2009 DODGE CHALLENGER Power Train Problems

Faulty TCM After purchasing my car it would hard shift in the 3rd and 4th gear And I realize that shortly after purchasing it chant and then one night I was on the freeway and between 2 semi trucks when it's just neutral and then tried shifting into 2nd gear Which almost caused me to wreck in between 2 semi trucks which was not cool and Now my car only shifts into 1st and 2nd gear and when it gets to 3rd it neutrals , It won't go into 3rd or 4th gear . I took it into the dealership to get new software Uploaded on my TCM they said it was fine so I drove it out the parking lot and still doing the sa.e thing won't shift into 3rd gear so I took it to another shop to have it looked at because I didn't want to risk...

I took my car to the dealer for recalls they didn’t fix anything they left my car out in the rain the hood up and Choppa had my car for a whole month did any nothing they were very courteous no customer assistance nothing

CAR GETS STUCK IN GEAR WHEN PARKED AND IS DIFFICULT TO SHIFT WHEN DRIVING. THE CAR WHEN PARKED IS ON A FLAT SURFACE AND YOU NEED TO YANK IT OUT OF GEAR WHEN THE CAR IS RUNNING. IF YOU BACK UP THE CAR AND TRY TO TAKE IT OUT OF REVERSE YOU HAVE TO YANK IT OUT OF GEAR.

I BROUGHT MY CAR 8 MONTHS AGO AND THE DELALERSHIP NEVER TOLD ME ABOUT ANY OF THE FOUR RECALLS I NEVER RECEIVED ANY PAPERS IN THE MAIL CONCERNING THE RECALLS AND THAT PUTS ME AND MY CHILDREN AT RISK EVERYDAY IT'S A SCARY FEELING I ALSO HIT A TREE THAT WAS IN THE MIDDLE OF THE STREET MY STEERING G WHEEL WAS HARD TO CONTROL AND MY BREAKS AS WELL

THE VEHICLE IS EXPERIENCING DIFFICULTY TAKING THE MANUAL TRANSMISSION OUT OF GEAR WITH THE CLUTCH PEDAL FULLY DEPRESSED. THIS OCCURS ON BOTH COLD AND HOT START UP AS WELL AS WHEN DRIVING OR STOPPING DURING IN TOWN DRIVING. THIS CREATES A DANGEROUS SITUATION IN THAT THE DRIVER COULD INADVERTENTLY ROLL INTO AN INTERSECTION WHERE THEY DO NOT HAVE THE RIGHT OF WAY, ANOTHER VEHICLE, PEDESTRIAN OR BUILDING. THE VEHICLE WILL "CREEP" ON FLAT GROUND IF IT IS NOT PLACED IN NEUTRAL AND THE BRAKE IS RELEASED. USING OUR FRIEND GOOGLE I HAVE RESEARCHED THIS ISSUE AND IT APPEARS FROM DISCUSSION ON MULTIPLE FORUMS THAT IT IS A KNOWN ISSUE FOR MY AND OTHER MODEL YEARS. TWO CASE NUMBERS FROM THE MANUFACTURER SEEM TO INDICATE THAT THERE IS A PROCEDURE FOR CORRECTING THIS ISSUE. CASE NUMBERS ARE K38556860 AND S1021000004. THE CASE NUMBERS ARE NOT RECALLS AND I HAVE NEVER BEEN...

MY CAR LOST COMPLETE POWER WHILE TURNING IN A RESIDENTIAL AREA. THE VEHICLE IS DEAD AND WILL NOT START. THE VEHICLE SHUT DOWN WITH NO WARNING. THIS HAS HAPPEN SEVERAL TIMES. THE LOCAL DODGE DEALER HAD IT 2 WEEKS AN COULD NOT DETERMINE WHY

MY CAR IS LOCKING ITS SELF IN FIRST GEAR AND IS HARD TO SHIFT OUT OF GEAR. THIS IS AT A STAND STILL. UPON FIRST GETTING INTO THE CAR. THIS HAPPENS NEARLY EVERYDAY NOW FOR APPROXIMATELY, 4 MONTHS. I NOW BACK INTO MY PARKING SPOT. ALSO, AT HIGH SPEEDS, ITS GETTING DIFFICULT TO SHIFT AS WELL. GEARS ARE GRINDING AS THEY GO INTO GEAR. MOST RECENTLY WAS SATURDAY MARCH 18TH 2017. I WAS ON INTERSTATE 5 IN OREGON. HEADING HOME. GRINDED EVERY GEAR AS I SHIFTED. I ENGAGED THE CLUTCH ALL THE WAY ON EVERY SHIFT AND IT STILL GRINDED ITS GEARS.

