2019 FORD ESCAPE Engine Problems

The ERG or Purge Valve failed, causing a hole to be burned into my intake manifold, which caused my car not to be able to read my fuel properly which caused air and heat to build which caused my catalytic converter to melt. The danger is my car could’ve caught on fire, a check engine light came on and we went to AutoZone and they said the code read O2 censor, but nothing ever indicated ERG or Purge Valve. Ford of Dalton said he’s never seen one do this kind of damage.

The contact owns a 2019 Ford Escape. The contact stated that the check engine warning light was illuminated. After refueling the vehicle, the contact had to depress the accelerator pedal to the floorboard then turn the key in the ignition until the vehicle started. The contact took the vehicle to a certified mechanic who diagnosed the vehicle and determined that the EVAP failed, making it difficult to start the vehicle. The certified mechanic cleared the warning light. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 80,000.

For the past few months I have been noticing a hot coolant smell from outside the vehicle. After investigating, I noticed the coolant level was low and there was residue on the valve cover. Afterwards, I refilled the coolant reservoir and continued driving for another week to make sure the coolant was leaking. Afterwards, I inspected the vehicle further to check for any external leaks and could not find any, but my reservoir was much lower when I check again. I then made an appointment with the dealership to see if they could find anything. They kept my vehicle for a day to run a pressure test, but oddly enough it passed the pressure test and they could not find any leaks. I only have 3000 miles left before the warranty expires and the service manager told me it would be fine to drive on our trip that we were...

Car has been acting up and making noises. (Engine rattles). Was driving and made a turn as I was speeding up, my car revved and then started sputtering like it was going to die. Was a 1/2 mile from home. Made it home and restarted car, it sounds like it is missing something and engine is still rattling super loud. Have 68000 miles on car, engine was replaced due to previous recall of coolant leaking into engine at 27000.

Ford has issued a Technical Service Bulletin for the known issue with the coolant intrusion into engine. My 2019 Ford Escape with 31,060 miles is now dead with a short engine on backorder. No lights came on until the car was inoperable.

The contact owns a 2019 Ford Escape. The contact stated while driving at various speeds, the accelerator pedal was depressed but the vehicle hesitated to respond and started shuddering. There was no warning light illuminated. The contact stated that at times she would veer to the side of the road for a moment before resuming normal driving. The vehicle was taken to the dealer where four spark plugs were replaced; however, the failure reoccurred. The vehicle was towed to the dealer where it was diagnosed that coolant was leaking into the engine and the engine block was cracked. The dealer diagnosed that the engine needed to be replaced. The dealer informed the contact that she needed to pay out-of-pocket for the repair because the failure could not be repaired under warranty. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they would...

The contact owns a 2019 Ford Escape. The contact stated that while his wife was driving at an undisclosed speed, there was an abnormal clapping sound detected. There were no warning lights illuminated. The vehicle was taken to an unknown local dealer in Kansas where the contact was informed that the failure was due to a friction plate issue however, the vehicle was not repaired. The vehicle was taken to another local dealer where it was diagnosed that there was coolant intrusion into the cylinder head and that an engine replacement was needed. The vehicle was repaired but the failure persisted. The contact stated that while driving there was an abnormal clapping noise detected with no warning lights illuminated. The vehicle was taken to another local dealer, Legacy Ford (27225 Southwest Fwy, Rosenberg, TX 77471, (281)342-5611) where a diagnostic test and repair was unknown. The manufacturer was notified but no...

Whitish and/or whitish-blue smoke comes out of tailpipes when starting vehicle . Believe there is faulty head gasket or engine block that causes oil to be mixed with antifreeze resulting in permanent damage to engine over time which could lead to possible fires, breakdowns, and or fumes. Tried to get it looked at to confirm that the 1.5l engines from the 2019 Ford Escapes are an issue like past models but dealership tried to side step me and not properly look over vehicle in my opinion.

