2002 JEEP WRANGLER Structurebody Problems

Frame is rotted out. Vehicle is well maintained and it is upsetting. After spending good money for a reputable brand, the frame did not last. It is not drivable and is unsafe to be on the road. It is not safe to travel with my family. Everyone I know that has these years wrangler TJ model has this problem. Lower and upper control arms need to be welded back because they rotted off.

PURCHASED A 2002 JEEP FROM TWIN RIVERS AUTO SALES, I DID NOT RECEIVE A VEHICLE DISCLOSURE REPORT AND IT WAS SOLD TO ME WITH A CONTROL ARM BRACKET THAT WAS DAMAGED WAS NOT ATTACHED TO THE FRAME WHICH MAKES DRIVING THE VEHICLE IMPOSSIBLE IT IS NOT ATTACHED TO FRAME WHICH COULD HAVE CAUSE OTHER'AND MYSELF EXTREME HARM OR DEATH. I WAS NOT INFORMED OF ANY PROBLEM WITH FRAME, AFTER PURCHASE THE DEALERSHIP TOLD ME TO TAKE IT TO ZIEBART AND IT WOULD BE UNDERCOATED FOR FREE, THEY TRIED TO COVER UP WITH THE UNDERCOATING WHERE THE CONTROL ARM BRACKET BECAME DETACHED FROM THE FRAME ALONG WITH OTHER DEFECTS IN THE FRAME I WAS ONLY ABLE TO DRIVE THE JEEP FROM DEALERSHIP TO ZIEBARTS FOR THE UNDERCOATING AND THEN HAD TO HAVE TOWED TO MY HOUSE DUE TO THE STABILIZER LINK BREAKING BECAUSE OF THE CONTROL ARM BRACKET BREAKING AWAY FROM...

TL* THE CONTACT OWNS A 2002 JEEP WRANGLER. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE VIBRATED ABNORMALLY. THE CONTACT STATED THAT THE SUBFRAME OF THE VEHICLE SHOWED SEVERE RUST FROM THE FRONT TO THE REAR OF THE VEHICLE. ADDITIONALLY, THE LEAF SPRING ON THE PASSENGER'S SIDE OF THE VEHICLE WAS FRACTURED. THE CONTACT ALSO STATED THAT THE SUBFRAME ON THE DRIVER AND PASSENGER'S SIDE OF THE VEHICLE SHOWED A 60% FRACTURE. NEITHER THE DEALER NOR THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

THE DESIGN OF THE VEHICLE FRAME WAS FAULTY FROM THE ORIGINAL PURCHASE WHERE WATER AND DIRT CAN ENTER THE FRAME BUT NO WAY TO EXIT THEREFORE BECOMING TRAPPED TO ALLOW RUST TO FORM FROM THE INSIDE OF FRAME. THIS NOT ONLY PROMOTES BUT ALLOWS THE LIFE OF THE FRAME TO BECOME DANGEROUSLY WEAK AND IF IN A ACCIDENT NOT TO WITH STAND A IMPACT AND CREATE A SITUATION WHERE LIFE OR HARM TO PERSONS INCREASE.

TL* THE CONTACT OWNS A 2002 JEEP WRANGLER. THE CONTACT STATED THAT THE VEHICLE'S FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO WATERMARK CHRYSLER DODGE JEEP RAM (LOCATED AT 1055 CROSSING PL, MADISONVILLE, KY 42431, (270) 875-4432), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 200,000.

THE FRAME IS ROTTING TERRIBLY AND THE FRONT CONTROL ARMS ARE ABOUT TO CRACK OFF AND THE TRANS/SKID PLATE HAS ALREADY RUSTED THROUGH CAUSING THE TRANSFER CASE AND TRANS TO FALL OFF OF THE FRAME, VEHICLE WAS CITY DRIVING WHEN THIS HAPPEND

EXCESSIVE FRAME ROT DUE TO POOR DESIGN BY MANUFACTURER.

