2016 FORD EXPLORER Structurebody Problems

PLASTIC ROOF RACK TOP CAPS ARE POORLY AFFIXED AND CAME LOOSE ON HIGHWAY AND BLEW OFF THE VEHICLE. THIS PRESENTS HAZARDOUS ROAD CONDITIONS FOR DRIVERS AND PEDESTRIANS. AFTER THE INCIDENT, I RESEARCHED AND FOUND THAT THIS IS A WELL DOCUMENTED ISSUE WITH THIS GENERATION OF FORD EXPLORER.

THE RECALLED TOE LINK ON THE REAR SUSPENSION BROKE 3 MONTHS AFTER IT WAS REPLACED AND CAUSE A CRASH WHILE DIVING DOWN THE HIGHWAY, SLOWING FOR A SPEED ZONE FOR A TOWN. INVOLVING BODY DAMAGE. AND THE VEHICLE WAS REPAIRED AND 1 WEEK AFTER GETTING IT BACK FROM THE DEALER THE LINK BROKE FOR A SECOND TIME, WHILE ON A CURVE WITH CRUISE CONTROL ON ROAD CONDITIONS WERE DRY BOTH TIMES.WE HAVE OWNED THE VEHICLE FOR 6 WEEKS TOTAL AND HAVE ONLY BEEN ABLE TO DRIVE FOR 2 OF THEM.

PLASTIC MOLDINGS ON THE RIGHT AND LEFT OF THE WINDSHIELD FLY OFF AT HIGHWAY SPEEDS AND THE WEATHERSTRIPPING SPLITS AND BANGS AGAINST THE WINDSHIELD

OBEYING SPEED LIMIT DRIVING DOWN THE HIGHWAY ON N127 TOWARDS JACKSON MICHIGAN, GOING PAST AN ON RAMP AND MY PASSENGERS WINDSHIELDS OUTER PILLAR COVER FLEW OFF OUT OF NO WHERE, NO REASON, VERY UNEXPECTED. ALMOST HIT A CAR THAT WAS COMING ONTO THE HIGHWAY ON A ON RAMP. I HAVE FOUND 5 OTHER REPORTS OF EXACTLY SAME THING. MY VEHICLE ONLY HAS 37K MILES ON IT, HAVE ONLY DROVE IT BARELY 3 MONTHS. THIS SHOULD NOT HAVE HAPPENED OR BE HAPPENING TO VEHICLES. OTHER COMPLAINTS I FOUND VEHICLES WERE AT 40K MILES OR 41K MILES. TIMING OF ALL 6 INCIDENTS IS NOT A COINCIDENCE. ALL 2016 FORD EXPLORERS ALL WITHIN LAST 6 MONTHS.

THE OEM ROOF RACKS WILL NOT STAY MOUNTED ON THE VEHICLE. I TOOK THE VEHICLE TO FORD AND THEY TOLD ME THERE WAS NOTHING THAT COULD BE DONE. FORD RECOMMENDED THAT I TAKE IT TO TRUCKING THUNDER AND SEE IF THEY COULD HELP. I TOOK THE VEHICLE TO TRUCKING THUNDER AND THEY SAID I SHOULD FOLLOW UP WITH CORPORATE AT FORD BECAUSE THIS IS SOMETHING FORD NEEDED TO CORRECT. I PURCHASED NEW RETAINER CLIPS (THIS IS WHAT HOLDS THE RACKS DOWN) AND REPLACED THEM BUT IT DID NOT FIX THE PROBLEM (PART #FB5Z-7851050-A). THE ROOF RACKS WILL NOT STAY MOUNTED ON EITHER SIDE OF THE VEHICLE. LAST WEEK I SUPER GLUED THEM DOWN AND THIS HAS HELP SO FAR. THE RACKS WERE POPPING OFF WHEN I WAS DRIVING DOWN THE ROAD. IT WAS A SERIOUS SAFETY ISSUE. I MAKE IT A POINT TO INSPECT OTHER EXPLORER ROOF RACKS WHEN I...

