2011 KIA SORENTO Engine And Engine Cooling Problems

The contact owns a 2011 Kia Sorento. The contact stated that while driving 55–60 MPH, the engine overheated and the vehicle stalled while making a turn. The vehicle stalled and failed to restart. Several unknown warning lights were illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V877000 (Engine). The vehicle was towed to an independent mechanic, but no assistance was provided. The vehicle was towed to another independent mechanic, but the cause of the failure was not determined. The vehicle was towed to the local dealer where it was determined that the battery and bracket needed to be replaced. The dealer also informed the contact that the engine and fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was contacted. The failure mileage was unknown.

The contact owns a 2011 Kia Sorento. The contact stated while driving on a main road at 55 MPH, there was an abnormal sound coming from the engine, and the engine power was reduced, and the vehicle failed to accelerate above 20 MPH. The temperature gauge indicated that the engine was overheating. The contact was forced to pull over onto the side of the road where the vehicle was left idling for a while. The check engine, and the oil pressure warning lights were illuminated. The vehicle was towed to a local independent mechanic, where the contact was informed that the engine was faulty and was not worth the effort to replace the engine, as the cost would significantly outweigh the value of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 200,000.

The contact owns a 2011 Kia Sorento. The contact stated that while operating the vehicle, there was smoke coming from the engine compartment. The vehicle was taken to the local service center which determined that the cam shaft sensor was faulty and needed to be replaced. The cam shaft sensor was replaced; however, the failure persisted. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 169,000.

The contact owns a 2011 Kia Sorento. The contact stated that while driving at 60 MPH, an abnormal clunking sound had emitted from the vehicle. The contact then heard parts falling out of the engine as white smoke began to release from the vehicle's hood. The check engine warning light was also illuminated on the instrument panel as the contact pulled over. The contact lifted that hood and saw flames coming from undeath the vehicle. The contact immediately shut the hood as smoke continued to discharge from the vehicle. The fire department arrived at the scene; however, the fire had dissolved on its own. The contact had the vehicle towed to an independent mechanic and was informed that a rod had blown in the engine resulting in engine failure. The vehicle was then towed to the dealer and was initially informed that her vehicle would be repaired under an extended...

The contact owned a 2011 Kia Sorento. The contact stated while driving at 25 mph, a UPS truck veered off into her lane causing the contact to crash her vehicle into a curb. The contact stated that the next morning, she saw that her vehicle was leaking an immense amount of oil. The contact stated that the check engine warning light was illuminated. The air bags did not deploy. A police report was not filed. The vehicle was taken to a repair shop where it was diagnosed with nothing needing to be replaced. The vehicle was not repaired. The contact then stated while driving at 55 mph, the vehicle stalled and the contact saw smoke emerging from the engine compartment. Upon exiting the vehicle, the contact opened the hood to fire behind the engine. There were no injuries. The air bags did not deploy. The fire department was contacted but...

The contact owns a 2011 Kia Sorento. The contact stated while driving 58 MPH, the vehicle shut-off with the engine and oil warning lights illuminated. The contact pulled off the road and had the vehicle towed to an independent mechanic. The mechanic informed her that the radiator was blown and that the engine needed to be replaced. The manufacturer was notified of the failure and informed her that since the software update was not performed on the vehicle, they could not assist her with the failure. The dealer was also notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was 93,407.

2011 KIA SORENTO. CONSUMER WRITES IN REGARDS TO RECALL FOR ENGINE MALFUNCTION. *AS *TR

TL* THE CONTACT OWNS A 2011 KIA SORENTO. WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE SEIZED WITHOUT WARNING. COOPER KIA (5056 COMMERCIAL DR, YORKVILLE, NY) WAS CONTACTED, BUT THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 17V224000 (ENGINE AND ENGINE COOLING) AS A POSSIBLE SOLUTION. THE CONTACT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000. *TT *TR

AIR CONDITIONING NOT COOLING PROPERLY.DRAIN AND RECHARGE SYSTEM BY DEALERSHIP,STILL NOT COOLING PROPERLY.DEALER ORDERED A NEW COMPRESSOR.DEALER INSTALLED NEW COMPRESSOR AND RECHARGE SYSTEM. *TR