I KNOW THE JEEP IS A 2002, BUT THIS RUSTING, TO BE THIS BAD, HAD TO HAVE STARTED AWHILE AGO. I WENT TO HAVE TWO NEW TIRES INSTALLED AND WAS TOLD BY THE SHOP THAT THEY COULD NOT JACK OR LIFT THE VEHICLE DUE TO THE RUST. THIS IS PART OF THE FRAME, GOD FORBID IF IT WOULD HAVE FAILED. IT IS SO RUSTED THAT I CAN PUT MY FINGER THROUGH THE FRAME IN SPOTS. I DO NOT USE THE JEEP FOR OFF ROAD ACTIVITIES NOR PARK IT IN THE OCEAN. I ALSO WASH THE ROAD SALT OFF DURING THE WINTER. I HAVE INCLUDED PICTURES OF THE RUSTED PASS SIDE AND THE NOT TOO RUSTED DRIVER SIDE. THIS IS JUST AN AROUND TOWN VEHICLE. THIS IS RIDICULOUS AND JEEP SHOULD BE ASHAMED TO RELEASE A VEHICLE WITH SUCH A DANGEROUS DEFECT. I WONDER IF THIS IS A VEHICLE FROM A...

THE MAIN RIGHT SIDE FRAME SUPPORT FOR THE CENTERLINE SKID PLATE/TRANSMISSION RUSTED FROM THE INSIDE OUT. THIS RESULTED IN ALMOST DROPPING THE SKID PLATE AND TRANSMISSION WHILE THE VEHICLE WAS IN MOTION. I WOULD DEARLY LOVE TO KNOW WHY JEEP SOLD VEHICLES THAT BEGIN RUSTING WHERE IT CAN'T BE FOUND UNTIL CATASTROPHIC DAMAGE OCCURS.

FOUND DURING VEHICLE INSPECTION FOR OTHER REPAIRS. CALLED CHRYSLER AND WAS TOLD THAT VEHICLE HAD TO BE TAKEN TO A DEALER AND WAS GIVEN CASE# 31813048 DEALER INSPECTED (SEE FILE BELOW) ON 7-10-17 CALLED CHRYSLER 800-992-1997 AND SPOKE WITH BRI, SHE SAID THAT THERE IS NO COVERAGE AVAILABLE THROUGH CHRYSLER. I FIND WITH MILEAGE AND KNOWING THAT I KEEP MY CAR INSIDE DURING WINTER WEATHER CONDITIONS AND HAVE MAINTAINED VEHICLE AS PER CHRYSLER THAT THIS SHOULD NOT HAVE HAPPENED.

DUE TO A POOR DESIGN OF SIDE HOLES BUT NO BOTTOM DRAIN HOLES, WATER AND DIRT, ETC COLLECTED INSIDE THE REAR FRAME SECTION AND RUSTED IT FROM THE INSIDE OUT.

"RUSTED FRAME" I BOUGHT A 2002 JEEP WRANGLER AND THE LEFT SIDE OF THE FRAME IN THE MIDDLE WHERE THE SKID PLATE BOLTS IN TO THE FRAME IS RUSTED OUT PRETTY BAD AND I HAVE A CAUSE FOR CONCERN FOR SAFETY. WELL I DIDN'T FIND THIS PROBLEM BUT I THOUGHT THE UNIVERSAL JOINT WAS CAUSING MY BAD SHAKE WHEN I PULLED THE FRONT DRIVE SHAFT OUT I NOTICED THAT PROBLEM. ITS A 14 YEAR OLD VEHICLE BUT I DON'T BELIEVE THAT THE FRAME SHOULD BE RUSTED LIKE THIS. PLEASE FIX MY PROBLEM.. THE VEHICLE WAS STATIONARY IN MY DRIVEWAY

TAKATA RECALL- DRIVING DOWN A DARK COUNTY ROAD- LOST CONTROL OF VEHICLE AND WENT OFF ROAD AND HIT A TREE- UPON IMPACT THE JEEP BURST INTO FLAMES- THE DRIVER WAS PULLED OUT BECAUSE SHE WAS TRAPPED INSIDE THE BURNING JEEP- THE JEEP WAS TOTALED DUE TO THE FIRE

JEEP FRAME HAS RUSTED IN HALF IN SEVERAL PLACES COSTING$3,000.00 IN REPAIRS LUCKILY IT BROKE AT A LOW SPEED WITHOUT HARM TO ANYONE IF THIS HAPPENS AT HIGHWAY SPEEDS WHO KNOWS HOW MANY PEOPLE COULD HAVE BEEN INJURED.

MY FRAME AND SUSPENSION HAVE ROTTED OUT FROM THE INSIDE OUT. ITS COSTING ME OVER $6,000 TO REPLACE EVERYTHING.

