2006 GMC SIERRA — Problems, Recalls & Safety Data
N/A
Safety Rating
65
Owner Complaints
6
Recalls
6
Service Bulletins
0
Investigations
Overview of the 2006 GMC SIERRA
The 2006 GMC SIERRA has received a total of 65 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 6 recall campaigns affecting this vehicle, covering issues with EXTERIOR LIGHTING:HEADLIGHTS, EQUIPMENT:ELECTRICAL, WHEELS:RIM. 6 technical service bulletins have been issued by General Motors, LLC for this model year. The most commonly reported problems involve the Service Brakes (20 complaints), Electrical System (7 complaints), and Service Brakes Hydraulic (5 complaints).
Recalls for the 2006 GMC SIERRA
NHTSA has recorded 6 recalls for the 2006 GMC SIERRA, potentially affecting up to 240,041 vehicles.
Recall 09E025000 — EXTERIOR LIGHTING:HEADLIGHTS
| 42,540 vehicles affected
Defect: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
View full details →Recall 07E066000 — EQUIPMENT:ELECTRICAL
| 175 vehicles affected
Defect: CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Remedy: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
View full details →Recall 06V307000 — WHEELS:RIM
| 3,227 vehicles affected
Defect: CERTAIN SPORT UTILITY VEHICLES AND TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES HAVE AN INCOMPLETE TIRE RIM DESIGNATION ON THE CERTIFICATION/TIRE LABEL LOCATED ON THE DRIVER'S DOOR EDGE. IN ADDITION, THE LABEL MAY ALSO BE MISSING THE TIRE LOAD RATING ON THE LABEL. ALTHOUGH THIS INFORMATION...
Consequence: IF A CUSTOMER REPLACES A WHEEL AND ONLY RELIES ON THE RIM SIZE DESIGNATION THAT IS INDICATED ON THE LABEL, A WHEEL THAT IS OF A DIFFERENT RIM CONTOUR DESIGNATION MAY BE INSTALLED. IT MAY BE DIFFICULT OR IMPOSSIBLE TO MOUNT THE TIRE ON A WHEEL WITH THE WRONG CONTOUR. IF THE TIRE IS MOUNTED ON THE WHEEL WITH THE WRONG CONTOUR, THE WHEEL AND TIRE MAY NOT PERFORM AS INTENDED, WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy: A LABEL THAT WILL CORRECT THE LABEL ORIGINALLY INSTALLED WILL BE MAILED TO CONSUMERS ALONG WITH INSTALLATION INSTRUCTIONS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL. THE RECALL BEGAON ON NOVEMBER 7, 2006. OWNERS SHOULD CONTACT...
View full details →Recall 06V289000 — ENGINE AND ENGINE COOLING
| 38,439 vehicles affected
Defect: ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
View full details →Recall 05V552000 — EQUIPMENT:OTHER:LABELS
| 32,068 vehicles affected
Defect: CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT...
View full details →Recall 05V455000 — STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
| 123,592 vehicles affected
Defect: CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339,...
View full details →Owner Complaints for the 2006 GMC SIERRA
65 complaints have been filed with NHTSA for the 2006 GMC SIERRA. Below is a breakdown by vehicle component.
Most Recent Complaints
TOTAL BRAKE FAILURE WHILE IN MOTION. CORRODED BRAKE LINE RUPTURED CAUSING IMMEDIATE LOSS OF ALL FLUID. HAD THIS HAPPENED 5 MINUTES EARLIER, I WOULD HAVE BEEN ON A FOUR LANE HIGHWAY IN BUMPER TO BUMPER CHRISTMAS TRAFFIC. AT 70 YEARS OLD I CAN ONLY IMAGINE HOW CATASTROPHIC AN ACCIDENT MY REFLEXES WOULD HAVE GENERATED. THE FLUID SPRAYED ON THE HOT ENGINE CREATING A CLOUD OF SMOKE. I WAS AFRAID THE TRUCK WAS ON FIRE. THE FLUID COOKED OFF THE ENGINE AS SMOKE AND AGAIN LUCKILY THERE WAS NO FIRE. NOW AFTER EXTENSIVE REPAIRS, I AM VERY NERVOUS BEHIND THE WHEEL OF THIS VEHICLE. THIS VERY DANGEROUS SITUATION WITH CORROSION SHOULD BE ADDRESSED AS BLOGS ON THE INTERNET INDICATE THIS DANGEROUS ISSUE HAS BEEN ONGOING FOR QUITE AWHILE. I HAVE ATTACHED THE INVOICE OF THE REPAIRS REQUIRED. I WAS IN THE DRIVE THROUGH OF A MCDONALDS AND HAD PLACED MY ORDER AND WAS PULLING TO THE WINDOW TO PAY WHEN THE BRAKES FAILED. LUCKILY I WAS ONLY MOVING SLOWLY AT THAT TIME, THUS ABLE TO AVOID INJURING ANYONE OR DAMAGING ANY OTHER VEHICLES.