BOTH PIECES THAT HOLD THE WINDSHIELD TO THE CAR ON THE LEFT AND RIGHT OF THE WINDSHIELD HAVE FLOWN OFF ON MY CAR AND SEVERAL OTHERS I KNOW WHO ALSO OWN A 2016 FORD EXPLORER.

THE KEY PAD ON THE DRIVER DOOR FELL OFF WHILE DRIVING ON A HIGHWAY. THEN AN HOUR LATER, ALSO WHILE DRIVING, THE LIFT GATE LIGHT CAME ON. I WAS UNABLE TO OPEN THE LIFT GATE BY ANY MEANS. FORD CHARGED ME APPROXIMATELY $450 FOR THE DOOR PANEL. IT WAS $900 TO REPAIR BOTH. IT IS UNKNOWN WHAT CAUSED BOTH PROBLEMS.

2016 FORD EXPLORER XLT - WHILE DRIVING 70 MPH ON STRAIGHT HIGHWAY, THE PLASTIC OUTER PILLAR WINDSHIELD TRIM ON THE PASSENGER'S SIDE OF THE WINDOW SHIELD DETACHED WITHOUT WARNING. THE VEHICLE HAS NOT YET BEEN TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS ~38,000.

ON SEPARATE OCCASIONS, MY VEHICLE'S DRIVER SIDE AND PASSENGER SIDE WINDSHIELD PILLAR/MOLDING TRIM FLEW OFF VEHICLE WHILE DRIVING ON THE HIGHWAY. THE PLASTIC WHICH THE PANEL IS DEFECTIVE.

2016 FORD EXPLORER WINDSHIELD PILLAR TRIM FALLING OFF. IVE READ NUMEROUS POST ABOUT OTHERS HAVING THE SAME PROBLEM. FLYING OFF THE VEHICLE WHILE GOING DOWN THE HIGHWAY. DANGER OF HITTING THE CAR BEHIND OR CAUSING THEM TO SWERVE AND WRECK. THE DEALERSHIP WANTS ALMOST $1000 TO FIX THIS, THATS OUTRAGEOUS AND FORD SHOULD BE PAYING FOR THESE REPAIRS.

WHEN DRIVING ON THE HIGHWAY THERE IS A BUZZING NOISE COMING FROM THE COWL GRILLE PANEL ON THE WINDSHIELD. IT BECOMES VERY DISTRACTING AND HARD TO HEAR ANY AUDIO.

ONE MORNING, I BEGAN TO SMELL A SULFUR OR GAS-LIKE SMELL INSIDE THE CAR. I THOUGHT NOTHING OF IT BUT IT PERSISTED FROM 5:00 A.M. -9:00 A.M. MY 7 YEAR OLD SON EVEN SMELLED IT WHEN ENTERING THE CAR. AFTER DROPPING HIM OFF AT SCHOOL I DROVE TO DEALERSHIP TO GET IT INSPECTED. DURING THAT DRIVE, WITH THE WINDOWS CRACKED, I BEGAN TO FEEL A DULL HEADACHE, DIZZINESS AND MUSCLE WEAKNESS. ONCE I DROPPED MY CAR OFF FOR INSPECTION AND WAS OUT OF THE CAR I DIDN'T FEEL ANY BETTER AND MY HEADACHE AND WEAKNESS GOT WORSE. MY WIFE TOOK ME TO THE ER OUT OF PRECAUTION AND AFTER BLOODWORK WAS TAKEN, I WAS CONFIRMED TO HAVE HAD CARBON MONOXIDE POISONING. I AM A NON-SMOKER AND MY COHB LEVELS WERE TWICE THAT OF A NON-SMOKER : 3.8% IT WAS RAINING OUT SO I COULD NOT UNROLLI WINDOWS AS MUCH AS...