THE FRAME IS DEVELOPING SEVERE RUSTING PREMATURELY AS COMPARATIVE TO OTHER VEHICLES OF THIS AGE OF MANUFACUTURE, MILEAGE, DRIVING CONDITIONS AND LOCATION OF OPERATION. *TR

PURCHASED A 2002 JEEP WRANGLER SAHARA WITH 4 MILES ON IT. ALL REQUIRED MAINTENANCE HAS BEEN DONE ROUTINELY. THIS VEHICLE HAS NEVER BEEN OFF ROAD AND WAS STRICTLY A DAILY DRIVER AVERAGING 12K MILES PER YEAR. I TOOK THE VEHICLE TO THE SHOP FOR AN OIL CHANGE AND THE MECHANIC BROUGHT ME INTO THE GARAGE TO SHOW ME THE FRAME WAS ALMOST COMPLETELY ROTTED THROUGH NEAR THE FRONT SUSPENSION. THE FRAME WHERE THE CROSS BRACKET THAT HOLDS THE TRANSMISSION IN PLACE HAS ALSO ROTTED. THE BOLTS IN THE BRACKET HAVE NOTHING TO HOLD ONTO BECAUSE THE FRAME HAS ROTTED THROUGH. THE MECHANIC STATED, "YOU ARE ONE POT HOLE AWAY FROM A MAJOR ACCIDENT". I BROUGHT IT TO ANOTHER MECHANIC WHO STATED "THIS IS A MAJOR SAFETY RISK AND I WOULD NOT SUGGEST DRIVING IT." OTHER THAN THE FRAME ROTTING OUT, THE VEHICLE IS IN PERFECT WORKING ORDER WITH NORMAL WEAR....

THE 2002 JEEP WRANGLER HAS APPROX. 85000 MILES ON IT. NEVER USED OFF ROAD - JUST TO AND FROM WORK. BROUGHT VEHICLE IN FOR WORK ON CLUTCH AND REPAIR SHOP STATES THAT THE VEHICLE FRAME IS ROTTED THROUGH AND NEED TO BE REPLACED BEFORE TRANSMISSION IS ABLE TO BE REMOVED. FRONT FENDERS HAVE RUSTED THROUGH IN SAME SPOT ON EACH SIDE. *TR

I PURCHASED THE JEEP 6/04. I PURCHASED IT FOR TRANSPORTATION BACK AND FORTH TO WORK. IT WAS NEVER USED OFF ROAD. IT ONLY HAS APPROX 81000 MILES AND THE FRAME IS COMPLETELY RUSTED FROM APPROX. THE BACK OF THE FRONT TIRES TO THE FRONT OF THE REAR TIRE. THERE MAY BE MORE BUT WE HAVE TO COMPLETELY STRIP DOWN VEHICLE TO ESTABLISH IF THERE IS MORE DAMAGE. ITS SO BAD THAT YOU CAN PUT A SCREW DRIVER THROUGH AND THROUGH THE FRAME AND THE TRANSMISSION AND THE TRAY IS DISCONNECTED FROM FRAME TO FRAME AND IS COMPLETELY HANGING. SCARE TO DRIVE IT. JEEP MAY FOLD CRUMBLE IN HALF. THIS I DEFINITELY A SAFETY ISSUE. IF I DIDN'T SEE ALL THE RUST ON THE DRIVEWAY I WOULD HAVE BEEN DRIVING AND GOD ONLY KNOW IF THERE COULD HAVE BEEN A FATALITY. WITH THE JEEP ONLY BEING 11 YEARS AT THE TIME...

WATER LEAKS INTO FRONT PASSENGER SIDE COMPARTMENT FROM AIR CONDITIONER DRAIN HOLE IN FIREWALL. WATER SOAKS FRONT CARPET, AND THE DRAIN PLUG IN FLOOR MUST BE REMOVED TO ALLOW WATER TO DRAIN OUT OF VEHICLE. APPEARS FOAM SURROUNDING DRAIN HAS FAILED ALLOWING THE WATER INTO THE VEHICLE.*AK

PAINT IS FLAKING OF ON FENDER, HOOD, DOOR, AND REAR DOOR.*AK

AT START UP, VEHICLE SHAKES AND SOUNDS LIKE INJECTORS ARE MISSING, NOT TAKEN TO DEALER YET. *AK VEHICLE TAKEN TO DEALER 3 TIMES, HOWEVER DEALERSHIP CANNOT DUPLICATE PROBLEM. VEHICLE BOGGS AND RUNS ROUGH/HESITATES WHEN COLD. REAR PORTION OF SOFT TOP LOCATED NEAR BOTTOM OF TAILGATE HAS GAP. REAR WEATHERSTRIP ADJUSTED. *TT