2011 HYUNDAI SANTA FE Engine Problems

CATASTROPHIC ENGINE FAILURE. With no prior indications, the engine seized while driving on side street at 25mph. Engine blew hole in block and dumped engine parts, including piston rod, piston and engine block remnants, and oil on street. Very dangerous as power steering stopped and was unable to turn. Very low miles, 40,680, with all maintenance performed by dealer. Filed a report with Hyundai USA, no action taken.

The contact owned a 2011 Hyundai Santa Fe. The contact stated while the contact's daughter was driving at an undisclosed speed, the contact noticed a burning odor and the vehicle stalled. The contact idled the vehicle to the shoulder of the road and exited the vehicle. The vehicle burst into flames after the occupants exited the vehicle. The contact's daughter and daughter's friend were occupants of the vehicle at the time of the failure. No injuries were sustained. The fire department arrived and extinguished the fire. A Police report was filed. The vehicle was towed to a local tow yard. The vehicle was condemned to total loss. The manufacturer was made aware of the failure. The failure mileage was approximately 280,000.

The contact owns a 2011 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the charger indicator warning light illuminated and the engine seized. The battery was recharged. The vehicle was taken to an independent mechanic where it was diagnosed with a failed valve cover gasket leak and that the valve cover gasket and the alternator needed to be replaced. The vehicle was not repaired. The vehicle was scheduled to be taken to the dealer for inspection within the week. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 126,600. The VIN was unavailable.

I was driving the car on a 4 lane road when suddenly the engine shut off and the car was no longer functioning. I lost power steering and had to coast into a nearby parking lot, otherwise I would have caused a major accident in the middle of a busy intersection with another 4 lane road. Upon taking the car to Hyundai for evaluation, it was declared to be total engine failure. Given the other issues with Hyundai engines failing and the fact that I VERY NARROWLY AVOIDED A MASSIVE COLLISION, I would like NHTSA to be aware that this problem may go back farther than Hyundai has addressed so far.

My 2011 Hyundai Santa Fe had 75,000 miles on it in September 2022. It was bought and serviced by the same dealership and I am the original owner. It was last serviced at the end of June 2022. While returning from Corvallis, Oregon to Forest Grove, Oregon, the car's display light all turned on and a second late the car completely stopped. I am thankful that I decided to take the back road home, if I had been on the highway, I am positive I would have been in a serious accident. It has been determined by the dealership that there was a complete engine failure. It has been at the Hyundai dealership for four months now and there is no replacement engine available for it. Not only that, they can't get a reasonably priced replacement engine anywhere. This car would have been a valuable trade in on a new...

UNKNOWN warning I’m the owner of a 2011 Hyundai Santa Fe and a week ago at 185k mikes all of a sudden driving on the freeway it started hesitating and sounded like metal grinding and smoking really bad. Pulled to the side of the freeway on a ramp at that. Tried to restart the vehicle and I heard a bang noise which upon later discovery the engine blew a rod with no warning locked the steering wheel couldn’t get the keys out of the ignition DO NOT buy this car still owe 5k on the vehicle

ENGINE STALLS

We have (had) a 2011 Hyundai Sante Fe. On 9/21/21, driving to Bozeman, just west of Livingston MT, on I-90, the car had a sudden stalling, loss of power (check engine light, oil light came on), then knocking sound that increased in volume and frequency. Smoke began pouring from under the hood as we pulled to the side of the highway, then very quickly accompanied by flames. We exited the vehicle. I opened the hood, the flames shot into the air. We moved away from the car. 911 had been called and the local fire department arrived within 10-15 minutes. Fire extinguished after about 20-30 minutes, but engulfed (destroyed) the entire engine compartment. Flames did not spread to passenger area of the vehicle. No one injured from the fire (although possible smoke inhalation before and as we exited vehicle). Car totaled, towed from highway. 1. Component: engine, all components in...

AS I WAS DRIVING MY FAMILY HOME FROM A SOCCER MATCH IN DENVER TO OUR HOME IN BRECKENRIDGE MY CAR(HYUNDAI, SANTA FE 2011) LOST ALL POWER WITH OUT THE ENGINE DYING. WE WERE HEADING WEST AND IN THE TUNNEL. IT WAS EXTREMELY SCARY AND PUT MY FAMILY IN DANGER. NO WARNING LIGHTS HAVE EVER COME UP ON MY CAR BEFORE OR AFTER. THIS IS THE FIRST TIME OF MANY INCIDENTS THAT THIS HAS HAPPENED AND NOT ONLY WHEN I HAVE BEEN DRIVING BUT ALSO MY DAUGHTER, SHE HAS HER PERMIT! IT DOESN'T JUST HAPPEN ON THE INTERSTATE BUT ALSO AROUND OUR COMMUNITY WHILE DRIVING. I HAVE HAD IT CHECKED IT OUT WITH MY MECHANIC AND THEY COULDN'T FIND THE ISSUE AS THE DIAGNOSTIC CAME UP WITH NOTHING. THIS IS A SERIOUS SAFETY HAZARD NOT ONLY FOR MYSELF BUT MY FAMILY AND OTHERS ON THE ROAD.