WHISTLE OR BUZZ-TYPE NOISE FROM FRONT COWL PANEL GRILLE COVER. FORD DEALERSHIP CONFIRMS THIS "BODY DEFECT ISSUE" BUT WILL NOT COVER IT UNDER ANY WARRANTY. WANT $1,300 TO FIX. THIS IS THE ISSUE: HTTPS://WWW.YOUTUBE.COM/WATCH?V=VWC3-PTT3L0&T=49S

I WAS DRIVING DOWN THE HIGHWAY AT 55MPH. HEARD A LOUD NOISE. THOUGHT I HAD SCRAPED A TREE AS WAS IN AN AREA WITH ALOT TREES. THE NEXT DAY NOTICED THAT THE PILLAR TRIM ON MY PASSENGER DOOR WAS GONE. CHECKED THE REST OF MY CAR AND THE PILLAR TRIM ON THE WINDSHIELD IS LOOSE ALSO. RESEARCHED THIS ON THE WEB AND IT IS A VERY COMMON PROBLEM WITH THIS VEHICLE. I AM CONCERNED ABOUT THIS TRIM FLYING OFF AT HIGH RATES OF SPEED AND STRIKING EITHER MY OWN WINDSHIELD OR ANOTHER VEHICLE BEHIND ME. CONTACTED FORD AND WAS TOLD THANK YOU FOR CONCERN BUT NO SOLUTION TO THIS ISSUE. I AM PRETTY SURE PIECES FLYING OFF A VEHICLE GOING AT A HIGH RATE OF SPEED SHOULD BE OF CONCERN. I NOW KNOW WHAT THAT WHISTLING SOUND WAS THAT I WOULD HEAR WHEN DRIVING. IT WAS THE LOOSE TRIM CATCHING...

PAINT ON THE HOOD IS BUBBLING UP AND CHIPPING OFF, CAUSING CORROSION WHERE THE PAINT HAS CHIPPED OFF.

WHILE DRIVING ON INTERSTATE, THE WINDSHIELD MOLDING BECAME LOOSE AND STARTING VIBRATING. AFTER PULLING OVER AND ATTEMPTING TO SECURE, IT THEN BECAME PARTIALLY DETACHED AND WAS BENT BACKWARDS. IT OBSTRUCTED THE VIEW OF THE REAR VIEW MIRROR AND PASSENGER SIDE WINDOW. IT THEN FLEW OFF INTO ONCOMING TRAFFIC. LUCKILY, IT LANDED ON THE SHOULDER AND DID NOT HIT ANOTHER CAR/CAUSE A WRECK ON THE INTERSTATE. THE DRIVER SIDE IS ALSO PARTIALLY COMING OFF ACCORDING TO REPAIR QUOTE FROM DEALERSHIP.

STRONG EXHAUST AND VERY HIGH LEVELS OF CO ENTERING CABIN AT NORMAL ACCELERATION, VERY BAD AT HARD ACCELERATION I HAVE MULTIPLE PICTURES OF MY CO SENSOR I HAD IN THE VEHICLE FOR SOME TIME NOW WITH LETHAL CO LEVELS. I BELIEVE THE EXHAUST MANIFOLDS HAVE BIG ENOUGH CRACKS TO FLOOD IN CO INTO THE CABIN THROUGH OPENINGS. MINE HAS HAD THE 'DEALER ITSB' TO RESOLVE, NO CHANGE AND IT REGISTERED HIGHER AFTER. REPLACE THIS MANIFOLD AND SEAL THIS TRUCK OR BUY IT BACK FROM ME FORD. IF PUTTING MY FAMILY'S LIFE IN DANGER DAILY DOESN'T SCARE YOU, THE PICTURES AND PROOF I HAVE ARE ENOUGH FOR ANOTHER LAWSUIT AGAINST YOU FOR THIS! I NEED TO BE CONTACTED BY A FORD REP (NOT A DEALERSHIP) TO RESOLVE OR MY LAWYERS WILL FOLLOW UP WITH YOU. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM

PAINT STARTS TO BULDGE AND FLAKES. STRONG SMELL OF CARBON MONOXIDE INSIDE THE CABIN WHILE DRIVING.

WE HAVE NOTICED A FOUL SMELL IN OUR FORD EX SINCE WE PURCHASED IT WITH NO EXPLANATION REGARDING THE CAUSE. I BELIEVE THAT IT IS RELATED TO THE CARBON MONOXIDE ISSUE WITH THIS VEHICLE. WHEN I CONTACTED FORD REGARDING THIS PROBLEM THEY REFUSED TO PROVIDE ANY ASSISTANCE OR ANY RESOLUTION REGARDING FIXING THE PROBLEM.