I was driving my car and then all of a sudden it's starts to jerk and make this clanking sound and stops in the middle of traffic...a indicator check engine light pops in and the service transmission soon..thank God there was no accident due to quick thinking. I try to restart the car and take to the dealer where I bought it and was told they could do nothing and they were backed for 3 months and they just cleared out the message. I start driving it again because I don't have a car and I have to get back and forth to work. Maybe 2 days later it's does the same thing and the car shut down and wouldn't change any gears. I had to get towed which cost money out of my pocket. The car would not move. I only had this car 2 months and I feel...

Loosing antifreeze found no external leaks

On March 29, 2022 my 2019 Ford Escape suddenly started shaking with no lights coming on to tell me there was an issue. When taken to the shop and after one week was towed to ford due to not being about to fix this problem. Once it arrived at ford the issue was found to be a leaking coolant which ruined the engine. This is a known ford problem. They will not fix the vehicle and for over a month we have been fighting with ford they have made no progress. This is known to cause engine failure, or verb eating engines, and even engine fires.

At 61,000 miles (1,000 miles outside Ford Factory warranty) my vehicle 2019 Ford Escape has a blown head gasket. The Check engine illuminated with a code of an engine misfire. Upon taking it to a ford dealership it was confirmed to have a blown head gasket.

The contact owns a 2019 Ford Escape. The contact stated while her husband was driving at an unknown speed, the check engine warning light illuminated. The contact took the vehicle to an independent mechanic, where it was diagnosed with needing the spark plugs and ignition coil to be replaced. The vehicle was not repaired. The contact took the vehicle to the local dealer, where it was diagnosed with needing the engine to be replaced. The vehicle was not repaired. The contact stated that the check engine warning light turned off but then illuminated again. The contact took the vehicle to another independent mechanic, where it was diagnosed with needing the spark plugs and ignition coil to be replaced. The vehicle was repaired. The contact took the vehicle to another local dealer; Garber Ford (3380 US-17, Green Cove Springs, FL 32043: (904) 264-2442) where it was diagnosed with needing the engine...

The contact owns a 2019 Ford Escape. The contact stated that while driving, the vehicle failed to accelerate over 60 MPH. The check engine warning light was illuminated. The vehicle was examined by an independent mechanic who replaced the spark plugs and indicated that coolant was present inside the combustion chamber of the engine. The vehicle was not repaired and continued to exhibit failure. The local dealer and manufacturer were notified of the failure. An appointment was scheduled to have the vehicle serviced by the dealer. The failure mileage was 75,000.

My vehicle is 2 yrs old and began having purge valve issues. Upon trying to fix the problem, I found that the part is on back order with no parts available anywhere in my region. Also while trying to locate the purge valve, part number: Gv6z9d289e, I found that several other people were also trying to locate the part indicating this is an issue in several vehicles. The vehicle vapor locks upon fueling possibly resulting in future engine damage.

The contact owns a 2019 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated and remained illuminated. The contact drove to the gas station and while refueling, there was an abnormal fuel odor coming from the vehicle. After restarting and driving the vehicle back to the residence, the fuel odor inside the cabin of the vehicle was extremely strong, causing the contact to have a headache. The contact took the vehicle to a local dealer who inspected and diagnosed the failure as the emission evap valve was not properly separating the fuel inside the fuel tank. The vehicle was not repaired because the local dealer did not have the parts needed to perform the repair. The manufacturer was made aware of the failure. The failure mileage was approximately 46,000.

Bought new March 2019; May 2020, with 32,000 miles, had a coolant leak and had to replace engine; about 6 weeks later needed anew flywheel and about 2 months after that needed some of the oxygen sensors replaced.

Our check engine light came on in our 2019 Ford Escape, which has 80,000 miles. It overheated with no warning. We took it to the dealership who informed us the coolant leaked and caused a crack in the engine between the 2nd and 3rd cylinders and said the engine needs to be completely replaced.

At 44,000 miles Engine began to idle badly on startup and misfire. Engine light came on during drive home after work. Stopped vehicle and had it towed to the nearest Ford Dealer. Dealer Service Technician checked codes and reported P0304 cylinder 4 miss fire. Dealer Technician replaced and replaced all four sparks plugs and used 446676 cleaner to clean throttle body, intake, fuel injectors and valve. Few days later engine light returned, took vehicle back to Ford Dealer. Ford Technician checked and road tested vehicle and stated 446676 cleaner may not have finished cleaning systems and that was the cause of the engine light. A few days later engine began to idle badly on startup and misfire again. Then saw white smoke came from the exhaust on startup. Two weeks earlier just had vehicle service maintenance completed by the Ford Dealer. Invoice #233228 and #782806.