CAR SMOKING FROM EXAHUST SINCE AROUND 42000 MILES OIL SMOKE STARTED IN 2017 . I HAVE TAKEN TO DEALERSHIP ABOUT 8 TIMES IN 3 YEARS NOW OIL ALL IN THE SPARKPLUGS USING OVER A QUART OF OIL EVERY 1000 MILES NOW HAS 56000 MILES AND UNABLE TO DRIVE IT. DEALSHIP TELLING ME THEY WILL HAVE CAR FOR ONE MONTH OR MORE WITH NO REPLACEMENT CAR GIVEN HAVE BEEN TOLD MAY NOT FIX REPLACE THE MOTOR I CALLED MAIN COMPANY EARLIER THIS YEAR. NOTHING WAS DONE.SMOKES AT START UP SMOKES OUT MY GARAGE . THEN CAR WAS SHIMMING WHEN DRIVING AND ENGINE LIGHT CAME ON .

CAR STARTED SMOKING BLUE SMOKE OUT OF THE EXHAUST AT 45,000 MILES WAS NEVER TREATED FOR AN OIL CONSUMPTION TEST. I DIDN'T KNOW THERE WAS SUCH A THING WAS NOT ADVISED AT THAT TIME NOW 3 YEARS LATER SUV ONLY HAS 56,000 IT USED 2 QUARTS OF OIL IN 1700 MILES. SINCE I DON'T DRIVE IT MUCH THEY ARE SAYING I HAVE TO START ALL OVER AGAIN SINCE I HAD NOT BEEN IN SINCE MAY 2020. IT IS NOW JULY DRIVEN IT 1300 MILE I WAS TOLD MUST START CONSUMPTION TEST FROM BEGINNING NOT WITH IN THE 1000 MILE RANGE . THEY NEVER FILED OUT ANY CONSUMPTION CHART TO START WITH . THIS CAR ONLY HAS ONE YEAR REMAINING ON WARRANTY AND THEY ARE TRYING TO RUN OUT THE WARRANTY WITHOUT FIXING IT. CAR SMOKES UP MY WHOLE GARAGE UPON STARTING , IT HAS COVERED PEOPLE UP WITH BLUE SMOKE...

ENGINE BLOWN SHORTLY AFTER 'SERVICE ENGINE' LIGHT CAME ON

THIS IS TO MAKE AWARE OF POTENTIAL/ POSSIBLE ENGINE FIRE CAUSE IN SOME HYUNDAI VEHICLES. I OWN A 2011 SANTA FE. AT LESS THAN 70K MILES THE OIL LIGHT BEGAN TO FLICKER AND LEAK OIL. DEALERSHIP INDICATED I RUINED ENGINE AND I WAS RESPONSIBLE FOR ALL REPAIR COSTS DUE TO BLA BLA BLA. I TOOK VEHICLE TO INDEPENDENT SHOP AND THEY FOUND AND REPLACED DEFECTIVE OIL PRESSURE SWITCH HYUNDAI #9475037000 WHICH LEAKED OIL ONTO TOP ENGINE, CREATED A LARGE POOL OF HOT OIL THAT SAT THERE HIDDEN UNDER OTHER COMPONENTS. ( FIRE HAZARD ). THEN- AT 130K MILES IT HAPPENED AGAIN. REPEAT REPLACEMENT OF GENUINE DEFECTIVE OIL PRESSURE SWITCH AND HOT OIL ON ENGINE (FIRE HAZARD) CONTACTED HYUNDAI TO EXPLAIN THE FIRE HAZARD DEFECTIVE OIL SWITCH ISSUE. ALL THEY COULD SAY WAS TAKE IT TO DEALERSHIP. WELL I DID JUST THAT THE FIRST TIME THIS HAPPENED SO WHY GO BACK...

MY CAR STARTED RUNNING HOT PERIODICALLY, THE THERMOSTAT GAUGE KEPT GOING UP AND DOWN. THERE WAS A BUBBLING SOUND IN RADIATOR RESERVE CONTAINER. MY VEHICLE WOULD NOT STAY CRANKED.

