2017 FORD ESCAPE Engine Problems

Engine fault popped up on the instrument panel on 12/16/2024. Diagnostic said misfire on cylinder 3, replaced the plug and coil pack and topped off the antifreeze.Two days later vehicle overheated and started blowing white smoke out of the exhaust, antifreeze was totally gone. Took it back to the mechanic and was told the engine needed replaced.

The contact owns a 2017 Ford Escape. The contact stated while starting and driving at various speeds, the vehicle experienced rough idling. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic and the dealer, who determined that there was coolant intrusion into the engine block and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

Vehicle overheated due to low coolant level. Coolant was escaping cooling system and penetrating the 1.5L engine block, which required engine removal and replacement of short engine block and cylinder heads. My case#: CXH03199782 Ford issued a Technical Service Bulletin (#20-0010) which covered the cost of this repair through November, 30, 2022. This is a known problem caused by poor design of the cooling system. Ford will not cover the cost (over $5,000) for the engine repair now, even though I work at a Ford dealership. I had purchased my 2017 Ford Escape pre-owned in 2022 from a Hyundai dealership. Did they have an obligation to disclose that service bulletin to me?

Coolant intrusion cylinder 4 no indicator light extremely low coolant level. A pressure leak down test was performed and it's getting in through the head gasket/cylinder wall.

Took it to a mechanic was informed I had coolant leak into the 2nd rear cylinder cracking the head. Which caused the car to prematurely overheat and stall randomly on the highway. Was notified there is a issuse with coolant leaks with this model from the mechanic for the 2017 ford escape ecoboost models. Only had the coolant light come on the day prior to stalling.

Vehicle currently has 86K miles. The transmission is being replaced for the SECOND time. Replaced for the first time 2/17/23 at 63206 miles (invoice included). The dealer also informed me that coolant is leaking into the engine block pursuant to Ford Technical Service Bulletin 22-2229 [XXX] ) but I would have to replace the engine at my expense. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2017 Ford Escape 1.5 ecoboost with only 50,571 miles. The engine failed as did the brakes due to the booster breaking off at the engine cam. I called Ford Motor Company and they asked me to take it to a Ford dealer because they have a customer service program on that engine which extended the power train warranty period to seven years. I notified Ford of the engine failure in August 2024, made an appointment at a Ford dealer per their request, had it towed to the dealer, and on 10/31/24 the Ford dealer notified me that the engine was defective and will cost $8000 to fix it. Ford Motor Company said sorry, the 7 year in service date on this vehicle expired on 10/19/24 just 12 days earlier, and refused to fix the engine. I had to pay the Ford dealer a $210 check out fee then go to...

The contact owns a 2017 Ford Escape. While the contact’s wife was driving at an undisclosed speed, the engine overheated. The temperature gauge indicated that the engine was overheating. The vehicle was taken to an independent mechanic and was diagnosed with coolant intrusion into the cylinders and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was advised to contact the dealer to make them aware of the failure. The dealer was made aware of the failure; however, the contact was informed that the repair was not covered under warranty or recall. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 62,000.

2017 Ford Escape SE Ecoboost engine. Engine gasket broken. Vehicle only has 78,000 miles on it. Just out of the original warranty range. Consequently piston pieces ended up in the oil pan, ruining my engine. Dealership wants us to pay for it, $11,000. This is a common manufacturer problem that I've seen reported, there is potentially a campaign to get this recalled. I've also researched to where there is class action lawsuits against it. It is currently at Walker Ford in Clearwater, FL.

My vehicle is a 2017 Ford Escape Titanium with a 2.0L EcoBoost engine with 57,315 miles. Check engine light came on and the Diagnostic Trouble Code came back P0301 so I took it to my highly trusted mechanic Aloha Auto Center in September for the repair of replacing the ignition coil and spark plugs. Unfortunately after the repair at 57,678 miles the indicator light came back on with the same code so I took it back to my mechanic looked it over saw that the coolant level was low (I think he mentioned white smoke but not 100% kind of a blur) so he did some quick research and found the TSB 19-2346 which includes my engine type, year, make and model along with the indicator code. My engine has the presence of coolant in the engine cylinder and it is running rough. He says it is clearly this TSB...

2017 Ford Escape SE Ecoboost engine failure. Check engine light came on, engine did not overheat, but continued to misfire and make strange noises and motions during idling. After diagnostics, it was seen as a coolant leak issue, they later found pistons in my oil pan. Cost is $11,000 and they won't help cover any cost despite class action lawsuits and recall campaign. My car is out of warranty by year. I only have 78,000 miles on it, again should not be happening to a vehicle with this mileage. This is an obvious manufacturer issue and huge safety issue that Ford should be held accountable for.