The contact owns a 2019 Ford Escape. The contact stated that in November of 2020 the engine was replaced under an unknown recall. The contact stated while driving at approximately 60 mph, the vehicle stalled without warning. The contact stated that after attempting and restarting the vehicle several times, the vehicle was taken to the dealer and the contact was informed that the VIN was under a recall. The vehicle was repaired. The contact stated that approximately 8 months later the failure recurred while driving approximately 35 mph. The vehicle was restarted and driven to the dealer. The mechanic was unable to determine the cause of the failure. The failure recurred while driving 55 mph. The vehicle was returned a third time to the dealer however, a repair was not performed. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 14,000. Consumer...

Engine began to idle badly on startup and misfire. White smoke came from exhaust on startup. Coolant levels started to decrease. Engine is burning coolant that has leaked into the cylinders due to a defect in the casting of the engine block. Dealership is now saying car needs an entire new engine block. Obviously the previous recall that was addressed did not solve the issue.

PURCHASED VEHICLE IN OCTOBER OF 2019, IN FEBRUARY 2020 HAD ENGINE LIGHT COME ON AND THE CODE P0496 WHICH IS A PURGE VALVE ERROR AND TOOK TO SERVICE AND THEY STATED THAT FORD HAD TO HAVE THIS HAPPEN TWICE, SO ON MARCH 17, 2020, IT HAPPENED AGAIN AND WAS TAKEN TO SERVICE AGAIN AND IT WAS REPLACED. ALMOST 1 YEAR LATER, ON FEBRUARY 27,2021 THE CHECK ENGINE LIGHT CAME ON AND WAS TAKEN BACK TO SERVICE ON MARCH 2 AND WAS REPLACED AGAIN. NO RECALLS ON THIS VEHICLE , BUT THERE SHOULD BE. THIS SHOULD HAVE HAPPENED ON A NEW VEHICLE NOR SHOULD IT CONTINUE TO HAPPEN! IT IS NOW ON ITS 3 RD PURGE VALVE!!!

BOUGHT USED ESCAPE IN APRIL. DIDN'T DRIVE MUCH SINCE I LIVE IN TOWN. TOOK A HOUR DRIVE FROM HOME.ENGINE STARTED MISFIRING AND CAR WAS JERKING. TOOK TO DEALERSHIP. THEY HAD FOR TWO WEEKS. SAID WAS SOLENOID IN TRANSMISSION AND REPLACED IT. PICKED UP, TOOK HOME. DROVE 3 DAYS LATER, STARTED DOING SAME THING. DROVE NEXT DAY AND CAR QUITE RUNNING 1 BLOCK FROM HOUSE. TRIED TO START BUT STARTED MISSING AND QUIT. HAD CAR TOWED TO DEALERSHIP. THEY HAD FOR 2 WEEKS. SAID CAM SHAFT AND CRANK SHAFT SENSOR WERE BAD AND REPLACED THEM. THEY TEST DROVE OVER 400 MILES WITH NO PROBLEMS. PICKED UP AND DROVE LESS THEN 5 MILE AND STARTED MISFIRING AGAIN. TOOK BACK TO DEALERSHIP. THEY SAID IT WAS ALTERNATOR.THEY REPLACED AND IT TOOK THREE WEEKS TO GET BACK. A COUPLE OF DAY LATER I DROVE 2 MILES TO GAS STATION, FILLED UP AND GOT ON...