SOMETHING IN THE ENGINE , HARNESS OR MODULE , ALLOWS THE COMPUTER TO OVERHEAT SUDDENLY , THROUGH 3 BATTERS AND 2 ALTERNATORS IN 4 MONTHS LAST ALTERNATOR LASTED 2 DRIVES... CAR DIES NANCY DEPRESSIVE LIGHT SHOW AND DIED THEN THE BATTERY AND ALTERNATOR IS FRIED. HYUNDIA DEALERSHIP REFUSING TO CHECK HARNESS OR MODULE BECAUSE MY VIN NUMBER ISN'T LISTED IN RECALL ALTHOUGH MY CAR IS IN THE RECALL. THE CAR HAS DIED 4 TIMES REQUIRING TOWING. THE CAR DIED WHEN DRIVING AFTER ABOUT 10 MILES . CAR HAS BRAND NEW BATTERY. STARTER WORKS FINE. IT DIED IN THE MIDDLE IF A STREETCEACH TIME TWICE WAS AT NIGHT. AND I AM A DISABLED WOMAN WHO USES A WHEELCHAIR. MONDAY JUNE 24TH WAS THE MOST RECENT TIME AT 1 PM IN 104 DEGREE HEAT FOR 5 HOURS WITH A HEART CONDITION WHICH WAS DOUBLY DANGEROUS SITUATION. THE BATTERY DIED EVENTUALLY LEAVING ME...

THE VEHICLE DEVELOPED A LOW END ENGINE RATTLE DURING IDLE. THE NOISE WOULD GO AWAY ON ACCELERATION. TODAY THE ENGINE FAILED. IT WON'T TURN OVER AT ALL. IT'S SEIZED UP. I CHECKED THE OIL AND THE OIL IS FULL. I BOUGHT THIS VEHICLE WHEN IT WAS 2 YEARS OLD. I'VE USED SYNTHETIC OIL AND CHANGED THE OIL EVERY 3 - 4,000 MILES. THE SYMPTOMS ARE IDENTICAL TO THE ONES ON THE SONATA AND OTHER VARIOUS MODELS. MY VEHICLE WAS MANUFACTURED HERE IN THE STATES. AN ENGINE IS A HUGE EXPENSE. ESPECIALLY IF IT'S DUE TO MANUFACTURER NEGLIGENCE. I WILL NEVER BUY ANOTHER HYUNDAI OR KIA AGAIN AT THIS POINT.

MY 2011 HYUNDAI SANTA FE WAS BEING DRIVEN ON THE CITY STREETS AT A SPEED OF APPROX. 30MPH WHEN THE ENGINE STARTING MAKING A LOUD NOISE IN THE ENGINE. FOUND THE ENGINE HAS A BENT ROD. THE CAR HAS 110,000 MILES AND HAS HAD A REGULAR OIL CHANGE EVER SINCE WE BOUGHT THE CAR. HAS ANYONE ELSE HAD THIS PROBLEM. ALL OTHER VEHICLES I HAVE OWNED OR OWN NOW LAST WELL OVER 200,000 MILES. HAD TO TOW THE VEHICLE HOME 80 MILES. HOPE THIS DOESN'T HAPPEN TO ANYONE ELSE. NEVER HAD A WARNING THIS WAS ABOUT TO HAPPEN. THANK GOODNESS HE WAS ON A CITY STREET..

WHILE DRIVING THE VEHICLE THE ENGINE STOPPED RUNNING WITHOUT WARNING OR SYMPTOMS. IT WOULD NOT RESTART. IT NEEDED TO BE TOWED. FURTHER INVESTIGATION FOUND THE ENGINE HAD SEIZED.

MY 2011 HYUNDAI SANTA FE BEGAN TO DRIVE ROUGH ON THE FREEWAY, SLIGHT TUGGING, RATTLING SOUND UNDER THE HOOD AND WOULD NOT ACCELERATE ABOVE 60MPH, CHECK ENGINE AND OIL LIGHT CAME ON. I EXITED THE FREEWAY AND IT STALLED AT RED LIGHT. STARTED IT UP AND THEN STALLED 3 MORE TIMES AT EVERY RED LIGHT ON THE WAY HOME. I ADDED OIL AND MADE SERVICE APPT. BROUGHT IN FOR SERVICE DIED ONCE ON THE WAY AND AGAIN AT THE SERVICE CENTER BUT DID NOT START BACK UP. MECHANIC SAID ENGINE FAILED DUE TO CRANK SHAFT SPUN BEARING. SENSORS DID NOT APPEAR IN ADVANCE SENSORS APPEARED TOO LATE CAUSING DAMAGE TO ENGINE. MY CAR IS ONLY 7 YEARS BOUGHT BRAND NEW OUT OF SHOW ROOM NO PREVIOUS MAJOR ISSUES. MULTIPLE COMPLAINTS ON LINE SHOWING SAME PROBLEM WITH OTHERS. UNACCEPTABLE AND DANGEROUS