DRIVER SIDE EXTERIOR PLASTIC WINDOW PILLAR FLEW OFF WHILE DRIVING ON THE HIGHWAY. WENT TO FORD DEALERSHIP AND THEY WILL NOT COVER SINCE IT IS NOT UNDER WARRANTY. TOTAL BS!!!

SINCE I HAVE PURCHASED THE VEHICLE IN FEBRUARY 16 IT HAS BEEN BACK FOR SERVICE NURMOUS TIMES, STARTING 2 DAYS AFTER DELIVERY! MAJOR COMPLAINT HAS BEEN COOLENT LOSS AND BURNING COOLANT SMELL FOLLOWING WITH A OIL LEAK AT THE SAME TIME. THIS IS A NEW VEHICLE 10 MILES ON IT SHOULDN'T HAVE THESE ISSUES SO I DEMANDED A DIFFERENT VEHICLE, WAS REFUSED DUE TO DEMOGRAPHICS! WELL THE DEALER BRUSHES EVERYTHING OFF AS ALL DO SAY IT'S NORMAL IT HAPPENS, AS TIME PASSES IT GOES BACK TO THE DEALER FOR SAME ISSUE THEY REPLACED A OIL SEAL AGAIN AND COOLANT LOSS AND SMELL IS NORMAL TO THEM, THEY CAN'T FIND ANY ISSUES, I TELL THEM IT'S AFTER LONG DRIVES WELL EACH TIME THEY HAVE IT OVER A WEEK. TO BOOT THEY IGNORE MY COMPLAINT ABOUT THE ROTTEN EGG SMELL I GET ON ACCELERATION! THEY TELL ME IT'S PROBABLY THE GAS I'M...

ON THE WINDSHIELD PILLAR, THEY HAVE PLASTIC COVERS HELD ON BY A FEW PLASTIC CLIPS. WHILE DRIVING THE COVER FLEW OFF WITHOUT ME NOTICING. I WAS DRIVING ON A MAJOR HIGHWAY AT 65 MPH. THIS ISSUE HAS BEEN REPORTED ONLINE, AND I CONTACTED FORD DIRECTLY AND THEY REFUSED TO ACKNOWLEDGE OR REMEDY THE SITUATION. THIS COULD HAVE CAUSED A MAJOR ACCIDENT IF A VEHICLE WAS HIT OR TRIED TO AVOID BEING HIT BY THIS PIECE OF PLASTIC. FORD ALSO TOLD ME THAT IF I DID NOT HAVE THE BROKEN PIECE THEY COULD NOT HELP WITH REPAIRS FINANCIALLY. SO THEY EXPECT PEOPLE TO TRY TO LOCATE A SMALL PIECE OF PLASTIC ON A MAJOR HIGHWAY AND RETRIEVE IT WHILE AVOIDING ONCOMING TRAFFIC. A RECALL MIGHT NEED TO BE FORCED IN ORDER FOR FORD TO ACKNOWLEDGE THIS DEFECT IN THEIR VEHICLE BEFORE IT CAUSES A SERIOUS ACCIDENT OR FATALITY.