I PURCHASED MY 2019 FORD ESCAPE BRAND NEW IN EARLY SPRING OF 2019. SHORTLY AFTER PURCHASING MY ESCAPE I DID NOTICE SOME SLIPPAGE OF THE TRANSMISSION. I PLANNED ON GOING BACK TO THE DEALER SO THEY COULD CHECK IT OUT, BUT UNFORTUNATELY I BECAME ILL, AND THEREFORE IT SLIPPED MY MIND. I WAS IN AND OUT OF THE HOSPITAL FOR THE NEXT SEVERAL MONTHS, BUT AS SOON AS I FELT WELL ENOUGH I COULD NOT WAIT TO DRIVE MY NEW CAR AGAIN. MY FIRST TRIP WAS ACTUALLY TO MY ONCOLOGIST OFFICE, BUT I WAS EXCITED JUST TO BE DRIVING. ON MY WAY THERE, HOWEVER, MY CAR JERKED ME TO THE LEFT CAUSING ME TO RUN OFF THE ROAD. I WAS RIGHT IN FRONT OF MY DOCTOR'S OFFICE, SO I PARKED AND WENT ABOUT MY BUSINESS. WHEN I MY APPOINTMENT WAS OVER, AND I CAME BACK OUT I NOTICED I HAD...

2019 FORD ESCAPE TITANIUM STEERING WHEEL SHAKES/VIBRATES HEAVY & MAKES A LOUD NOISE FROM CAR (ALMOST SOUNDS LIKE A BAD LOUD MUFFLER SOUND) AT SPEEDS OF 35 MPH & 45MPH WHEN THE GAS PEDDLE IS LEVELED AT SPEED AND ALSO DOES THE SAME WHEN GOING UP AN INCLINE AT THE SAME SPEEDS. ALSO TRANSMISSION SLIPS BETWEEN 1 & 2 GEARS INTERMITTENTLY. VERY BUMPY RIDE IN THE BACK WHEN GOING 70 MPH ON THE HIGHWAY. THESE ISSUES HAPPEN WHEN ON LOCAL ROADS & HIGHWAY RAMPS. DEALER REPAIR HAS CHECKED SEVERAL TIMES. FIRST FEW TIMES THEY COULD NOT REPLICATE THE ISSUE. DECEMBER 29, 2020 FINALLY GOT THE ISSUE TO REPLICATE AND PUT A TICKET DIRECTLY INTO FORD. I CHECKED BACK ON 1/7/2021 SINCE I BARE THE HEARD FROM THE DEALER SERVICE REP. AT THAT TIME SHE STILL DIDN'T HAVE AN ANSWER TO A RESOLUTION TO FIX THE FAULT. I CALLED TODAY 1/13/2021...

BOUGHT THIS CAR AS CERTIFIED PRE OWNED FROM A FORD DEALER WITH 28K MILES. APPROX. 4 WEEKS AFTER PURCHASE THE ENGINE STARTS RUNNING ROUGH AND CHECK ENGINE LIGHT CAME ON WITH AN ERROR CODE P0303 MISFIRE. TOOK IT TO DEALER AND THEY DIAGNOSED COOLANT IN CYLINDER 3 WITH THE FIX BEING A NEW SHORT BLOCK ENGINE REPLACEMENT. IT WAS STILL UNDER WARRANTY BUT VERY FRUSTRATING THIS HAPPENED TO A CAR WITH LOW MILES. AFTER DOING RESEARCH THIS IS A VERY COMMON PROBLEM WITH THE FORD 1.5 LITER ENGINE.

WAS STARTING VEHICLE, IT SHUDDERED AND STOPPED WHEN PUT IN REVERSE, RESTARTED VEHICLE AND THEN PUT IN DRIVE, TRIED TO PRESS GAS PEDAL AND CAR WOULD NOT GO ABOVE 25 MPH BEFORE CHECK ENGINE LIGHT CAME ON, TOWED TO DELAERSHIP WAS INFORMED IT HAD COOLANT LEAKING AND NEEDED ENGINE REPLACED 28,200 MILES

AT 7000 MILES THE CAR STARTED MISSFIRENING AND WOULDN'T RUN THE DEALER SAID IT WAS A SPARK PLUG NOW WE ARE AT 29000 MILES LESS THEN A YEAR LATER AND IT'S MISSFIRENING AGAIN THIS TIME IT HAPPENED WHILE ENTERING A BUSY STREET AND ALMOST CAUSED US TO GET REAR-ENDED DUE TO THE CAR NOT ACCELERATING AS EXPECTED. ALSO THE PASS FRONT SEAT BELT DOES NOT KEEP PROPER TENSION IF YOU LEAN FORWARD THEM SIT BACK THE SEAT BELT WILL HAVE SLACK IN IT UNTIL YOU MESS WITH IT TO GET IT TO GO BACK IN.