WHILE DRIVING HOME ON WEDNESDAY DECEMBER 12 2018 MY HYUNDAI SANTA FE ENGINE CAUGHT ON FIRE AND BURNED UP THE WHOLE FRONT END.

TL* THE CONTACT OWNS A 2011 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 5 MPH AND ATTEMPTING TO PARK, THE ENGINE SUDDENLY REVVED VERY HIGH, THE RPMS INCREASED, AND THE VEHICLE ATTEMPTED TO ACCELERATE. THE DRIVER IMMEDIATELY DEPRESSED THE BRAKE PEDAL AND SHUT THE ENGINE OFF TO PREVENT THE VEHICLE FROM ACCELERATING FORWARD AND CRASHING INTO A WALL. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 123,279.

ENGINE NOISE AT COLD START. WHEN STARTING THE VEHICLE AFTER THE CAR HAS SAT FOR OVER AN HOUR, A LOUD RATTLE NOISE IS HEARD FOR 3-5 SECONDS. THE NOISE IS COMING FROM OIL STARVATION. I HAVE BEEN QUOTED THAT IS A TIMING CHAIN AND GUIDE ISSUE. SEVERAL PEOPLE ONLINE ARE EXPERIENCING THE SAME PROBLEM.

CAR WAS DRIVEN ABOUT 10 MILES AND THEN PARKED INSIDE AN ATTACHED GARAGE. NO ISSUES WERE PRESENT DURING THE DRIVE. THE IGNITION WAS TURNED OFF AND KEY REMOVED FROM VEHICLE. AFTER APPROXIMATELY 1 HOUR HAD PASSED THE CAR STARTED ON FIRE. FLAMES WERE VISIBLE BEHIND THE FRONT RIGHT HEADLIGHT AND FRONT RIGHT WHEEL. LUCKILY NO ONE WAS HARMED. THE FIRE CAUSED SIGNIFICANT DAMAGE TO THE GARAGE AND HOME. FIRE DEPARTMENT INVESTIGATION CONCLUDED THAT THE CAUSE OF THE FIRE WAS NOT EXTERNAL TO THE VEHICLE.

ENGINE SHUTDOWN AND I CANNOT STEER THE WHEEL.

SEVERAL MONTHS AGO THE FAN IN ENGINE CONTINUED RUNNING AFTER VEHICLE WAS TURNED OFF. RAN BATTERY DOWN. WE COULD HEAR THE FAN RUNNING BUT HAD NO IDEA HOW TO STOP IT. NO PROBLEMS UNTIL YESTERDAY WHEN THE SAME THING HAPPENED. ONLY DIFFERENCE WAS WE COULD NOT HEAR THE FAN RUNNING UNTIL WE POPPED THE HOOD TO JUMP START THE CAR.

ON SATURDAY 6/3/17 I WAS DRIVING HOME FROM A BABY SHOWER WHEN I HEARD A METAL SOUNDING NOISE TOWARDS THE FRONT OF MY CAR AFTER HITTING A BUMP. THE NOISE ONLY HAPPENED ONCE AND WHEN I PULLED IN THE DRIVEWAY AND TURNED MY CAR OFF IT SOUNDED LIKE METAL PARTS FALLING OUT UNDER MY CAR BUT WHEN I CRAWLED UNDER MY CAR NOTHING LOOKED ABNORMAL, SO I GOT BACK IN THE CAR TO START IT AND IT WOULD NOT START. MONDAY 6/5/17 I HAD MY CAR TOWED TO KELLEY RADIATOR TO BE LOOKED AT, AFTER THEM CHECKING EVERYTHING THEY TOLD ME MY ENGINE IS SEIZED. THE OWNER OF KELLEY RADIATOR CANNOT FIGURE OUT WHY MY ENGINE SEIZED, HE HAS CHECKED EVERYTHING SUCH AS FLUIDS TO MECHANICAL PARTS AND EVERYTHING CHECKS OUT GOOD. I DID SOME RESEARCH AND FOUND ENGINE FAILURE IS A COMMON PROBLEM WITH CERTAIN HYUNDAI CARS. I HAVE...