MANUEL TRANSMISSION GRINDS/HARD TO SHIFT INTO THE NEXT GEARS. FEELS LIKE THE CLUTCH ISNT COMPLETELY DISENGAGEING AND IF YOU PARK WITH IT IN GEAR YOU CANT GET IT OUT OF GEAR TO PUT IT INTO NUETRAL,STICKS OR LOCKS IN GEAR. SOMETIMES DOUBLE CLUTCHING IT DOESNT HELP

SUDDEN ENGINE STALL AT STOP SIGN, AT IDLE AND ALSO WHILE ON HIGHWAY AT SPEED. OIL LIGHT COMES ON INTERMITTENT NO CODES , OIL LEVEL CHECKED , GAS WAS GOOD . MANY ON EVERY CHALLENGER FORUMS ARE HAVING THIS ISSUE "STALLING" , EVEN BRAND NEW CARS RIGHT OFF THE LOT. DODGE REJECTS THERE'S AN ISSUE, FROM DEALERS TO THE TOP. PLEASE HELP! WE DON'T TRUST OUR CARS!

THROWOUT BEARING SCREECH-SQUEALING NOISE. BAD GREASE ON THE INPUT SHAFT AND CLUTCH HUB SPLINES. THESE ISSUES LED TO CLUTCH FAILURE. SLAVE CYLINDER BLEW OUT AND CLUTCH FLUID LEAKED OUT OF THE LINES.

MY 2009 DODGE CHALLENGER R/T EQUIPPED WITH THE AUTOMATIC TRANSMISSION STARTED EXPERIENCING PROBLEMS DOWNSHIFTING WHEN APPROACHING A STOP. YOU WOULDN'T KNOW UNTIL YOU PRESS THE GAS TO PROCEED DOWN THE ROAD AND BARELY MOVE AS THE VEHICLE WOULD BE STUCK IN THE HIGHEST GEAR. I WOULD HAVE TO PULL OVER, TURN THE VEHICLE OFF, AND RESTART IT TO DRIVE THE VEHICLE. LUCKILY THIS DIDN'T HAPPEN WHEN TRYING TO PULL OUT INTO TRAFFIC AS IT WOULD HAVE A HIGH TENDENCY TO CREATE A COLLISION. TRANSMISSION CODE FOR THE INPUT SPEED SENSOR AND AFTER RESEARCHING IT ONLINE, I FOUND A MASS NUMBER OF COMPLAINTS AND REPAIRS ABOUT THIS ISSUE. IT APPEARS TO BE A MECHANICAL DEFECT THAT NEEDS TO BE DEALT WITH BY FCA AND NHTSA DUE TO THE COMMON OCCURRENCE IS THESE VEHICLES. REPLACING THE INPUT SPEED SENSOR WHICH IS PART OF AN ELECTRONIC MODULE COST APPROXIMATELY $500 AND CORRECTED THE...

HELLO! HARD SHIFTING 6SPEED MANUAL: I HAVE BEEN HAVING SHIFTING PROBLEMS WITH MY MANUAL TRANS FOR A COUPLE OF MONTHS. IT STARTED BACK IN NOV 11 WHEN TRAVELING OUT OF TOWN,GOT STUCK IN TRAFFIC AND CLUTCH STARTED TO NOT DISINGAUGE ALL THE WAY (WOULD CREEP) HAD TO HOLD FOOT ON BRAKE OR PUT IN NEUTRAL EVEN AFTER PULLING OFF THE ROAD. LATTER WHEN COMING HOME BAKED INTO PARKING SPACE TURN KEY OFF WANTED TO PUT IN OTHER GEAR WAS VERY HARD TO PULL OUT OF REVERSE. HAS GOTTEN WORSE, IT IS GETTING HARDER TO SHIFT WHILE DRIVING. MY WIFE WENT TO GET ON THE HIGHWAY AND HAD VERY HARD TIME GOING INTO LOWER GEAR ALMOST GETTING HIT IN THE REAR.DODGE SAYS WORN CLUTCH,BUT IT DOESN'T SLIP, BUT THEY HAVE A NOTICE ABOUT GREASE BEING ON INPUT SPLINE THATS THE CLUTCH SLIDES ON GETTING DIRTY FROM TO MUCH GREASE AND DIRT,...