STARTING APPROXIMATELY OF APRIL OF THIS YEAR, NOTICED THAT THE CAR WAS SURGING AND "MISSING" ON START. THOUGHT IT MAY HAVE BEEN A SPARK PLUG OR SUCH GOING BAD AND IT WASN'T HAPPENING WITH EVERY START. THEN MIDDLE OF MAY, IT WAS DAILY ON EVERY START AND WAS SURGING HARDER AND SPUTTERING. THE TACHOMETER WOULD EVEN RISE AND FALL IN QUICK SUCCESSION. ON MAY 20TH, THE ENGINE LIGHT CAME ON AND TOOK IT TO MY DEALERSHIP. BEFORE EVEN LOOKING AT MY VEHICLE, AFTER DESCRIBING TO THEM WHAT WAS HAPPENING, THEY ALREADY KNEW WHAT WAS WRONG AND WHAT THE REMEDY WOULD BE. THEY STILL PUT MY CAR ON THE COMPUTER AND LOOKED IT OVER, BUT CAME OUT WITH THE CONCLUSION THAT THE ENGINE WOULD NEED REBUILT. FAST FORWARD 2 MONTHS LATER, FINALLY GOT ALL THE PARTS IN TO REBUILD THE ENGINE, HOWEVER MY DEALERSHIP IS SMALL AND DO NOT HAVE A...

DRIVING ON THE HIGHWAY, ALL OF A SUDDEN WARNING COMES ON STATING, "CAR IS OVERHEATING STOP ENGINE NOW." CAR STARTED TO SHAKE AND STEERING WHEEL STARTED TO SHAKE. PULLED TO THE SIDE OF THE HIGHWAY. CHECK ENGINE LIGHT IS RED. POLICE OFFICER PULLED ASIDE TO ASSIST. OPENS HOOD OF THE CAR. OFFICER VISIBLY SEES COOLANT IS BELOW THE MINIMUM LINE. THE OFFICER GOES TO HIS CAR TO RETRIEVE COOLANT. WHEN THE OFFICER UNSCREWED THE COVER OF THE COOLANT FLUID HOLDER, THE FLUID RAISED BY ITSELF TO MAXIMUM LINE. OFFICER DID NOT ADD MORE COOLANT. STARTED THE CAR AND ENGINE LIGHT GOES FROM RED TO YELLOW. I WAS ABLE TO COAST THE CAR HOME BUT VERY SLOWLY. *TR

MY 2019 FORD ESCAPE HAS LESS THAN 20,000 MILES AND IS ALREADY HAVING COOLANT LEAK ISSUES INTO THE ENGINE. CYLINDER 3 ISSUE AND THE DEALERSHIP IS TELLING ME THAT THE ENGINE WILL LIKELY NEED TO BE REPLACED. AS I READ MORE ABOUT THIS I AM SEEING THOUSANDS OF VEHICLES AFFECTED, BACK ORDER ON ENGINES, AND A LIKELY LONG WAIT PERIOD FOR THIS TO BE RESOLVED. AFTER SPEND ALMOST $30,000 ON MY VEHICLE THIS IS ABSOLUTELY UNACCEPTABLE BUSINESS PRACTICE! I AM ALSO READING THAT A LAW FIRM IN TENNESSEE IS COLLECTING CLIENTS FOR A LAWSUIT. *TR

DRIVING 70+MPH ON FREEWAY AND THE ACC WENT OUT WITH AN ALERT. CONTINUED DRIVING AND THE LANEKEEP ASSIST HAD AN ERROR AND CEASED WORKING, FOLLOWED BY AN ERROR FOR COLLISION AVOIDANCE. SHORTLY AFTER THE SPEEDOMETER AND ODOMETER WENT TO 0 AND SEVERAL OTHER ERRORS FOR ABS, ESC, AND OTHERS WENT OFF. THIS FELT LIKE THE SCENE FROM APOLLO 13 WHERE EVERYTHING WAS GOING WRONG AT ONCE. I NOTICED THE POWER STEERING WAS NOT WORKING AND IT WAS MUCH MORE DIFFICULT TO TURN THE WHEEL AS I PULLED INTO THE FORD DEALER. THERE WAS STEAM/SMOKE COMING FROM MY FRONT GRILL.