TL* THE CONTACT OWNS A 2011 HYUNDAI SANTA FE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V226000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS UNABLE TO CONFIRM WHEN THE PARTS WOULD BE AVAILABLE. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

ENGINE STALLED TWICE DURING 35MPH DRIVE HOME THIS EVE, MAKING STEERING AWAY FROM ONCOMING TRAFFIC EXTREMELY CHALLENGING AND TERRIFYING. OCCURRED ON #3 AND #4 OF 6 RIGHT TURNS.

2011 HYUNDAI SANTA FE STALLS, LOSES POWER, WILL NOT ACCELERATE, GIVES NO WARNING. THIS COULD CAUSE A MAJOR ACCIDENT AND MULTIPLE DEATHS. THIS HAPPENS SUDDENLY WHILE DRIVING ALONG CITY STREETS AND HIGHWAYS AND WHILE TURNING. *TR

MULTIPLE TIMES THE ENGINE JUST SHUTS OFF. THIS HAS HAPPENED AT IDLE AND AT SPEED. FULL LOSS OF POWER, ALL LIGHTS ON DASH ILLUMINATE, LOUD BANG WHEN AT SPEED. IF YOU PUT IN NEUTRAL AND RE-ENGAGE IGNITION CAR WILL START. THIS HAS HAPPENED MULTIPLE TIMES. LAST WAS 9/6

WHILE DRIVING THE MOTOR LOCKED UP WITH NO WARNING. NO OIL LEFT IN THE PAN BUT NO LIGHTS CAME ON.

ON 3 SEPARATE OCCASIONS MY VEHICLE WOULD REV UP THE RPM'S AND THEN SLOW WAY DOWN AND VEHICLE PAUSED FOR ABOUT 5-10 SECONDS THEN REENGAGED. ALSO, THE ENGINE SEEMS ACCELERATES AND SLOWS DOWN ON ITS OWN, DOESN'T FEEL LIKE TAKING FUEL AT TIMES. MY COMPLAINT SOUNDS SIMILAR TO NHTSA ID# 10744564, HOWEVER, MY VEHICLE DID NOT MAKE A LOUD SOUND FROM UNDERNEATH. I HAVE HAD MY 60000 MI SERVICE COMPLETED AND ISSUE PRESENTED AFTERWARDS. LUCKILY, THESE 3 INCIDENTS HAPPENED ON LOW VOLUME TRAFFIC STREETS. I HAVE HAD SERVICE AFTER AT DIFFERENT HYUNDAI DEALERS WITHOUT EXPLANATION.

TL* THE CONTACT OWNS A 2011 HYUNDAI SANTA FE. WHILE DRIVING AT HIGH SPEEDS, THERE WAS A SUDDEN INCREASE AND SUDDEN DECREASE IN ENGINE RPMS. THE CONTACT STATED THAT THE ELECTRICAL FUNCTIONS OF THE VEHICLE FAILED AND A LOUD NOISE EMITTED FROM UNDERNEATH THE VEHICLE. THE CONTACT STATED THAT THE ENGINE STALLED BRIEFLY, BUT WAS ABLE TO RESUME NORMAL OPERATION. WHILE DRIVING AT LOW SPEEDS, THE FAILURE RECURRED; HOWEVER, THE ENGINE STALLED COMPLETELY. THE CONTACT MANEUVERED TO THE EMERGENCY LANE AND WAS ABLE TO RESTART THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED FOR HESITATION OF THE MOTOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. THE VIN WAS NOT AVAILABLE. UPDATED 09/18/15*LJ

I WAS STOPPED AT A RED LIGHT WITH MY FOOT ON THE BRAKE, WHEN THE ENGINE SUDDENLY REVVED VERY QUICKLY AND LURCHED FORWARD TOWARDS THE CAR IN FRONT OF ME. I TURNED THE ENGINE OFF AND THE CAR STOPPED. FORTUNATELY THERE WAS ENOUGH ROOM BETWEEN MY CAR AND THE ONE IN FRONT OF ME THAT I DIDN'T HIT IT. WHEN I RESTARTED IT, IT WORKED FINE. *TR

