2004 FORD E-450 Engine And Engine Cooling Problems

FORD E450 DOORS POP OPEN WHILE DRIVING. CONSUMER STATES THAT THE BODY IS TWISTED, THE DOORS POP OPEN WHILE DRIVING. THE MOTOR AND TRANSMISSION HAVE BEEN REPLACED. PLUS THIS VEHICLE HAS EXPERIENCED EVEN MORE SEVERE PROBLEMS. *KB THE CONSUMER STATED THE BOLTS SHEARED OFF THE BODY OF THE VEHICLE, THE ROOF LEAKED, THE VEHICLE WOULD JUST SHUT OFF WITH NO WARNING AND THE OVERHEAD OF THE CAB WAS COMING OFF OVER THE WINDSHIELD. *JB ODI NOTE: THIS IS A ROCKPORT BODY ON AN E450 FORD CHASSIS - GTB 5-2-08

PARAMEDIC PLUS DBA SUNSTAR PARAMEDIC, IN PINELLAS COUNTY, FLORIDA, PURCHASED 54 AMBULANCES, FORD E-450, 6.0 LITER, IN AUGUST OF 2004. FOR THE PAST TWO YEARS OF USING THESE AMBULANCES IN ONE OF THE COUNTRIES BUSIEST EMS AGENCIES, WE'VE INCURRED A MULTITUDE OF ISSUES, WHICH HAVE HAMPERED OUR ABILITY TO PUT AMBULANCES ON THE STREET. THESE PROBLEMS INCLUDE, BUT ARE NOT LIMITED TO: EGR VALVES, EGR COOLERS, OIL COOLERS, INJECTORS, AC COMPRESSORS, RADIATORS, WIRING HARNESSES, SEVERAL ENGINES. EVERY AMBULANCE IN OUR FLEET HAS BEEN AFFECTED BY ONE OR MORE OF THE ABOVE PROBLEMS. IN SPEAKING WITH EMS AGENCY REPRESENTATIVES ACROSS THE UNITED STATES, I HAVE FOUND THAT THIS IS NOT AN ISOLATED PROBLEM. WE ARE SPENDING COUNTLESS HOURS OF LABOR AND COST OF REPAIRS OVER TWO YEARS WITH 54 OF THESE VEHICLES. WE HAVE MAINTAINED ALL RECORDS OF REPAIR AND CAN DEMONSTRATE THE IMPACT THIS HAS ON OUR EMERGENCY 911 SERVICE....

WHILE DRIVING AT VARIOUS SPEEDS OR TURNING THE ENGINE STALLED. WHEN THIS OCCURRED THE VEHICLE COASTED TO A COMPLETE STOP. DEALERSHIP REPROGRAMMED THE COMPUTER TWICE, REPLACED THE SENSOR ON CRANK SHAFT, AND CHECKED THE WIRING IN THE ENGINE COMPARTMENT. BUT, PROBLEM RECURRED. VEHICLE IS CURRENTLY AT THE DEALERSHIP. THE CHASSIS IS CONNECTED TO A BIG FOOT MH30BB 2004 MOTOR HOME. *AK WHEN THE ENGINE SHOT DOWN IT CHIMED AND THE LIGHTS CAME ON INDICATING THAT WATER WAS IN THE FUEL. CHECK ENGINE LIGHT COMES ON THEN THE ENGINE DIED. *TC

THE VEHICLE WILL NOT START. THE VEHICLE WAS TOWED TO DEALER AND THEY CANNOT FIND DEFECTS. THE MANUFACTURE HAS STATED THAT THEY WILL HELP. THE CONSUMER STATED "THIS IS AN EMERGENCY VEHICLE, AND HAS BEEN OUT OF SERVICE FOR THIRTEEN DAYS". *NM