TL* THE CONTACT OWNS A 2019 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE VEHICLE SUDDENLY SURGED FORWARD TO THE RIGHT AND CRASHED INTO A UTILITY POLE. NO INJURIES WERE REPORTED. A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE WAS TOWED TO THE LOCAL DEALER FRIENDLY FORD (2800 N. TELEGRAPH RD, MONROE MI.) THE CAUSE OF THE FAILURE WAS NOT DETERMINED. ALSO, WHILE DRIVING AT VARIOUS SPEEDS AN ABNORMAL NOISE WAS PRESENT COMING FROM THE REAR OF THE VEHICLE. THE NOISE WAS MOST NOTICEABLE WHILE DRIVING DOWN AN INCLINE. THE VEHICLE WAS ALSO TAKEN TO THE DEALER FOR THIS ISSUE HOWEVER, THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 500. *JS

SINCE BUYING MY ESCAPE BRAND NEW WITH 1 MILE ON IT, IT HAS BEEN PLAGUED WITH ISSUES, ENGINE SHUTS OFF WHILE DRIVING CAN BE GOING 30 MPH OR 70 MPH, WHILE DRIVING ON THE INTERSTATE AT 70 BAD SMELL FROM CATALYTIC CONVERTER SEEPS IN THROUGH VENTS. PASSENGER SIDE TIRE WALL BLEW WHILE TURNING OUT OF A PARKING LOT. LICENSE PLATE LIGHT OUT AND UNABLE TO REMOVE TO CHANGE. DEALERSHIP HAS HAD CAR SEVERAL TIMES CLAIMING NOTHING IS WRONG WITH IT. RADIO KEEPS SAYING "UPDATE" DEALERSHIP CLAIMS IT'S MY PHONE (MY PHONE HAS NO UPDATES DUE) BRAKES MAKE TERRIBLE NOISE WHEN REVERSE BREAKING. A LITTLE OVER 11,000 MILES AND TRANSMISSION KEEPS SLIPPING BUT DEALERSHIP CLAIMS NOTHING IS WRONG, ALSO CAR DOES NOT WANT TO START HALF THE TIME. USB FOR PHONE CORD IN FRONT DOES NOT WANT TO STAY CONNECTED, AND BACK PORT FOR CAR CHARGER OVERHEATED AND CAUSED MY DAUGHTER...

LOW COOLANT LEVEL PREVIOUS OIL CHANGE/COOLANT ADDED. ROUGH IDLE COLD START, P0302 2/11/2020 WITH AGAIN LOW COOLANT. TOPPED OFF COOLANT 2/11/2020 DROPPED OFF AT DEALERSHIP 2/23/2020 AGAIN COOLANT LEVEL LOW. APPARENTLY THIS IS VERY COMMON AND ENGINE REPLACEMENT IS ONLY REMEDY. VERY DAMAGING TO VEHICLE VALUE.

PURCHASED VEHICLE APRIL 2019. ALMOST IMMEDIATELY HEARD COOLANT GURGLING SOUND COMING FROM ENGINE WHEN ENGINE AUTO TURNED OFF AT STOP LIGHT. I WAS TOLD THAT THIS SOUND WAS NORMAL. JANUARY RECEIVED NOTICE FROM FORD THAT MY VEHICLE NEED PCM REPROGRAMMING. DAY AFTER REPROGRAMMING I BEGAN TO RECEIVE CHECK ENGINE WARNINGS. SOON AFTER THE HEATER WOULD NOT WORK WHEN CAR WAS NOT IN GEAR. TOOK VEHICLE TO DEALER AND WAS TOLD THAT THE ENGINE NEEDS TO BE REPLACED DUE TO COOLANT LEAK IN TO VALVES. DEALER ALSO MENTIONED THAT I HAD LOST ALMOST ALL OF MY COOLANT. NOTE: I NEVER RECEIVED ANY WARNING MESSAGES ABOUT LOW COOLANT LEVEL. I HAVE SINCE DISCOVERED THAT THERE ARE THOUSANDS OF THESE ENGINES THAT HAVE HAD TO BE REPLACED DUE TO THIS ISSUE.