WE OWN A 2011 HYNUDAI SANTA FE AND HAD AN INCIDENT LAST NIGHT PULLING INTO A PARKING SPOT, WHICH APPEARS TO BE SOMETHING OTHERS HAVE EXPERIENCED: SUA SUDDEN UNINTENDED ACCELERATION. I WAS PULLING INTO THE PARKING SPACE WITH MY FOOT ON THE BRAKE AND THE MOTOR JUST STARTED RACING FULL THROTTLE FOR NO APPARENT REASON. I MASHED ON THE BRAKE AND FELT IT FADE OUT UNDER THE FORCE OF THE INCREASED MOTOR RPM. I QUICKLY SHIFTED INTO NEUTRAL AND THE ENGINE CONTINUED TO RACE BUT I HAD MY FOOT COMPLETELY REMOVED FROM THE BRAKE OR ACCELERATOR PEDALS. I THEN SHUT THE ENGINE OFF. MY WIFE AND I WERE SHAKEN BUT UNINJURED. AFTER COMPLETING OUR REASON FOR THE STOP, THE VEHICLE STARTED NORMALLY AND WE RETURNED HOME WITH NO FURTHER INCIDENT. BUT OUR CONFIDENCE IN THE VEHICLE HAS GONE TO ZERO. THIS WAS THE FIRST AND ONLY TIME THIS HAS OCCURRED...

VEHICLE STALLED WHEN LEAVING STOP LIGHT LOST SPEED WOULD NOT ACCELERATE HAVE READ OTHER COMPLAINTS ON LINE SOME ARE AFRAID TO DRIVE VEHICLES I AGREE SAFTEY IS AN ISSUE DEALER OR MANUFACTURE CANNOT FIND SOLUTION TO PROBLEM. *TR

DRIVING ON INTERSTATE 1 HOUR EAST OF ASHEVILLE, NC IN HEAVY TRAFFIC. AT APPROXIMATELY 230 PM ON 8/20/2014 THE CHECK ENGINE LIGHT CAME ON, THE CAR SHUDDERED AND LOST ALL ACCELERATION. COMPLETE LOSS OF POWER MANAGED TO COAST TO THE SIDE OF THE ROAD AND TURNED CAR OFF. RESTARTED AND DROVE TO HYUNDAI DEALERSHIP IN ASHEVILLE, NC ABOUT 30 MILES AWAY. THEY PERFORMED A SOFTWARE UPDATE AND STATED PROBLEM WAS RESOLVED. CONTINUED DRIVING ON HIGHWAY (TRAVELING BACK TO DAYTON OH), AND WITHIN 1 HOUR CHECK ENGINE LIGHT CAME ON, AT ABOUT 700 PM, A COMPLETE LOSS OF POWER AND NO ACCELERATION, AND HAD TO COAST TO THE SIDE OF THE ROAD, RESTART THE ENGINE, ETC. AGAIN, INCREDIBLY DANGEROUS SITUATION ON A BUSY INTERSTATE. THE SAME EXACT SITUATION HAPPENED 2 MORE TIMES ON OUR WAY HOME ON THE INTERSTATE, UNTIL WE COULD FINALLY TAKE IT TO OUR DEALER WHERE THEY REPLACED...

ENGINE SHUTS OFF AFTER TAKING FOOT OFF GAS, SLOWING DOWN AND THEN APPLYING GAS TO ACCELERATE. AFTER A SHORT PAUSE APROXIMATELY 15 TO 20 SECONDS, THE ENGINE WILL RESTART AND RESUME NORMAL OPERATION. NO CHECK ENGINE LIGHT APPEARS. THE ENGINE HAS THREE TIMES IN THE LAST 14 MONTHS. CAR WAS BROUGH TO DEALER AFTER FIRST TIME AND NO CODES OR ISSUES COULD BE FOUND. I WILL BRING CAR BACK TO DEALER NOW AFTER THE THIRD TIME. THIS IS LAST STALL RESULTED IN A CLOSE CALL IN HEAVY TRAFFIC. *TR

TL* THE CONTACT OWNS A 2011 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 50.

WHILE DRIVING THE ENGINE DIED SUDDENLY, I WAS ABLE TO RESTART THE ENGINE. THIS HAS HAPPENED MULTIPLE TIMES AND IS VERY DANGEROUS FOR A REAR END COLLISION, I HAVE TAKEN THE CAR TO HYUNDAI DEALERSHIPS BUT THEY ARE UNABLE TO DUPLICATE THE PROBLEM AND SAY THAT THEY CAN'T FIND ANYTHING WRONG WITH THE VEHICLE. I HAVE NOTIFIED HYUNDAI OF THE PROBLEM AND THEY JUST TELL ME TO TAKE IT TO A DIFFERENT DEALERSHIP. I HAVE RESEARCHED THIS ISSUE ON THE INTERNET AND THERE SEEMS TO BE MANY HYUNDAI OWNERS HAVING THE SAME ISSUE WITH THE SAME YEAR AND MAKE OF VEHICLE. THERE DOESN'T SEEM TO BE A FIX FOR THIS PROBLEM THAT HYUNDAI IS AWARE OF. PLEASE HELP! THANK YOU *TR