FOUND THIS ON ANOTHER WEB SITE: WWW.TOPCLASSACTIONS.COM (SEE BELOW FOR DESCRIPTION) VERY INTERESTING: APPARENTLY THIS DEFECT HAS BEEN GOING ON SINCE 2002!! WELL IT'S STILL HAPPENING I HAVE THE 2011 6 CYL AWD AND FOUND OUT IT'S STILL A DEFECT IN THE 2012 AND 2013. NOTHING MORE TO SAY BUT 'SHAME ON KIA MOTORS' YOUR LACK OF TAKING OWNERSHIP FOR THIS DEFECT IS JUST DISCUSTING. NHTSA PLEASE HELP US.....LIVES NEED TO BE SAVED; I AM BLEARY EYED READING ALL THE POWERTRAIN DEFECTS FOR THE 2011 KIA SORENTO. THE KIA SORENTO IS PRONE TO CATASTROPHIC ENGINE FAILURE, ACCORDING TO A CLASS ACTION LAWSUIT FILED IN NEW JERSEY. PLAINTIFFS ALLEGE IN THE KIA SORENTO CLASS ACTION LAWSUIT THAT KIA MOTORS KNOWINGLY CONCEALED THAT ITS 2002-2009 SORENTO CROSSOVERS WERE MANUFACTURED WITH A DEFECTIVE ENGINE PART CALLED THE CRANK SPROCKET. THIS ALLEGED ENGINE DEFECT LEADS TO A CATASTROPHIC CHAIN OF EVENTS THAT STARTS WITH...

AS I BACK U THIS WEIRD SCRATCHY SOUND AND ALSO AS I DRIVE AT NORMAL SPEED. *TR

WHEN TRYING TO STEP ON GAS VEHICLE SEEMS TO STRAIN. EXAMPLE, WHEN NEEDING TO GET IN LANE, MY CAR SEEMS NOT TO GET MUCH GAS WHICH I FEEL ESPECIALLY ON HIGHWAY, MAY CAUSE AN ACCIDENT. MY VEHICLE TEND TO RIDE QUITE ROUGH AS FAR AS WHEEL SUSPENSION. I HAVE HAD A WHEEL ALIGNMENT AND HAVE HAD THE VEHICLE CHECKED. I WAS TOLD NOTHING SEEMED TO BE WRONG WITH IT. I HAD THE 189.00 SERVICE DID ON MY CAR AS WELL. I CALLED THE RECALL CENTER AND I WAS TOLD NOTHING SHOWED FOR MY VEHICLE. MY VEHICLE IS NOT PERFORMING AS IT SHOULD. *TR

MY 2011 KIA SORENTO DOWNSHIFTS WHILE AT A HIGH RATE OF SPEED. IT ALSO GETS STUCK AND WHILE THE RPMS ARE RACING, IT WILL NOT SHIFT UP. THE BLUETOOTH DOES NOT WORK PROPERLY AND AM ONLY ABLE TO MAKE A CALL 30% OF THE TIME. BACKUP CAMERAS AND SENSORS ARE INTERMITTENT. WINDOW WILL NOT WORK. BACK DRIVERS SIDE DOOR FELL OFF HINGES WHILE I WAS DRIVING WITH MY CHILD IN THE BACKSEAT. MY PASSENGER SIDE SEAT OVERHEATED AND WOULD NOT TURN OFF. CAUSING MY CAR TO FILL WITH SMOKE ON THE EXPRESSWAY. MANY ISSUES WITH THIS LEMON! SHIFTER WILL NOT GO FROM DRIVE INTO PARK LEAVING ME STRANDED IN MY CAR. VEHICLE HAS NO POWER....POOR ENGINE. PAINT AND CHROME OF HANDLES ARE COMING OFF. PULLS TO THE LEFT AND ESC LIGHT COMES ON ALL THE TIME. *TR

WHILE DRIVING THROUGH A SHOPPING PLAZA, GOING ABOUT 15MPH,THE VEHICLE SUDDENLY SHUT OFF, CAUSING THE LOSS OF ALL POWER ASSIST FUNCTIONS AND ELECTRICAL OPERATION. THE ELECTRICAL CAME BACK ON-LINE RIGHT AWAY, BUT THE CAR HAD TO BE RESTARTED. THE SECOND TIME IT HAPPENED WAS IN RUSH HOUR TRAFFIC, 4 DAYS LATER. THE CAR WAS COASTING AT ABOUT 25 MPH WHEN IT SHUT DOWN AGAIN. *KB

WHILE DRIVING THE VEHICLE AND WHILE PRESSING THE GAS PEDAL THE VEHICLE STARTS TO COME TO A STOP AS IF THE GAS PEDAL IS NOT BEING APPLIED. I HAVE TO RELEASE THE GAS PEDAL AND PRESS IT AGAIN FOR THE SORENTO TO RESPOND AND CONTINUE TO ACCELERATE. I TOOK IT TO THE DEALER AND THEY HAVE NO CLUE AS TO WHAT IS THE PROBLEM. THEY RESET THE COMPUTER AND RELEASED THE VEHICLE TO ME BUT THE PROBLEM PERSISTS. *KB