WE WERE DRIVING ON A 3 LANE HIGHWAY AT NIGHT, STOPPED AT A RED LIGHT. SUDDENLY, THE CAR WENT COMPLETELY DEAD - NO LIGHTS OR POWER. CARS DRIVING AT BETWEEN 40-50 MPH WERE COMING UP BEHIND US, BUT COULD NOT SEE US BECAUSE WE COULD NOT EVEN GET HAZARD LIGHTS ON. WE WERE LOCKED IN - THE DOORS WOULD NOT OPEN!! AFTER SEVERAL NEAR MISSES, WE WERE LUCKY ENOUGH TO HAVE A STRANGER STOP AND HE WAS ABLE TO ALERT ONCOMING CARS SO WE WOULD NOT GET HIT. ENDS UP THAT THE NEGATIVE TERMINAL OF THE BATTERY WAS VERY LOOSE AS WELL AS THE SURROUNDING FASTENERS OF THE BATTERY. WE PURCHASED THE CAR 5 WEEKS EARLIER, BRAND NEW WITH 11 MILES ON IT. AFTER GETTING TOWED TO THE DEALERSHIP, IT WAS AN EASY FIX, BUT MY SAFETY CONCERN WAS THE FACT THAT THE DOORS WOULD NOT OPEN!!! IF THERE WAS...

THE VEHICLE STARTED RUNNING ROUGH AND MISSING AT 75 MPH WITH ABOUT 5000 MILES ON IT. CHECK ENGINE LIGHT CAME ON, CRUISE CONTROL SHUT OFF. I TOOK IT TO THE DEALERSHIP AND THEY SAID I HAD 3 TROUBLE CODES BUT I DON'T KNOW WHAT THE WERE. THEY REPROGRAMMED SOMETHING A GAVE ME THE CAR BACK A WEEK LATER. TWO WEEKS AFTER THAT I STARTED GETTING ANOTHER CHECK ENGINE LIGHT WITH THE CODE P0420. THE LOCAL DEALER SAYS THEY CAN'T FIX IT OR HONOR MY WARRANTY BECAUSE IT'S A US SPEC VEHICLE AND I'M IN EUROPE. I HAVE A BRAND NEW VEHICLE THAT I HAVE TO CLEAR THE CODE EVERY OTHER DAY. TO MAKE MATTERS WORST THE SMALL DOOR THAT COVERS THE ODB PORT WON'T CLOSE CORRECTLY. I'M SURE IT WASN'T DESIGNED TO BE OPENED EVERY OTHER DAY.

I BOUGHT MY 2019 FORD ESCAPE BRAND NEW IN MARCH OF THIS YEAR, IT HAD LITTLE UNDER 25 MILES. AS OF NOVEMBER 11TH I AUTO STARTED MY CAR- WHEN I WENT TO GET IN IT WAS RUNNING FUNNY AND CHECK ENGINE LIGHT WAS BLINKING. TOOK IT TO DEALERSHIP, ON NOVEMBER 13TH THEY CALL AND TELL ME MY ENGINE IS BAD. THIS IS UNACCEPTABLE, MY CAR HAS 11,647 MILES ON IT & NEEDS A NEW ENGINE. FORD NEEDS TO DO A RECALL ON THESE FORD ESCAPES - I KNOW 3 PEOPLE NOW WHO HAVE HAD THE SAME ISSUE. VERY UNACCEPTABLE FOR BUYING A BRAND NEW CAR

I WAS DRIVING AT ABOUT 30 MILES AN HOUR AND THE ENGINE JUST SHUT DOWN FOR NO REASON. AN ALERT CAME UP THAT SAID AUTO STOPSTART SHIFT TO P RESTART ENGINE.