SINCE PURCHASING THIS VEHICLE IN DECEMBER 2016 I HAVE HAD SEATBELT RETRACTABLE MECHANISM IN THE THIRD ROW REPLACED; I HAVE HAD THE NAVIGATION SYSTEM REPLACED; I HAD TO HAVE THE KEYPAD ON THE DOOR PANEL REPLACED; I HAVE HAD TO HAVE THE POWER STEERING EPAS REPLACED (MOST RECENT). MOST HAPPENED WHILE THE VEHICLE WAS STATIONARY THANK GOODNESS. THE NAVIGATION SYSTEM DID GO OUT WHILE DRIVING.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING, THE CONTACT NOTICED AN ABNORMAL ODOR INSIDE THE VEHICLE RESEMBLING CARBON MONOXIDE WHILE THE RECIRCULATION AIR CONDITIONER WAS ACTIVATED. THE PASSENGER (THE CONTACT'S WIFE) NOTICED THE ODOR. THE CONTACT SAW THE FAILURE ON THE NEWS AND CALLED THE DEALER (L&S TOYOTA, 248 AUTO PLAZA DR, BECKLEY, WV, 25801; 304-252-8548; EXT 231) WHERE THE DEALER ADVISED THE CONTACT THAT THEY WERE TRYING TO SCHEDULE AN APPOINTMENT. THE CONTACT FAXED OVER SIX PAGES OF INFORMATION FOR THE DEALER TO TRY AND REMEDY THE CARBON MONOXIDE FAILURE. THE VEHICLE YEAR AND MODEL WAS INCLUDED IN INVESTIGATION NHTSA NUMBER: EA17002 (STRUCTURE, ENGINE). THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000.

THE TRIM BETWEEN THE DRIVER SIDE DOOR AND THE WINDSHIELD FLEW OFF OF THE THE CAR. I ESTIMATE THAT MY SPEED WAS 65 MPH. THERE ARE 51,000 MILES ON THE CAR. NOT ONLY DOES THIS COST ABOUT $300 EVERY TIME IT HAPPENS, IT IS AN EXTREME SAFETY HAZARD TO OTHER DRIVERS OR PEDESTRIANS NEAR THE ROAD. IT VIRTUALLY BECOMES SPEAR WHEN IT BECOMES DETACHED. I PASS OTHER EXPLORERS OFTEN THAT ARE MISSING THE SAME PIECE OF TRIM AND HAVE SEEN NUMEROUS COMPLAINTS ONLINE.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING AT ANY SPEED, THE CONTACT SMELLED EXHAUST FUMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE SHARPE MOTOR DEALER WHERE IT WAS DIAGNOSED THAT THE BUMPER NEEDED TO BE REPLACED. THE FUME ODOR REMAINED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE SOURCE OF THE FUMES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT REMEDIED. THE FAILURE MILEAGE WAS 16,000.

WHILE DRIVING ON A HIGHWAY AT APPROXIMATELY 55 MPH I HEARD A NOISE AND CAUGHT A GLIMPSE OF A OBJECT FLYING BY THE PASSENGER SIDE WINDOW OF MY VEHICLE. UPON STOPPING TO INVESTIGATE THE SUDDEN OCCURRENCE I DISCOVERED THAT THE PIECE OF PLASTIC TRIM ON THE FRONT WINDSHIELD PASSENGER SIDE HAD BROKEN OFF. I RETRIEVED IT FROM THE SHOULDER OF THE ROAD AND UPON EXAMINATION IT APPEARS THAT THE MOLDED CLIP HOLDERS BROKE AWAY FROM THEIR ANCHORS. FORTUNATELY THERE WAS NO VEHICLE BEHIND ME OR TO MY RIGHT. HAD THERE BEEN A VEHICLE IN CLOSE PROXIMITY THIS COULD HAVE CAUSED A SERIOUS ACCIDENT. I KNOW THAT THIS INCIDENT STARTLED ME. HAVING RESEARCHED THIS TYPE OF INCIDENT I LEARNED THAT OTHER PEOPLE HAVE EXPERIENCED THE SAME PROBLEM WITH THE 2016 FORD EXPLORER. FORD MOTOR COMPANY SHOULD INVESTIGATE THIS ISSUE BEFORE A TRAGEDY OCCURS.