I WAS DRIVING ABOUT 40 MPH, WHEN THE VEHICLE APPEARED TO MISS/SKIP GEARS! IT FELT AS IF THE VEHICLE WAS GOING TO STOP ALTOGETHER, AND I DEFINITELY LOST ACCELERATION ABILITY. NEXT THE MALFUNCTION INDICATOR LIGHT CAME ON AND IT HAS NOT GONE OFF. I AM GOING TO TAKE THE VEHICLE IN TO THE DEALER ON 12/17/2011 TO SEE WHAT MAY BE CAUSING A PROBLEM LIKE THIS. *TR

TL* THE CONTACT OWNS A 2011 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE VEHICLE SUDDENLY ACCELERATED UPON RESTARTING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON SEVERAL OCCASIONS AND THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT COULD NOT OFFER ANY ASSISTANCE WITHOUT HAVING A DIAGNOSED FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 5,000 AND THE CURRENT MILEAGE WAS 22,000.

TL* THE CONTACT OWNS A 2011 KIA SORENTO. THE CONTACT WAS DRIVING 50 MPH WHEN SHE HEARD A CLICKING SOUND COMING FROM THE ENGINE AS THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE FILTER PLACE IN THE ENGINE WAS NOT UP TO STANDARDS AND THE ENGINE WOULD NEED TO BE REBUILT. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 12,000.

WHILE DRIVING DOWN THE EXPRESSWAY, WITHOUT WARNING, THERE WAS A CATASTROPHIC ENGINE FAILURE CAUSING ONE OR TWO OF THE CONNECTING RODS TO BLOW THROUGH THE OIL PAN AND START A FIRE FROM THE FRONT OF THE VEHICLE TO THE BACK UNDERNEATH THE CARRIAGE. THE FLAMES CAME UP THE SIDES AND BACK OF THE CAR. NEEDLESS TO SAY IT WAS EXTREMELY FRIGHTENING. LOOKING AT THE DAMAGE OF THE CAR I NEVER EXPECTED THEM TO ATTEMPT TO REPAIR THIS CAR YET THEY DID. THE CAR WAS DOWN FOR ALMOST TWO MONTHS, THE SECOND ENGINE AND POWER STEERING FAILED BEFORE WE EVEN DROVE THE REPAIRED CAR OFF THE LOT. KIA STILL DID NOT WANT TO DO ANYTHING BUT REPAIR THE CAR AGAIN. THEY SAID, "THESE THINGS HAPPEN THATS WHY YOU HAVE A WARRANTY". THESE THINGS HAVE NEVER HAPPENED TO ME OR ANYONE I KNOW IN THE 30 YEARS I HAVE BEEN DRIVING. YOU...

WHEN ACCELERATING FROM A STOP OR SLOW SPEED THE ENGINE WILL OCCASIONALLY BOG DOWN AND ALMOST DIE. THIS IS EXTREMELY DANGEROUS WHEN PULLING INTO TRAFFIC OR ACROSS ONCOMING LANES OF TRAFFIC. IT HAS OCCURRED NUMEROUS TIMES. SOMETIMES FROM A FULL STOP AND SOMETIMES FROM LOW SPEED (LESS THAN 10 MPH). I HAVE TAKEN THE CAR TO THE DEALER THREE TIMES. THE FIRST TWO TIMES THEY CLAIMED TO HAVE REPAIRED THE VEHICLE AND TURNED IT BACK OVER TO US WITHOUT ANY COMMENT. THE THIRD TIME, AFTER I COMPLAINED ABOUT IT NOT BEING FIXED THE TWO TIMES BEFORE, THEY FINALLY ADMITTED THERE WAS NOTHING THEY COULD DO. THEY CLAIM TO HAVE DRIVEN ANOTHER 2011 SORENTO WHICH DID THE SAME THING AND THEY CLAIM TO HAVE CONTACTED KIA WHO TOLD THEM IF THERE WAS NO CODE ON THE COMPUTER (THERE WAS NOT) THERE WAS NOTHING THEY COULD DO. THIS IS VERY DANGEROUS AND...

