1999 FORD F-150 Structure Problems

9 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Structure Issues in the 1999 FORD F-150

9 structure complaints have been filed with NHTSA for the 1999 FORD F-150. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.

Complaints

Crashes

Fires

Injuries

Deaths

All Structure Complaints

#10480913 | October 17, 2012

THE WINDSHIELD LEAKS ON THIS MODEL STYLE AND THE WATER RUNS DOWN TO THE GEM MODULE AND FUSE BOX CAUSING THE GEM MODULE TO SHORT OUT AND THE ELECTRONICS DO WHAT EVER THEY WANT TO. THE TRUCK WILL START ON ITS OWN EVEN IF OFF OR RUNNING AND DRIVING WITH THE STARTER ENGAGING. WINDOWS ROLL DOWN THE ALARM ACTIVATES RADIO COMES ON ALL THE ELECTRONICS COME ON AT THERE OWN EVEN WHEN PARKED WITH THE ENGINE OFF AND THE KEY REMOVED. THIS IS A VERY COMMON PROBLEM FROM MY RESEARCH TO TENS OF THOUSANDS OF THESE TRUCKS. THIS IS VERY DANGEROUS DUE TO THE CAR CAN EVEN ENGAGE THE TRANSMISSION AS WELL AS IT CAN CUT OFF WHILE DRIVING AS IT HAS WITH MYSELF. THIS PART IS VERY EXPENSIVE AND THE LEAK IS VERY COMMON. *TR

#10362523 | October 26, 2010

1-SEVERE CORROSION OF FUEL TANK STRAPS. THE REAR STRAP IS COMPLETELY RUSTED THROUGH, RESULTING IN THE TANK BEING HELD UP BY THE FRONT STRAP. THE SKID PLATE IS KEEPING THE TANK FROM FALLING DOWN. LUCKILY I NOTICED THIS WHILE CHECKING THE AIR PRESSURE IN MY TIRES. I WILL BE GETTING NEW STRAPS THIS WEEK TO DO THE REPAIR MYSELF. I WILL KEEP THE OLD STRAPS. 2- BRAKE PRESSURE SWITCH ON MASTER CYLINDER LEAKS. THIS CAUSES THE CRUISE CONTROL TO BE INOPERATIVE. BRAKE FLUID LEAKS OUT ONTO THE WIRING. THIS VEHICLE HAS HAD THE REPAIR FOR THE RECALL ON THE WIRING HARNESS. I BELIEVE THAT THE LEAKING BRAKE PRESSURE SWITCH ALSO CREATES A FIRE HAZARD AS IT COULD POTENTIALLY CAUSE A SHORT IN THE WIRING. I WILL ALSO OBTAIN AND REPLACE THIS PART. *TR

#10359175 | October 4, 2010

1999 FORD F150 4WHEEL DRIVE THE FRONT GAS TANK STRAP BECAME DETACHED FROM THE MOUNT . THE STRAP DRAGGED THE GROUND . I AM HAPPY IT DID NOT CAUSE ANY OTHER DAMAGE. THE STRAP MOUNT IS TOTALLY RUSTED THROUGH AND I DO NOT KNOW HOW OR IF IT CAN BE REPAIRED. THE TRUCK ONLY HAS 93K MILES ON IT. *TR

#10066389 | April 18, 2004

MY 1999 F150 HAS A CRACK FORMING ON THE BOTTOM REAR CORNER OF THE DRIVERS SIDE WINDOW OF THE DRIVERS DOOR AT 32000 I BROUGHT THIS TO THE ATTENTION OF THE DEALER I BOUGHT THE TRUCK FROM AND THEY WOULD NOT FIX IT BECAUSE IT WAS OUT OF WARRANTY BECAUSE OF YEAR . THE DEALER SAID THEY WERE FIXING THIS PROBLEM ON NEWER VEHICLES THEN MINE BUT FORD COMPLAINT SAID THEY NEVER HEARD OF SUCH A THING AND WOULD NOT FIX IT ALSO. I HAVE SEEN THIS ON OTHER TRUCKS SO I KNOW I AM NOT ALONE. ON A DIFFERENT DATE I HAD A PROBLEM WITH THE GASKET SINKING IT CHANNEL BETWEEN THE WINDOW FRAME AND BODY OF TRUCK THEY WOULD NOT FIX THIS BECAUSE IT WAS NOT A FORD PART IT WAS MADE FOR FORD AND CAME ON THE TRUCK FROM THE FACTORY BUT DOSEN'T CARRY A WARRANTY. *JB

#10051046 | December 24, 2003

MAJOR WATER LEAK AROUND REAR WINDOW. ALMOST EVERYONE YOU TALK TO WITH THIS TRUCK STYLE (OVER SEVERAL MODEL YEARS) HAS THIS PROBLEM. FORD HAS KNOWN FOR YEARS ABOUT IT. WHY ARE THEY NOT REQUIRED TO FIX IT?*AK

#10038941 | September 15, 2003

MY 1999 FORD F150 EXTENDED CAB SHAKES WHEN DRIVING AT SPEEDS BETWEEN 40-45 MPH AND OCCASSIONALLY AT SPEEDS GREATER THEN 80 MPH. FRONT AND REAR ALIGNMENT NOR TIRE BALANCE/ROTATION CORRECTS PROBLEM. ANOTHER OWNER RELATED THIS IS DUE TO A DEFECT IN THE CHASSIS DUE TO DESIGN PROBLEMS WITH EXTENDED CAB. IS THEIR A CORRECTIVE ACTION FOR THIS VIBRATION?

#10021224 | June 7, 2003

FORD F-150 2WD, SUPER CAB, 8 FT BED. WATER IS LEAKING FROM THE HEAD LINER IN THE RIGHT REAR OF VEHICLE DIRECTLY ABOVE FIXED PANEL OF SLIDING REAR WINDOW ASSEMBLY. I SPOKE TO FORD CUSTOMER SERVICE ABOUT THE PROBLEM 2 MONTHS AGO AND THEY MADE IT SOUND LIKE IT WAS THE FIRST TIME THEY HAD HEARD ABOUT IT. I TOOK THE TRUCK IN TO THE DEALER WHERE I PURCHASED IT AND THEY HAVE INDICATED THAT THE ENTIRE REAR WINDOW ASSEMBLY NEEDS TO BE REPLACE, AT MY EXPENSE. SEARCH OF YOUR SERVICE BULLETIN SECTION RESULTED IN IDENTIFICATION OF BULLETIN #01111 POSTED JAN. 22, 2001 LISTED THE FOLLOWING. "SOME VEHICLES MAY EXHIBIT A WATER LEAK AROUND THE REAR (SLIDING) WINDOW. *TT. HOW DO I GET FORD TO DO THE RESPONSIBLE THING AND MAKE THIS REPAIR. *JB

#857539 | February 25, 2000

CONSUMER IS EXPERIENCING EXCESSIVE AMOUNT OF STATIC ELECTRICITY WHEN GOING IN OR COMING OUT OF EXTENDED CAB. CAUSE IS UNKNOWN. *AK *ML

#550791 | February 18, 2000

CONSUMER FEELS VEHICLE SHOULD BE EQUIPT WITH RUNNING BOARD FOR SAFETY. THESE BOARD WOULD PREVENT PEOPLE FROM FALLING WHILE ENTERING OR EXITING THE VEHICLE. NLM

Other 1999 FORD F-150 Problem Areas

← Back to 1999 FORD F-150 overview