2004 ENC ESCORT RE-A — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
2
Recalls
0
Service Bulletins
0
Investigations
Overview of the 2004 ENC ESCORT RE-A
The 2004 ENC ESCORT RE-A has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 2 recall campaigns affecting this vehicle, covering issues with FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP, FUEL SYSTEM, DIESEL.
Recalls for the 2004 ENC ESCORT RE-A
NHTSA has recorded 2 recalls for the 2004 ENC ESCORT RE-A, potentially affecting up to 1,391 vehicles.
Recall 05V416000 — FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP
| 989 vehicles affected
Defect: ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS ISB-02 DIESEL ENGINES BUILT WITH EMC CONTROLLED FUEL LIFT PUMPS. ERRATIC VOLTAGE SUPPLY TO THE FUEL LIFT PUMP CAUSES PREMATURE ELECTRIC BRUSH WEAR INTERNAL TO THE FUEL LIFT PUMP. THIS PREMATURE WEAR COULD RESULT IN FUEL LIFT PUMP FAILURE AND IN SOME CASES MAY CAUSE AN ENGINE STALL CONDITION.
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: CUMMINS, IN CONJUNCTION WITH ELDORADO NATIONAL, WILL NOTIFY OWNERS AND REPAIR THE ENGINES BY EMC RECALIBRATION AND REPLACEMENT OF THE FUEL LIFT PUMP AT NO CHARGE TO THE CUSTOMER. OWNERS MAY CONTACT CUMMINS ASSISTANCE CENTER AT 1-800-DIESELS OR ELDORADO NATIONAL...
View full details →Recall 05V114000 — FUEL SYSTEM, DIESEL
| 402 vehicles affected
Defect: ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS ISB DIESEL ENGINES, THE FUEL LIFT PUMP COULD FAIL IN A MANNER WHICH RESULTS IN ENGINE FUEL STARVATION, WHICH COULD RESULT IN A STALL CONDITION. POTENTIAL LIFT PUMP FAILURE MODES INCLUDE: BRUSH WEAR OUT, BUSHING FAILURE, ROTOR TAB INSERT FAILURE, OR ANY OTHER FAILURE MODE THAT WOULD CAUSE THE FUEL PUMPING ELEMENT TO...
Consequence: IF THE FUEL LIFT PUMP PUMPING ELEMENT STOPS SPINNING AND THE FUEL PUMPING VANES STOP IN A LOCATION WHICH BLOCKS FUEL FLOW THROUGH THE LIFT PUMP, THE ENGINE WILL BE STARVED OF FUEL. FUEL STARVATION COULD CAUSE LOW ENGINE POWER, ENGINE MISFIRE, OR ENGINE STALL. PRIOR TO THE ENGINE STALLING, THE OPERATOR COULD EXPERIENCE LOW ENGINE POWER, ENGINE MISFIRE, AND/OR DASH-MOUNTED FAULT LAMP ILLUMINATION.
Remedy: CUMMINS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 OR ELDORADO AT 1-909-591-9557.
View full details →Owner Complaints for the 2004 ENC ESCORT RE-A
No complaints have been filed with NHTSA for the 2004 ENC ESCORT RE-A.
Safety Rating for the 2004 ENC ESCORT RE-A
NHTSA has not yet tested the 2004 ENC ESCORT RE-A in its New Car Assessment Program.
Technical Service Bulletins for the 2004 ENC ESCORT RE-A
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 2004 ENC ESCORT RE-A
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the ENC ESCORT RE-A
- 2004 ENC ESCORT RE-A (current)
- 2005 ENC ESCORT RE-A — 0 complaints
- 2006 ENC ESCORT RE-A — 0 complaints
Other ENC Models
- ENC COACH — 1 total complaint
- ENC AXESS — 0 total complaints
- ENC BUS — 0 total complaints
- ENC ESCORT RE — 0 total complaints
- ENC ESCORT REA — 0 total complaints
- ENC EZ-RIDER — 0 total complaints
- ENC EZ-RIDER II — 0 total complaints
- ENC EZ-RIDER MAX — 0 total complaints