BRAKE PEDAL WENT TO FLOOR ALMOST CAUSING AN ACCIDENT BEFORE THE VEHICLE CAME TO A STOP. BEFORE THE SERVICE LIGHT CAME ON. THE SERVICE LIGHT DID COME EVENTUALLY AT WHICH TIME WE CHECKED THE MASTER CYLINDER WHICH WAS EXTREMELY LOW SO WE FILLED IT THINKING THAT WAS THE PROBLEM. THE NEXT DAY WE NOTICED BRAKE FLUID DRIPPING AND AFTER CHECKING REALIZED THAT AT LEAST ONE OF THE BRAKE LINES WERE WERE RUSTED THROUGH IN SEVERAL PLACES AND ALL OF THE OTHER LINES ARE TERRIBLY RUSTED AND PROBABLY ON THE VERGE OF LEAKING ALSO. THIS IS A TRUCK THAT WE USUALLY PULL OUR CAMPER WITH. LUCKILY WE WERE NOT PULLING IT AT THE TIME THIS OCCURRED.
TURNED OFF ENGINE, HVAC FAN STILL ON. WILL NOT TURN OFF. THIS IS THE DUAL CLIMATE CONTROL SYSTEM. HAD TO REMOVE FUSE SO THE BATTERY WILL NOT DISCHARGE. SERVICE BULLETINS WERE ISSUED FOR THIS PROBLEM BUT DID NOT INCLUDE ALL VEHICLES, INCLUDING OURS.
TURNED OFF ENGINE, HVAC FAN STILL ON. WILL NOT TURN OFF. THIS IS THE DUAL CLIMATE CONTROL SYSTEM. HAD TO REMOVE FUSE SO THE BATTERY WILL NOT DISCHARGE. SERVICE BULLETINS WERE ISSUED FOR THIS PROBLEM BUT DID NOT INCLUDE ALL VEHICLES, INCLUDING OURS.
TURNED OFF ENGINE, HVAC FAN STILL ON. WILL NOT TURN OFF. THIS IS THE DUAL CLIMATE CONTROL SYSTEM. HAD TO REMOVE FUSE SO THE BATTERY WILL NOT DISCHARGE. SERVICE BULLETINS WERE ISSUED FOR THIS PROBLEM BUT DID NOT INCLUDE ALL VEHICLES, INCLUDING OURS.
Safety Rating for the 2006 GMC SIERRA
NHTSA has not yet tested the 2006 GMC SIERRA in its New Car Assessment Program.
Technical Service Bulletins for the 2006 GMC SIERRA
General Motors, LLC has issued 6 technical service bulletins (TSBs) for the 2006 GMC SIERRA. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
PIP-4430 — FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
GMC: FUEL RAIL PRESSURE SENSOR PERFORMANCE DTC P0191. MAY SET DUE TO ACTUAL FUEL RAIL PRESSURE NOT DROPPING QUICKLY ENOUGH WHEN THE ENGINE IS SHUT OFF. *PE
PIP3605 — POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
DTC U0101, NO ENGINE CRANK AND NO TECH II COMMUNICATION WITH TCM. EQUIPPED WITH ALLISON LCT1000 (RPO-MW7) AUTOMATIC TRANSMISSION. *NJ
4024 — SERVICE BRAKES, AIR
REAR BRAKE PULSATION CHECK DRUM TO AXLE CLEARANCE, WITH RPO JF3 OR JF7. *KB
3475A — POWER TRAIN
BULLETIN-SIT-BULLETIN-NO FORWARD, SLIPS, DTC P0875 P0876. *SC
3766 — VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
FRONT BLOWER INOPERATIVE STAY RUNNING DURING LOW AMBIENT TEMPERATURE. *TT
3681 — POWER TRAIN:AUTOMATIC TRANSMISSION
ALLISON LCT 1000 OVERHEAT DIAGNOSTIC TROUBLE CODE P0218, P0741 AND /OR P0742. *AK
NHTSA Investigations for the 2006 GMC SIERRA
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the GMC SIERRA
- 2001 GMC SIERRA — 333 complaints
- 2002 GMC SIERRA — 291 complaints
- 2003 GMC SIERRA — 248 complaints
- 2004 GMC SIERRA — 224 complaints
- 2005 GMC SIERRA — 152 complaints
- 2006 GMC SIERRA (current)
- 2007 GMC SIERRA — 71 complaints
- 2008 GMC SIERRA — 84 complaints
- 2009 GMC SIERRA — 48 complaints
- 2010 GMC SIERRA — 43 complaints
- 2011 GMC SIERRA — 67 complaints
Other GMC Models
- GMC SIERRA 1500 — 10,327 total complaints
- GMC ACADIA — 7,420 total complaints
- GMC YUKON — 6,108 total complaints
- GMC TERRAIN — 4,098 total complaints
- GMC JIMMY — 3,778 total complaints
- GMC ENVOY — 3,269 total complaints
- GMC YUKON XL — 2,820 total complaints
- GMC SUBURBAN — 2,323 total complaints