUSY ROAD AS WELL, WITH CARS FLYING BY ME ON A 6 LANE ROAD.tHERE WAS NO WARNING LIGHTS ON AS WELL AS ANY OTHER LIGHTS UNTIL THIS HAPPENED

The contact's daughter owns a 2016 Kia Sportage. The contact stated that while his daughter was driving at an undisclosed speed, there was a knocking sound, and the vehicle lost motive power. The vehicle was towed to the dealer and diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and informed the contact that there was a service campaign for the knock sensor mailed to the contact's daughter's residence; however, the contact's daughter had not received the service campaign notification. The manufacturer declined the engine replacement. The failure mileage was approximately 137,000.

On 12/2/21 I was driving down 52 towards Lexington in the fast lane going about 66 MPH with my child in the back seat in her car seat when I noticed my 2016 Kia Sportage would not accelerate and suddenly went down to around 20 MPH resulting in more than one almost collisions to try to get off the highway. I then heard a loud knocking noise and my vehicle would not go over 15 MPH. There was not a single light on my dashboard that came on to alert me of the situation. I had the car towed to the auto shop I use until I could contact KIA. Bob King Kia (where I bought this one new as well as two other cars previously) said I had to have it towed there and have a diagnostic ($130) completed before they could help me. on 1/4/22 I had it...

Engine stopped completely while on the highway with my family

I own a 2016 Kia Sportage which is still new. I've owned it for 2-3 years had about 32k miles on the vehicle when I purchased it in 2018. I currently have 50k miles now, I follow-up with dealership on my Oil Changes without having any issues. One day out of the blue it started making a knocking sound coming from engine, I contacted the Dealership they couldn't figure it out stating it was a known issue from the Back Rear seats locking latch not holding steady. I explained that it sounds like it's coming from front side of the vehicle in the engine. They advised me that I am okay so I took their word for it. Followed up on a routine Oil Service Change and again I advised the dealership to look into the knocking sound due to concerns that it doesn't seem right. My engine service lamps...

CAR BEGAN MAKING A RATTLING NOISE IN THE ENGINE THEN IMMEDIATELY STOPPED RUNNING WHILE I WAS DRIVING. LUCKILY I WAS ON A COUNTY ROAD AND COASTED IN TO A DRIVEWAY. I HAD THE CAR TOWED TO MY HOUSE WHERE IT STILL RESIDES AND FEARING IT IS A ROD BEARING FAILURE IN THE MOTOR.

ON MARCH 12 2021 I WAS ON I-4 EAST TOWARD DAYTONA BEACH ABOUT 70 MILES PER HOUR AND ALL OF THE SUDDEN THE ENGINE STAHL. I WAS ABLE TO MOVE TO THE SHOULDER OF THE ROAD. THE TOW TRUCK DRIVER JUMPED THE BATTERY 3 TIMES AND THE ENGINE DIDN'T START,TOOK IT TO THE DEALER KEPT THE CAR OVERNIGHT DID ALL NECESSARY CHECKS EVERYTHING LOOKS FINE NO PROBLEM WITH THE BATTERY OR ANY OTHER THING.. THE NEXT DAY THE CAR START AS NORMAL, THEY DID A TEST DRIVE AND EVERYTHING WAS OK AS IF NOTHING HAD HAPPENED. I WENT AND TOOK THE CAR HOME AND AS OF THIS MOMENT IT SEEMS TO BE OK. MY BIG CONCERN NOW IS WHAT IF IT HAPPENS AGAIN WHILE DRIVING IN THE HIGHWAY. IT CAN CAUSE AN ACCIDENT RISKING MINE AND MY FAMILY LIVES. IS THERE ANYTHING I CAN DO???

WHILE DRIVING THE OIL LIGHT KEPT FLASHING. A LOUD NOISE UNDER MY HOOD AND CAR WAS PULLING. CAR WAS UP TO DATE AND SERVICED 1/21.

CAR JUST SHUTDOWN ON ME DOING 75 IN A 70. MILEAGE WAS NOT HIGH AND MAINTENANCE WASN'T NEED ACCORDING TO THE DASHBOARD. CAR WAS GREAT THEN JUST OUT OF NOWHERE SHUTDOWN DUE TO FAULTY ENGINE THEY KEEP SAYING.*JB

I OWN A 2016 KIA SPORTAGE AND IN JANUARY 2019 ON A TRIP TO A NEARBY TOWN THE CAR ENGINE STARTED TO CATCH. AT THIS TIME THE CAR ONLY HAD ABOUT 29,000 MILES ON IT AND HAD THE OIL CHANGED ABOUT 4 WEEKS PRIOR. MY HUSBAND CHECKED THE ALL THE FLUIDS AND FOUND THE CAR HAD VERY LITTLE OIL IN IT. WE WERE SURPRISED SINCE NO WARNING LIGHTS EVER CAME ON AND WE HAD JUST CHANGE THE OIL. HE PUT OIL IN IT AND WATCHED IT AND AGAIN 2 WEEKS LATER THERE WAS VERY LITTLE OIL IN THE CAR. I TOOK IT TO THE DEALER AND EXPLAIN ALL OF THIS. THEY TOOK A PICTURE OF THE INSIDE OF MY MOTOR AND SAID IT WAS LIKE SLUDGE THEN PUT IT ALL BACK TOGETHER AND BLAMED EVERYTHING ON US VOIDED THE WARRANTY . THE CAR CANNOT BE DRIVEN OVER ABOUT 45MPH. UPON...

MY CAR WOULDN'T RUN RIGHT WE TOOK IT IN THEY SAID IT WAS THE CRAN SENSOR CHARGED 900 TO FIX IT. THEN THAT DIDN'T WORK NOW IT IS THE ENGINE HARNESS AND THEY WANT 3400 TO FIX IT. IF I SAY FIX IT WHAT WILL BE NEXT. THEY DON'T WANT OT REPAIR IT JUST REPLACE