2011 HYUNDAI SANTA FE. CONSUMER WRITES IN REGARDS TO WHILE DRIVING VEHICLE ENGINE SHUT OFF AND CAR DIED. *SMD THE CONSUMER STATED WHEN HE SLOWED DOWN TO GO AROUND A CURVE, THE VEHICLE SHUT OFF. HE COULD BARELY GET THE VEHICLE TO THE SIDE OF THE ROADWAY, BECAUSE THERE WAS NO POWER STEERING OR POWER BRAKES. TECH SUPPORT, RECOMMENDED REPLACING THE THROTTLE BODY, SINCE THE DEALER COULD NOT FIND A PROBLEM. HOWEVER, ON MARCH 1, 2014, WHILE DRIVING IN A PARKING LOT AT 10 MPH, THE ENGINE SHUT OFF AGAIN. THE POWER STEERING AND BRAKES WERE NOT OPERABLE. HE LET THE VEHICLE SIT FOR SEVERAL MINUTES BEFORE RE-STARTING IT. THE CONSUMER RETURNED TO THE DEALER, AND AFTER A THOROUGH EXAMINATION, THEY WERE UNABLE TO DUPLICATE THE PROBLEM. *JB

TL* THE CONTACT OWNS A 2011 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURE WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 38,800 AND THE CURRENT MILEAGE WAS 38,920.

THIS IS A FOLLOW UP TO THE COMPLAINT I MADE ON 5/13/2013. AT THAT TIME MY VEHICLE WAS AT THE DEALERSHIP TO TRY TO DUPLICATE THE PROBLEM I HAD BEEN HAVING WHICH WAS THAT MY CAR WOULD RANDOMLY STALL WHILE MAKING A TURN, WHETHER LEFT OR RIGHT. WHEN THIS HAPPENED THE PANEL WOULD LIGHT UP LIKE CHRISTMAS AND EVERYTHING INCLUDING THE BRAKES WOULD CEASE TO WORK. I HAVE TO COAST TO A SAFE LOCATION (IF POSSIBLE) TO TURN OFF CAR AND THEN RESTART IT. I HAVE BEEN VERY FORTUNATE THAT ME OR MY FAMILY HAVE NOT BEEN HIT WHEN THIS HAPPENS. UPDATE TO LAST REPORT: MY CAR STAYED AT THE DEALERSHIP FOR 3 WEEKS HOWEVER THE PROBLEM WAS NOT DUPLICATED. THEIR SOLUTION (HYUNDAI USA AND MY DEALERSHIP) WAS TO REPLACE THE THROTTLE BODY. EVERYTHING WAS FINE UNTIL THE SAME PROBLEM OCCURRED ON 1/19/2014. I DON'T THINK HYNDAI USA WILL BE...

WHILE ACCELERATING FROM A TRAFFIC LIGHT, VEHICLE DROPPED SPEED WHILE I ACCELERATED. IT COASTED ALONG AT 1-2 MILES AN HOUR. THE CHECK ENGINE, ANTILOCK BRAKE AND 4 WHEEL DRIVE 'SKID' INDICATORS ALL LIT UP ON THE DASH BOARD. I HAD TO GUIDE THE VEHICLE TO A SAFE STOP BY THE SIDE OF THE ROAD AFTER CLEARING A DANGEROUS INTERSECTION. THIS HAS OCCURRED FOUR ADDITIONAL TIMES AFTER THE DEALERSHIP ASSURED ME THIS PROBLEM HAD BEEN RECTIFIED. IT IS PRESENTLY AT THE DEALERSHIP AFTER HAVING BEEN TOWED IN FOR THE FIFTH (5TH) TIME. THIS CAR NEEDS TO BE REPLACED BY THE DEALER. *TR

WHILE DRIVING AT SLOW SPEED 10-15 MPH AND BRAKING THE CAR COMPLETELY STALLED, ONCE WHILE TURNING LEFT AND ONCE WHILE GOING STRAIGHT. LOSS OF POWER STEERING AND POWER BRAKES AND NARROWLY AVOIDING HITTING ANOTHER VEHICLE. NO CHECK ENGINE LIGHT CAME ON AND NO CODES STORED. *TR

