2002 INTERNATIONAL 9400I — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
4
Recalls
0
Service Bulletins
0
Investigations
Overview of the 2002 INTERNATIONAL 9400I
The 2002 INTERNATIONAL 9400I has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 4 recall campaigns affecting this vehicle, covering issues with EXTERIOR LIGHTING:BACK UP LIGHTS, ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD, EQUIPMENT:RECREATIONAL VEHICLE/TRAILER.
Recalls for the 2002 INTERNATIONAL 9400I
NHTSA has recorded 4 recalls for the 2002 INTERNATIONAL 9400I, potentially affecting up to 124,683 vehicles.
Recall 23V353000 — EXTERIOR LIGHTING:BACK UP LIGHTS
| 32,880 vehicles affected
Defect: Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up...
Consequence: Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy: Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.
View full details →Recall 04V307000 — ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
| 7,610 vehicles affected
Defect: ON CERTAIN HEAVY DUTY TRUCKS, THE ENGINE ELECTRICAL HARNESS CAN CHAFE AGAINST SHARP EDGES ON THE ENGINE.
Consequence: SUDDEN ACCELERATION, ACTIVATION OF THE ENGINE COMPRESSION BRAKE, ENGINE SPEED DROPPING TO IDLE, ALTERNATOR OVERLOAD WITH POSSIBLE FIRE, AND A LOSS OF ENGINE ECM POWER RESULTING IN ENGINE SHUTDOWN COULD OCCUR WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE HARNESS TO DETERMINE IF IT IS DAMAGED. IF DAMAGED, THE ENGINE HARNESS WILL BE REPAIRED. ALL HARNESSES WILL BE RE-ROUTED AND STAND-OFF BRACKETS WILL BE ADDED. THE RECALL BEGAN ON SEPTEMBER 8, 2004. OWNERS CAN CONTACT...
View full details →Recall 04V100000 — EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
| 83,312 vehicles affected
Defect: ON CERTAIN CONVENTIONAL TRUCKS EQUIPPED WITH PRO-SLEEPER BERTHS, WATER INTRUSION CAN BE FOUND IN THE BUNK CONTROL PANEL AREA AND POOL IN THE TOPS OF THE DOME LIGHT, TV/VCR, AND OR REFRIGERATOR POWER SWITCHES.
Consequence: THE CIRCUIT BOARDS IN THE SWITCHES COULD HEAT UP , POSSIBLY PRODUCE A FLAME OR FIRE, AND CAUSE PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy: DEALERS WILL INSTALL A WATER SHIELD OVER THE BACK OF THE ENTIRE BUNK CONTROL PANEL. OWNER NOTIFICATION BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
View full details →Recall 03V072000 — ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
| 881 vehicles affected
Defect: ON CERTAIN HEAVY DUTY TRUCKS BUILT WITH A DETROIT ENGINE AND A LEECE NEVILLE ALTERNATOR. THE ELECTRICAL TERMINAL AT THE ALTERNATOR END OF THE CABLE THAT RUNS FROM THE STARTER TO THE BATTERY STUD ON THE ALTERNATOR MAY BREAK OFF, DUE TO VIBRATION IN THE CABLE.
Consequence: IF THE TERMINAL BREAKS OFF, THE CAB WILL LOSE ALL POWER, RESULTING IN COMPLETE ELECTRICAL FAILURE AND ENGINE SHUTDOWN, WHICH MAY RESULT IN A CRASH AND POTENTIALLY CAUSE PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy: DEALERS WILL REROUTE AND REWIRE THE WIRING HARNESS TO THE ALTERNATOR. OWNER NOTIFICATION BEGAN ON MARCH 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY...
View full details →Owner Complaints for the 2002 INTERNATIONAL 9400I
No complaints have been filed with NHTSA for the 2002 INTERNATIONAL 9400I.
Safety Rating for the 2002 INTERNATIONAL 9400I
NHTSA has not yet tested the 2002 INTERNATIONAL 9400I in its New Car Assessment Program.
Technical Service Bulletins for the 2002 INTERNATIONAL 9400I
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 2002 INTERNATIONAL 9400I
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the INTERNATIONAL 9400I
- 2001 INTERNATIONAL 9400I — 0 complaints
- 2002 INTERNATIONAL 9400I (current)
- 2003 INTERNATIONAL 9400I — 1 complaint
- 2004 INTERNATIONAL 9400I — 0 complaints
- 2005 INTERNATIONAL 9400I — 2 complaints
- 2006 INTERNATIONAL 9400I — 0 complaints
- 2007 INTERNATIONAL 9400I — 4 complaints
Other INTERNATIONAL Models
- INTERNATIONAL 4300 — 58 total complaints
- INTERNATIONAL PROSTAR — 52 total complaints
- INTERNATIONAL LT — 28 total complaints
- INTERNATIONAL INTERNATIONAL — 26 total complaints
- INTERNATIONAL CE — 24 total complaints
- INTERNATIONAL SCHOOL BUS — 21 total complaints
- INTERNATIONAL 4400 — 11 total complaints
- INTERNATIONAL 9900I — 10 total complaints