EVER SINCE BOUGHT NEW (SORENTO SX 6CYL.) IN APRIL 2011, THERE HAS BEEN A INTERMITTANT ISSUE WITH NO ENGINE RESPONSE FROM STOP FOR 2-3 SECONDS. RPM'S STAY AT IDLE SPEED, THEN IT SUDDENLY TAKES HOLD AND RUNS FINE. ONLY HAPPENS FROM STOP, AND ONLY ABOUT ONCE OR TWICE EVERY 2-3 DAYS. DEALER CANNOT DUPLICATE PROBLEM, NO CODES. DANGEROUS SITUATION WHEN PULLING OUT INTO TRAFFIC FROM A STOP. I CANNOT DUPLICATE IT UNDER ANY DRIVING CIRCUMSTANCES. ALSO, IF I APPLY BRAKE DURING THIS "HESITATION" THERE IS NO ENGINE ACCELERATION WHILE I HOLD THE BRAKE. I FEEL SURE IT IS IN THE "FLY BY WIRE" SYSTEM, BUT DEALER HAS NO CLUE. I HAVE TO "FEATHER" THE ACCELERATOR FROM STOP WHENEVER I AM CONCERNED ABOUT ONCOMING TRAFFIC. *TT

AFTER THE FIRST DEALER OIL CHANGE I BEGAN GETTING LIFTER NOISE ON ENGINE START UP THAT WOULD LAST FOR MINUTES. THE PROBLEM HAS GOTTEN WORSE. DEALER REFUSES TO AKNOWLEDGE THE PROBLEM AND NOW I HAVE PUT A NON-OP ON MY BRAND NEW 2011 SORENTO BECAUSE OF THIS PROBLEM. TRIED TO GET THIS RESOLVED WITH A LAWYER AND THE COMPANY REFUSED TO TAKE THE CAR BACK. I HAVE BEEN FORCED TO RETAIN A LEMON LAW ATTORNEY TO GET THIS RESOLVED. KIA MOTORS DOES NOT STAND BEHIND THEIR WARRANTY. MY CAR WAS IN AND OUT OF DIFFERENT DEALERSHIPS WITH AN ARRAY OF PROBLEMS. THE INTERIOR CLOTH AROUND THE REAR HATCH IS COMING APART AND THE CAR WAS IN THE SHOP 3 TIMES FOR IT AND IT WAS NEVER FIXED. THE LAST DEALER SAID THAT THEY HAVE TO GET "SPECIAL PERMISSION" TO FIX THIS EVEN THOUGH THE CAR IS UNDER FACTORY WARRANTY. THE...

MY 2011 KIA SORENTO EX 4 CYLINDER HAS HAD A SAFETY ISSUE WITH HESITATION UPON TAKEOFF FROM A STOP SIGN OR ANY STOP. YOU NEVER KNOW WHEN IT WILL ACCELERATE AND I AM VERY CONCERNED IT WILL CAUSE AN ACCIDENT. I HAVE TAKEN IT TO THE LOCAL DEALER MANY TIMES AS IT SHOULD BE COVERED UNDER THE BUMPER TO BUMPER WARRANTY. THEY ACT LIKE THERE IS NOT A PROBLEM, BUT THERE IS. ONE TIME THEY DID SAY IT WOULD TAKE A SOFTWARE FIX THAT KIA HAS NOT PROVIDED. I JUST WANT IT FIXED. *TR

WHILE DRIVING DOWN INTERSTATE AT VARIOUS SPEEDS, THE VEHICLE SUDDENLY DIES AND THE VEHICLE COASTS DOWN THE ROAD W/ SERVICE ENGINE SOON LIGHT ILLUMINATED. VEHICLE HAS ONLY 11K MILES ON IT; HAS DONE IT 3 TIMES IN 2 DAYS. ALL KIA SERVICE WOULD DO IS CLEAR THE HISTORY (RESET). *TR

WE PURCHASED/LEASED A NEW 2011 SORENTO V6 AND ALMOST IMMEDIATELY STARTED EXPERIENCING THE OCCASIONAL HESITATION PROBLEM WHEN PULLING INTO TRAFFIC FROM A STOP. ON A COUPLE OCCASIONS IT PUT US IN A VERY DANGEROUS SITUATION AS WE WERE CROSSING 2 LANES OF TRAFFIC. TOOK THE VEHICLE TO COURTESY KIA IN BRANDON FL. 4 TIMES, THEY COULD NOT DUPLICATE THE PROBLEM. FINALLY THEY GOT US A 2012 NEAR IDENTICAL SORENTO V6, AND ON THE 3RD DAY HAD THE SAME EXPERIENCE W/50 MILES ON THE VEHICLE. WE NOW HAVE 500+ ON IT AND HAVE HAD A TOTAL OF 7 SIMILAR SITUATIONS. THE DEALERSHIP SAYS I'M THE ONLY ONE EXPERIENCING THIS AND THAT THEY AREN'T AWARE OF THE PROBLEM, ALTHOUGH I TALKED W/A CUSTOMER OF THEIRS W/A 2011 SORENTO AND HE SAID HE AND HIS WIFE HAVE THE SAME ISSUES W/THEIRS. WE ARE VERY DISAPPOINTED WITH THIS SITUATION, BUT OTHER THAN THAT WE...