MY ENGINE HAS STALLED AT SEVERAL OCCASIONS BEGINNING AROUND APRIL 2013. THE FIRST 2 EVENTS HAPPENED AS I WAS STOPPED AT A RED LIGHT. I PUT MY FOOT ON THE ACCELERATOR AND NOTHING HAPPENED I HAD TO RESTART THE CAR TO GET IT MOVING AGAIN. THE CAR HAS ALSO STALLED TWICE WHILE I WAS REVERSING INTO A PARKING SPOT AND ONCE AS I WAS TURNING A CORNER I LOST CONTROL OF THE STEERING FUNCTION IN THE MIDDLE OF THE STREET. AS RECENTLY AS OCTOBER 2013 THE CAR STALLED AGAIN WHILE STOPPED AT A RED LIGHT. ALL OF THESE EVENTS HAPPENED AS I WAS STOPPED OR MOVING AT A LOW (LESS THAN 10 MPH) RATE OF SPEED. *TR

9/26/13 - WHILE GOING UP TO THE NEXT LEVEL OF A PARKING STRUCTURE AT A SLOW SPEED, THE VEHICLE STALLED. PUT IT INTO PARK AND RESTARTED IT AND DROVE IT TO A PARKING SPOT. LATER THAT DAY WAS ABLE TO DRIVE IT TO THE DEALERSHIP; THEY HAVE HAD IT FOR 4 DAYS (2 OF WHICH WERE OVER THE WEEKEND). NO CODES REGISTERED IN THE COMPUTER SYSTEM; THEY ARE WAITING TO HEAR FROM A HYUNDAI TECH. ACCORDING TO RESEARCH ONLINE, THIS IS A COMMON (AND DANGEROUS) PROBLEM WITH THE SANTA FE. PRIOR TO THIS EPISODE, ON 2 OTHER OCCASIONS (9/13/13 AND 8/3/2012), WAS DRIVING THE VEHICLE AT 70MPG AND 50MPH RESPECTIVELY AND LOST POWER AND THE ABILITY TO KEEP OR INCREASE MY SPEED AND HAD TO PULL OVER AND GET TOWED TO THE DEALERSHIP, BOTH TIMES. THIS TOO APPEARS TO BE COMMON AMONG ONLINE FORUMS FOR SANTA FE'S. *TR

FOR THE SECOND TIME THIS SUMMER THE ENGINE HAS JUST SHUT OFF WHILE DRIVING SLOWLY DOWN HILL. THIS TIME I BARELY MISSED CAUSING AN ACCIDENT AND HITTING A PEDESTRIAN. *TR

ON JUNE 11, 2013 I WAS DRIVING MY 2011 HYUNDAI SANTA FE. I WAS IN A PARKING LOT AND HAD PULLED INTO A PARKING PLACE. I WAS STOPPED AND PUTTING MY CAR INTO PARK. AS I REACH NEUTRAL MY CAR ACCELERATED FAST...THIS WAS MORE THEN A LUNGE FORWARD, IT WAS MORE LIKE A POWER SURGE. MY CAR CONTINUED FORWARD AT A VERY FAST SPEED, DESPITE MY BRAKING ( THERE WERE SKID MARKS) AND HIT A WALL. I ENDED UP WITH LOTS OF MASSIVE BRUISING AND SPRAINED MUSCLES. PLUS I WAS VERY FRIGHTENED. THERE WAS LOTS OF DAMAGE TO MY CAR. IT WAS TOWED TO THE DEALERSHIP, WHERE I PURCHASED IT. IT IS SILL IN THEIR BODY SHOP. A FEW DAYS AFTER THE ACCIDENT I CHECKED THE INTERNET TO SEE IF ANYONE ELSE HAD THIS PROBLEM. THERE WERE LOTS & LOTS OF EXAMPLES OF THIS, SUDDEN UNINTENDED ACCELERATION PROBLEM, WITH THE...

I TOOK IT IN FOR SERVICE AFTER THE ENGINE HESITATED AND BUCKED FORWARD SEPT, 2012. IT HAD APPROX. 29,500 MILES. TODAY JUNE 21, 2013 WHILE PUTTING IT IN REVERSE, I HEARD A LOUD "CLUNK" AND ALSO HEARD SAME "CLUNK" WHEN I CHANGED IT FROM REVERSE TO DRIVE. ENGINE THEN PROCEEDED TO HESITATE AND BUCK ALL THE WAY HOME. IT IS GOING IN FOR SERVICE AGAIN (SECOND TIME) TOMORROW. THIS IS VERY FRUSTRATING!! *TR