Internal coolant leak into engine

Check engine light came on while normal driving on highway and car immediately started running rough, power cutting out, engine sputtering. I immediately exited highway & pulled into a Ford dealership that was right off the highway. They hooked up a code reader & got a P0301 code error, misfire in cylinder 1. They said it could be a number of things wrong but couldn't get my car in shop for 2 weeks. Replaced spark plugs& coil, no difference, checked fuel injection & pressure seemed ok. Did some research found that there is a known issue with the 2017 escapes 1.5 liter eco boost turbo engines involving coolant leaking into cylinders causing the same exact problem I am experiencing with my vehicle. I have done regular oil changes & other maintenance on the vehicle since purchasing in 2020 and haven't had any problems really other than having to replace the...

2017 Ford Escape Titanium with 2.0 engine and 61,000 miles. Just had to replace the whole engine due to coolant leaks from engine block cracks. Extremely heavy smoking and very rough idling and driving. Will be picking up repaired vehicle tomorrow (12/10/24) after it being in garage for over a week. Estimated bill is ~$7,000.

Car had error code P0301. Took car to Ford dealer and was told there is a known defect with the 2.0 liter Ecoboost engine, (Ford TSB 22-2229) regarding coolant leak into the engine cylinders. There is no fix, and Ford recommends replacing the entire engine at a cost of over $8,000. I have called Ford customer support, there is no recall and they are unwilling to do anything to assist with this problem.

-PURGE VALVE SOLENOID REPLACED TWICE FOR EVAP SYSTEN, CODE 1450 OCCURED 01/05/2021 & 05/14/2021 AND -LEAK IN RADIATOR, UNKNOWN IF BLOWN GASKET. RECEIVED MESSAGE “HIGH ENGINE TEMPERATURE STOP SAFELY” WITH ZERO RADIATOR FLUED IN TANK OCCURED 11/2/202. THIS HAS NOT BEEN REPAIRED BUT I HAVE BEEN AWARE OF CLASS ACTION LAW SUIT RELATED TO THIS ISSUE.

In October, 2023 and issue with car just shutting off (no warning) in middle of road. Garage said possibly a thropple. After that nothing. October 2024 car shutting off again in middle of road . Garage can not find the problem. Meter just goes wacky. Please check in to this. Awaiting your reply.

UNKOWN Was Driving my sons car to dealership, because there was an oil leak and transmission fluid leak. I checked the levels before i left and made sure everything was up to the required levels. After leaving it, I got a call a few days later and they told me they were surprised the car didn't catch on fire due to how bad the issue was. The dealership called in the warranty claim to car shield which I have a contract with and they told me it was denied because there was a technical service bulletin number 22-2229 released on June 9'th 2022 stating the following "Summary This article supersedes TSB 22-2133 to update the Parts List. Issue: Some 2015-2018 Edge and 2017-2019 Fusion/MKZ/Escape/MKC vehicles equipped with a 2.0L EcoBoost engine may exhibit a low coolant level, white exhaust smoke and/or a runs rough condition with or without an illuminated...

Our 2017 ford escape is experiencing an engine coolant intrusion and causing issues with vehicles handling a performance. Our vehicle is well maintained and only 72000 miles on it. This is a known issues with the eco boost engine and is currently a class action lawsuit against ford for other vehicles with a different VIN than the one we own. Our vehicle is meeting all the requirements but is not covered.

Vehicle had coolant intrusion in the engine causing irreversible engine damage as diagnosed by a Ford dealership's service department. Apparently this is a well known issue on these Escapes. Ford states that although there are some recalls on this vehicle for this issue, they are only covering certain VINs. I was advised by others to submit my information here in hope of Ford expanding coverage for this faulty engine. We are left with a paperweight as a result of faulty engineering and pitiful customer service.

An internal coolant leak has caused the engine to fail and the dealer is quoting nearly $7,000 for a new front block. A quick Google search indicates this is a known and common problem with this model/year Escape. This vehicle has less than 40,000 miles on it but Ford is not willing to assume any responsibility. Based on our experience and the well-documented issues online, we believe the manufacturer should be required to implement a recall and cover repair costs for this issue.

Engine service lights on and overheated. Replaced fan clutch, but same issue a week later. Repair shop stated coolant leaked into cylinder, needs engine replaced. I see online that others have had the same issue with 2017 Ford Escapes. I checked with Ford, they said to reach out to you for financial assistance as a safety issue since it is a known issue. Also seen a Ford technical bulletin 19-2139 dated November 21, 2019 for the issue.

There was a coolant leak in to the engine that caused a head gasket issue. When we got the headgasket replaced, a month and a half later the same issue came back but this time it caused a crack in the engine block and we're now being told we need a new engine. The car only has 83000 miles on it.