LEAK IN ROOF DUE TO BODY WELD ISSUES. LEAK CAUSED RAIN TO ENTER. 3RD ROW SEATBELT WAS WET, AS WELL AS ELECTRICAL OUTLET IN TRUNK.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE TRAVELING 25 MPH, THE TAILGATE INADVERTENTLY OPENED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE ISSUE COULD NOT BE DUPLICATED. THE CONTACT STATED THAT THE FAILURE HAD NOT RECURRED WHILE DRIVING, BUT WHILE THE VEHICLE WAS PARKED. THE CONTACT CLOSED THE TAILGATE, BUT IT WOULD RE-OPEN. WHILE THE TAILGATE WAS OPEN, IT CLOSED UNEXPECTEDLY AND INJURED THE CONTACT'S HEAD. MEDICAL ATTENTION WAS NOT REQUIRED. THE CONTACT STATED THAT HE WAS AWARE OF THE SENSOR FOR THE TAILGATE. ALSO, WHEN THE VEHICLE WAS STARTED, THE DRIVER'S SEAT MOVED FORWARD AND INJURED THE CONTACT'S RIGHT KNEE. MEDICAL ATTENTION WAS REQUIRED. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE, BUT THE VEHICLE MODULE WAS REPROGRAMMED. THE CONTACT ALSO STATED THAT THE VEHICLE HAD SEVERAL ELECTRICAL ISSUES BECAUSE THE INSTRUMENT PANEL DISPLAY WOULD NOT OPERATE OR OPERATED INCORRECTLY. THE...

I ALREADY SUBMITTED ONE COMPLAINT TODAY ABOUT THE CABIN FILLING WITH EXHAUST FUMES WHILE ACCELERATING BUT THEN I WAS READING OTHER ISSUES PEOPLE WERE HAVING AND WANTED TO ENSURE YOU WERE AWARE OF MINE AS WELL. I HAD TO HAVE THE COOLING FANS REPLACED BECAUSE THEY WOULD COME TO A SCREECHING HALT WHEN YOU WOULD SHUT THE MOTOR OFF. I HAD TO HAVE THE INSIDE OF THE POWER LIFT GATE REPAINTED WHERE THE MOTOR AND SHOCK ARE LOCATED BECAUSE THE PAINT WAS CRACKING. THE CENTER CAPS ON THE WHEELS ARE FALLING IN SO THOSE ARE GOING TO BE REPLACED. IT IS NOW RUSTING ON THE BACK OF MY CAR BY THE REAR TAIL LIGHT. THE HOOD VIBRATES REALLY BAD WHEN GOING OVER 65 MPH. I HAVEN'T TAKEN IT IN FOR THAT YET BECAUSE I CAN'T GET IT TO DO IT ALL OF THE TIME. IT HAS TO BE WINDY FOR...

WE TOOK OUR 2016 EXPLORER LIMITED BACK TO THE SHOP FOR THE SECOND TIME AFTER SMELLING EXHAUST IN THE CABIN AGAIN WHILE IN OPERATION. DURING THE FIRST VISIT THE DEALER BEGAN DISCUSSING THE FORD REPAIR BULLETIN THAT CAME OUT 30 DAYS OR SO AGO THAT WAS TO FIX THE EXHAUST LEAK. HOWEVER, AFTER A COUPLE OF HOURS LATER WE RECEIVED A CALL THAT THE BULLETIN HE REFERENCED WAS SPECIFICALLY FOR 2011 THRU 2015". WE WERE TOLD THAT PER THE BULLETIN THE EXHAUST SYSTEM FROM THE ENGINE MANIFOLD TO THE TAIL PIPE GETS REPLACED, A FRESH AIR VENT NEAR THE REAR OF THE VEHICLE GETS "RE-ROUTED" AND THE BUMPER COMES OFF TO GAIN ACCESS TO SOME METAL SEAMS NEEDED TO BE FILLED. OUR SERVICE REPRESENTATIVE STATED HIS HANDS WERE TIED AND COULD NOT DO ANYTHING MORE THAN TAKE IT IN A CHECK IT OUT. THEY CALLED A FOUND THE EXHAUST OUTLETS...