GOING DOWNHILL IN OUR NEWLY PURCHASED 2011 KIA SORENTO EX V6, REACHING A 4 WAY STOP, OUR ENGINE QUIT. VEHICLE HAD ONLY 175 MILES ON IT AS IT IS BRAND NEW. CAR RESTARTED WITHOUT FURTHER INCIDENT. TOOK IT TO DEALER, THEY FOUND NO PROBLEM OR FAULTS REGISTERED ON THE ONBOARD COMPUTER. I HAVE READ OF SIMILAR OCCURRENCES WITH OTHER 2011 KIA SORENTO EX V6. I WILL FILE ANOTHER REPORT IF IT HAPPENS AGAIN. *TR

TL* THE CONTACT OWNED A 2011 KIA SORENTO. WHILE DRIVING APPROXIMATELY 40 MPH, THE CHECK ENGINE LIGHT BEGAN ILLUMINATING. THE CONTACT ALSO BEGAN TO SEE SPARKS COMING FROM THE ENGINE. THE VEHICLE WAS PULLED OVER AND A FIRE BEGAN UNDER THE ENGINE. THE FIRE DEPARTMENT APPEARED TO THE SCENE TO EXTINGUISH THE FIRE. A POLICE REPORT WAS ALSO FILED BUT NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROYED AND TOWED TO AN AUTHORIZED DEALER WHERE THEY WERE IN THE PROCESS OF DIAGNOSING THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 800.

I HAVE HAD THE CAR FOR ABOUT 4 MONTHS. DURING THIS TIME IT HAS 5 TIMES COMPLETELY SHUT OFF IN THE MIDDLE OF AN INTERSECTION AND ONCE WHILE I WAS CHANGING LANES IN STOP AND GO TRAFFIC. I HAVE TAKEN IT BACK TO THE DEALER TWICE AND THEY HAVE BEEN UNABLE TO DUPLICATE THE PROBLEM. *TR

TL*THE CONTACT OWNS A 2011 KIA SORENTO. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT STATED THAT THE AIR CONDITIONER SHUT OFF WITHOUT WARNING, CAUSING THE VEHICLE TO MAKE A GRINDING NOISE, AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO NOTICED SMOKE COMING FROM UNDER THE HOOD OF THE VEHICLE. THE DEALER WAS NOTIFIED WHO AND ADVISED THE CONTACT THAT THE ENGINE NEEDED TO BE REPLACED. THE CONTACT DID NOT INFORM THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 2000.

7/21/10 PURCHASED KIA SORRENTO EX FWD FROM MORITZ 110 NE LOOP 820 HURST, TX 7/22 NOTICED ENGINE HESITATED SEVERAL TIMES WHILE DRIVING SUFFICIENT THAT CARS PULLED AROUND ME. CONTACTED JERRY SIMPSON AND JIM CARTWRIGHT SERVICE MANAGER 7/26 TOOK SORRENTO BACK AND TO MORITZ AND RODE WITH JIM CARTWRIGHT THROUGH RESIDENTIAL NEIGHBORHOODS. CAR EXHIBITED NO HESITATION 8/2 HAVE DRIVEN SORRENTO TO OKLAHOMA TWICE AND AROUND RESIDENTIAL AREAS IN THE METROPLEX AND NOTICED A SLIGHT HESITATION. 11/8 WHILE IN 8:OOAM BUMPER TO BUMPER TRAFFIC EAST BOUND ON HWY 820 IN FORT WORTH,TX AT A SLOW 15MPH (EST) ENGINE CHUGGED DOWN AND THEN CAUGHT AND THEN DIED COMPLETELY AND CAR HAD TO BE PUSHED OUT OF WAY. WAS ABLE TO RESTART AND MAKE IT TO DOCTORS APPOINTMENT THEN TOOK THE SORRENTO BACK TO MORITZ KIA WHERE WE BOUGHT IT AND TOLD THEM I WANTED IT FIXED 11/11 NOT HAVING HEARD FROM MORITZ KIA...

TL*THE CONTACT OWNS A 2011 KIA SORENTO. WHILE THE CONTACT STARTED THE IGNITION,THERE WAS A LOUD CLANKING NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE "TIRE PRESSURE" WARNING INDICATOR BEGAN TO FLASH FOR FORTY- FIVE TO FIFTY SECONDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE CLANKING NOISE CONTINUED TO OCCUR INTERMITTENTLY. THE FAILURE MILEAGE WAS APPROXIMATELY 65.