2017 Ford Escape with 66,000 miles, garage kept, well maintained. My steering wheel started to shake when shifting from park to drive but after idling for 30 seconds in park it was perfectly fine. Check engine light comes on, take it to a Ford dealer and they tell me the engine has a small coolant leak and the shaking was because the coolant was soaking a spark plug and it was burning it off. They told me the only repair they could do was replacing the engine for $10,000 or I could trade it/sell it to them and get $2,500 for it. And it is not covered by warranty and not recalled, but a known issue in these models/years. In this day and age a car should last more than 7 years and I’m not sure I understand if it’s a known issue why it isn’t recalled. Now I’m expected...

On start-up the check engine light came on and the vehicle will vibrate at lower speeds, such as within a neighborhood. When going faster, it seems like it would act more normal. Took it into the dealer on 11/18/24. Dealer points out that this engine has a common known problem. Same applies to the year/make/model/engine which is on recall for coolant intrusion cylinder 3. However, my vin does not show this recall. The fix would be TSB 22-2229.

Engine Failure on the 2.0 Ecoboost Engine. Vehicle only had 57,000 miles on it, but the warranty was not honored since it was past the 5 years, but it was less miles than the 60K warranty. I see that this is a recurring problem and I wanted to add my vehicle to the list of complaints. This vehicle should have been part of a recall.

The oil pump failed due to the coolant intrusion into the engine, causing low pressure and sludge. My mechanical breakdown warranty inspected it and will not cover the replacement due to the sludge. The check engine light came on and off after I hit 70000 miles, and I was alerted to a recall when I got my last oil change in March of 2024, but the Ford dealership stated I had no warranty and no recall to address.

The contact owns a 2017 Ford Escape. The contact stated while driving at an undisclosed speed, there was an engine misfire and the check engine warning light illuminated. Additionally, the contact noticed white smoke coming out of the exhaust pipe. The vehicle was taken to the dealer, where it was diagnosed that the engine had failed due to coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was previously repaired under Ford Campaign Number: 19B37. The manufacturer was made aware of the failure and a case was opened. The manufacturer informed the contact of Ford Campaign Number: 21N12; however, the vehicle was not covered. The failure mileage was approximately 58,000.

What component or system failed or malfunctioned, and is it available for inspection upon request? The engine has failed at 79k miles due to coolant intrusion into the cylinder. The catalytic converter has also failed and needs to be replaced as a direct correlation. Yes it is available for inspection upon request in the near term, as it is currently at the Ford service center. The scope of the problems either match directly or are very similar to Ford's Technical Service Bulletin 22-2229 and/or 22-2134. How was your safety or the safety of others put at risk? The check engine light indicator was only illuminated for 2-3 days before service. The severity of potential engine failure as well as loss of coolant could cause an engine fire that puts my family at significant risk and danger. Has the problem been reproduced or confirmed by a dealer or independent service center?...

Engine design is flawed and has a known coolant intrusion into the cylinders. Ford only issued a tsb for this and not recall. I’m the second owner so I have no way to remedy this now as the mileage is over what ford offers. Ford should be covering their bad design. At this point I’m stuck with it since it would cost me about the cost of what I paid for this vehicle.

suffering from Ford's coolant intrusion issue and neither my local ford dealership or Ford Corp will help me resolve this issue without buying a new engine

Known Technical Service Bulletin 22-2229 in place through Ford. Coolant intrusion in #3 cylinder. Long block needs to be replaced. Issue will continue to get worse and if coolant is not added engine will overheat and potentially result in an accident. There is no recall on this issue but Ford has known about it for several years.

The contact owns a 2017 Ford Escape. The contact stated while the vehicle was parked, the vehicle stalled, with the "Engine Error Fault" message displayed on the instrument panel. The contact stated that several unknown warning lights were intermittently illuminated, and the infotainment screen was inoperable. The vehicle was towed to a dealer where it was diagnosed that coolant had leaked into the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 142,000.

My check engine light came on so I took it to a Ford dealership for an inspection. After my car was inspected, they deemed my car was unsafe to drive due to extreme coolant intrusion and my engine was close to seizing up. The coolant intrusion issue was a known recall problem that I took to get fixed roughly 2 years ago and was assured that the problem was fixed.

Coolant intrusion into combustion chamber requires new engine. Verified by Ford dealer. Not covered by warranty. Ford technician states engine block manufacturer issue.

I have a coolant leak into one of the cylinders of the engine block. It causes a rough start in the morning when the car is sitting overnight. The check engne light has also been on.

Coolant leaking into cylinder number 3

The contact owns a 2017 Ford Escape. The contact stated that while starting the vehicle and driving at an undisclosed speed, the vehicle was shuddering, with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was determined that there was coolant intrusion into the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 62,000.