WHEN DRIVING AT HIGHWAY SPEEDS THE A-PILLAR WINDSHIELD MOULDING/APPLIQUE FLIES OFF. NOT ONLY IS IT UNACCEPTABLE FOR BODY/TRIM PANELS TO FLY OFF A VEHICLE DURING NORMAL DRIVING, BUT THIS POSES A SAFETY RISK, AS IT CREATES FLYING DEBRIS FOR VEHICLES TRAVELING BEHIND THE AFFECTED VEHICLE. *TR

I HAVE TO MAJOR COMPLAINTS WITH THE FORD EXPLORER 2016. THE TRUCK WAS PURCHASED BRAND NEW. THE FIRST OCCURRED WHEN I WAS ON MY WAY TO WORK ABOUT 7:30AM. I WAS DRIVING ABOUT 60 MILES PER ON HOUR ON A CITY STREET AND ALL OF A SUDDEN A WRENCH SYMBOL SHOWS AND THE CAR WILL NOT ACCELERATE ANYMORE. I HAD NEVER SEEN THIS SYMBOL BEFORE SO I WASN'T SURE WHAT WAS GOING ON AND COULD NOT FIND IT IN THE MANUAL. BEFORE THIS I ONLY COULD GO ABOUT 5 MILES PER HOUR MAX SPEED. WHEN I GOOGLED THE WRENCH MANY OTHERS HAD THE SAME ISSUE. I AM SURE FORD IS AWARE OF THIS AND SHOULD HAD SAID SOMETHING ABOUT THIS BEFORE WE PURCHASED IT. I HAD TO END UP LEAVING THE EXPLORER UP AT FORD FOR 2 AND A HALF WEEKS. WHEN I GOOGLED THE ISSUE IT SAID THESE EXPLORERS...

HI I NEED HELP WE ARE HAVING ISSUE WITH OUR 2016 FORD EXPLORER SPORT WE ONLY HAVE IT FOR 3 MONTHS 2K MILEAGE, WE NOTICED THE HOOD VIBRATE AT 65MPH OR OVER ON FREEWAY, I BROUGHT IT TO MY NEAREST FORD DEALER, "FORD SERRAMONTE" ON 05/16/16 THE SERVICE MANAGER NAME HENRY SAID THEY ARE AWARE OF IT BUT COULDN'T DO ANYTHING & THEY ARE WAITING FOR FORD TO FIND THE SOLUTION TO FIX IT, BUT THEY DIDN'T EVEN CHECK THE HOOD. I CONTACTED FORD CUSTOMER CARE TEAM ON 05/18/16 & THEY OPEN A CASE, CASE NUMBER: CAS-9514452-P1Y5C2 TARA MELVIN COSTUMER CARE MANGER HANDLING THE CASE. WE ARE PROSTRATED BECAUSE IT'S BRAND NEW CAR & ALREADY HAS A LOT OF PROBLEMS, IT WAS DISTRACTIVE DRIVING THE VEHICLE SO I'M SCARED SPECIALLY I'M ALWAYS WITH MY 1YR & 4YRS OLD SON, THEY JUST TOLD ME TO WAIT & IT'S BEEN MORE THAN...

WINDOW TRIM CAME FLYING OFF WHILE DRIVING ON THE HIGHWAY. AT 300 MILES ON THE VEHICLE THIS WAS VERY SCARY. NOT KNOWING WHAT WAS TAKING PLACE TRYING TO GET TO THE SHOULDER CARS BEHIND HAD TO DEAL WITH THE FLYING PIECE OF TRIM THAT FLEW OFF OF OUR CAR HIGHWAY NO TURNPICK IN RUSH HOUR TRAFFIC.

THE AUTOMATIC LIFTGATE FUNCTIONED ON ITS OWN WITHOUT ANY OPERATOR INPUT. THIS HAS HAPPENED 3 TIMES WITHIN APPROXIMATELY ONE MONTH OF OWNERSHIP. ALSO ONE INSTANCE OF LIFTGATE CLOSING ON HEAD. FORD CLAIMS THEY ARE AWARE OF SIMILAR COMPLAINTS AND IS WORKING ON A FIX.??? IF THE OPERATOR WERE NOT AWARE THIS OCCURRED AND A CHILD OR PET WERE IN THE 3RD ROW, THIS COULD HAVE SERIOUS CONSEQUENCES. PLEASE SEE ATTACHED REPAIR ORDER WITH FORD'S RESPONSE. ALL INSTANCES SO FAR WERE VEHICLE IN PARK WITH OPERATOR NEAR THE REAR END OR BEHIND OF THE VEHICLE.