WHILE DRIVING A LOCAL INTERSTATE BETWEEN 60 AND 70 MPH, OUR NEWLY PURCHASED (3,000 MILES) 2019 FORD ESCAPE SEL SPORT COMPLETELY SHUT DOWN WITHOUT WARNING IN HEAVY TRAFFIC. LUCKILY, MY WIFE WAS ABLE TO COAST TO THE NEAREST EXIT AND PULL OFF THE ROAD WHILE TRAFFIC WAS WHIZZING BY US AT BREAKNECK SPEED. TURNS OUT THAT PART OF THE WIRING HARNESS HAD EITHER LOOSENED ON ITS OWN OR WAS NEVER PROPERLY SECURED FROM THE FACTORY. SO, THE SERPENTINE BELT MANAGED TO CLIP THIS WIRING HARNESS WHICH, IN TURN, PULLED THE HARNESS FROM ITS SOCKET WHILE STARTING TO GRADUALLY SHRED THE SERPENTINE BELT. INSTANTANEOUS LOSS OF POWER WITHOUT WARNING CREATED A VERY SERIOUS AND DANGEROUS SITUATION. FORD NEEDS TO ISSUE A SERVICE BULLETIN AND/OR ISSUE A RECALL ASAP SINCE IT WOULD ONLY TAKE ONE OTHER INCIDENT SIMILAR TO THIS BEFORE SOMEONE IS SERIOUSLY INJURED, OR WORSE.

TL* THE CONTACT OWNS A 2019 FORD ESCAPE. WHILE DRIVING, THE VEHICLE SUDDENLY SHUT OFF. APPROXIMATELY TWO HOURS LATER, THE VEHICLE RESTARTED AND SHUT OFF AGAIN AFTER THE CONTACT DROVE HOME. THE VEHICLE WAS TOWED TO ISLAND FORD (3698 RT 9 SOUTH OLD, BRIDGE, NJ) AND UNKNOWN PINS WERE TIGHTENED. AFTER RETRIEVING THE VEHICLE AND LATER PARKING IT, THE VEHICLE COULD NOT BE RESTARTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 800.

VEHICLE SHUTS OFF WHILE DRIVING. STEPS TO REPRODUCE ISSUE: KEYFOB IS INSIDE VEHICLE IN DRIVERS COAT POCKET, MOBILE PHONE IS INTERMITTENTLY CONNECTED TO VEHICLE VIA USB CORD, VEHICLE IS ON, ENGINE RUNNING, START/STOP IS ON, VEHICLE IS DRIVING THEN STOPS AT A STOPLIGHT, START/STOP ENGAGES AND IDLES ENGINE FOR AT LEAST 15 SECONDS. WHEN FOOT BRAKE IS RELEASED VEHICLE SHUTS OFF, INSTRUMENT CLUSTER, RADIO, INFOTAINMENT, ETC TURN OFF. TO RESTART VEHICLE TRANSMISSION MUST BE PLACED IN NEUTRAL OR PARK AND VEHICLE ON/OFF BUTTON PRESSED. VEHICLE RESTARTS, POWERTRAIN MALFUNCTION ERROR DISPLAYS AND INFOTAINMENT SYSTEM APPEARS TO BE REBOOTING AND DISPLAYS WELCOME MESSAGE SUCH AS BEFORE IT WAS SET UP. VEHICLE WAS IMMEDIATELY BROUGHT TO DEALER; BLACKWELL FORD IN PLYMOUTH MI BOTH TIMES. DEALER COULD NOT REPRODUCE ISSUE OR PULL DETAILED INFORMATION BEYOND GENERAL FAULT. DEALER PERFORMED 1265OD EEC SYSTEM DIAGNOSIS QUICK TEST, 1265OD45 ENGINE MODULE DIAGNOSTIC PIN POINT TEST, 12650DX1 EEC...

SMELL ENTERS PASSENGER CABIN FROM WHAT APPEARS TO BE CATALYTIC EXHAUST FUMES WHILE DRIVING ON HIGHWAY.