The contact's mother owns a 2017 Ford Escape. The contact stated that upon her mother starting the vehicle, the vehicle started to smoke. The check engine warning light was illuminated. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. The vehicle was driven by the mechanic to the same local dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no warranty coverage on the vehicle. There was no additional assistance provided. The failure mileage was approximately 48,000. The VIN was not available.

The Ford Escapes are having issues with cylinder misfires. This is prevalent in model years from 2012 to 2019. This impacts engine power and possible engine failure. This has been reported to the local Ford Dealership. The service advisor even acknowledged that this is a common problem, and he then proceeded to check if this issue has an open recall. It does not. I had my mechanic replace: all coils, spark plugs, fuel injectors, camshaft sensor, and crankshaft sensor. This did not fix the problem. Yes, the check engine light comes on. I purchase vehicles from auction sites. On inspection reports for Ford Escapes, the majority of them have cylinder misfires as code P030_. This cannot be to lack of maintenance. This is an issue with Ford ENGINES.

My 2017 Ford Escape has approx. 88k miles on it. The check engine light illuminated the week of 11/10/2024 and the engine began sputtering and experiencing significant disruptions in performance. I took it to the dealer and was told that there was a coolant intrusion on cylinder 1 and said the only fix was the replace the engine block, costing $8,700. I have decided against fixing it since that's basically the value of the car. I know that this is a known issue with Ford Escapes, and am disappointed that Ford has not decided to remedy the problem.

Car began putting out heavy grey exhaust. Occurred twice at the beach and thought it related to the high temperature. Returned home and noticed nothing out of the ordinary. Three weeks later, I went to turn on the car, the car immediately began to shudder violently and the check engine light kicked on. I immediately turned off the car and got it to a Lincoln dealer. It was covered under extended warranty, but they held my car to replace the engine for 3 months. Had to pressure the dealership to get a loaner for the 2.5 months.

Coolant leaked into cylinder 1.

Notice coolant reservoir was empty after warning light, refill coolant check reservoir couple days later low again. Research and come to find out common issue with ecoboost engines produced by Ford. Design flaw in the engine block that allows engine coolant to get into cylinders. Took car to Ford dealership were it issue was confirmed, coolant in cylinders. Dealership wants 9k to replace engine that has 71k miles on it. The car is unsafe to drive possible engine failure or fire.

Car was not accelerating properly. Took the car to a repair shop. Cylinder 2 completely ruined by a coolant leak into the cylinder. Mechanic stated only fix was a new engine.

Our car started slipping gears, jerking, take forever to accelerate, and would lose power. We took to dealership thinking it was a transmission. They told us no it wasn’t the transmission and we needed the replace the fuel pump injector we did that. A week later SAME issues happened again they replaced the pump again. A month later SAME symptoms again this time they told us we needed our engine replaced. So we got a brand new engine in. A month later I lost power while turning onto to a highway and the dealership told me that it was the new engine breaking in. Not even 3 months later after the new engine being put in our car starts to act up with the SAME symptoms. We took it back since the engine was under warranty. They tell us we need a new transmission. We told them we knew it...

Engine light became illuminated, car spewing white smoke on cold start-up. My 2017 Ford Esacape Titanium has under 97,000 miles. Took to dealership. Codes P0302 & P0316 Misfire on start & Cylinder 2 Misfire. Found Cylinder 2 has Coolant Intrusion. TSB 22-2229 needs a Long Block Motor Replacement. TSB was written in 2019 & Ford did nothing about Notification to anyone. Cost of repair is $ 7130.66, which I should not responsible for, seeing that Ford knew about this issue. NHTSA needs to hold Ford Motor Company liable for the repairs to all the affected parties.

A few weeks ago, the car started running rough. Upon inspection, what was first thought to be a faulty spark plug, has turned out to be a cracked engine block. It is burning coolant and running rougher and rougher. Took it to a local repair shop and, per guidance received from Ford, we have to replace the full engine. No warranty coverage, nothing.

Ecoboost 2.0 engine leaks coolant into cylinder. Check engine light came on took to dealer they said needed a tune-up. When we took it in for the tune up we told them we are now losing coolant and don't find any leaks. They checked and said the coolant is in the cylinder. Got estimate of $7703

1.5L EcoBoost - Low Coolant, White Exhaust Smoke And/Or Illuminated MIL Issue: Some 2014-2019 Fusion vehicles built on or before 10-Jun-2019 and 2017-2019 Escape vehicles built on or before 08-Apr-2019 equipped with a 1.5L EcoBoost engine may exhibit low coolant level, white exhaust smoke and/or runs rough condition with or without an illuminated malfunction indicator light (MIL) with only diagnostic trouble codes (DTCs) P0300, P0301-P0304, P0316, P0217, P1285 and/or P1299 stored in powertrain control module (PCM). This may be due to coolant intrusion into the cylinder. To resolve the condition, follow the Service Procedure to replace the short block and head gasket