THE VEHICLE WILL STICK IN GEAR WITH THE CLUTCH PEDAL FULLY DISENGAGED (PRESSED TO THE FLOOR) AND THE VEHICLE WILL CONTINUE TO BE DRIVEN BY THE ENGINE POWER. THIS ISSUE CAN CAUSE THE VEHICLE TO ENTER AN INTERSECTION OR RUN OVER A PEDESTRIAN DESPITE THE DRIVER'S EFFORTS TO DISENGAGE THE VEHICLE'S TRANSMISSION/DRIVE SYSTEM. CHRYSLER ADDRESSED THE ISSUE AS EXCESSIVE GREASE ON THE INPUT SHAFT SPLINES COLLECTING EXCESSIVE AMOUNTS OF DIRT WHICH DID NOT ALLOW MOVEMENT OF THE CLUTCH DISC ON THE INPUT SHAFT.

KNOWN TREMEC TR6060 ISSUE & DODGE REFUSES TO HELP!! STAR CASE# S1021000004 & K38556860. THE GREASE USED IN THE TRANSMISSION TURNS INTO A GLUE AT HIGH TEMPS CAUSING THE TRANS TO NOT SHIFT PROPERLY THROUGH THE GEARS EITHER GOING INTO GEAR OR GETTING STUCK COMING OUT OF GEAR. IF HOT ENOUGH THIS GREASE FUSES THE PILOT & THROWOUT BEARING TO THE INPUT SHAFT REQUIRING THOSE BE REPLACED AT MINIMUM. THIS HAPPENED TO ME & THE CAR COULD NOT BE PUT IN 1ST-4TH WITHOUT A SEVERE GRINDING NOISE. IT CAN BE HEARD IN THE TRANS & FELT IN BOTH THE STICK & CLUTCH PEDAL. THE ONLY WAY TO SLOW DOWN WAS TO PUT THE CAR IN NEUTRAL & USE THE BRAKES WITHOUT ANY ENGINE CONTROL. BECAUSE OF THIS HIGH HEAT FUSION I HAD TO HAVE ESSENTIALLY THE ENTIRE TRANS REBUILT (BEARINGS, SYNCHROS, INPUT SHAFT & GASKETS). WHEN I SPOKE WITH DODGE...

THERE IS A KNOWN DEFECT WITH THE TREMECS AS ASSEMBLED IN 2009... THE GREASE THEY USED WAS INCORRECT. PLEASE REFERENCE VEHICLE ISSUE TRANS IS HARD TO SHIFT INTO GEAR. YEAR 2009 MODEL LC - CHALLENGER ENGINE 6.1L SRT HEMI (SMPI) V8, 5.7L HEMI VCT, 5.7L HEMI VCT MDS (EZD) SYSTEM OR COMPONENT;GEAR DRIVER INPUT / VEHICLE OPERATION; SHIFTING CASE VERIFICATION; VEHICLE AFFECTED IS THE LC CHALLENGER EQUIPPED WITH A MANUAL TRANSMISSION. IT MAY BE DIFFICULT TO SHIFT IN AND OUT OF GEAR. RECOMMENDATION ;REPAIR THIS CONDITION BY REMOVING THE TRANSMISSION, CLEANING THE TRANSMISSION INPUT SHAFT SPLINES AND THE CLUTCH HUB SPLINES, REGREASING, AND PUTTING ALL THE SAME PARTS BACK TOGETHER. NO PARTS NEED TO BE REPLACED BECAUSE CLUTCH DISC WEAR OR SHAFT/HUB SPLINE WEAR ARE NOT CONTRIBUTING FACTORS. THE CLUTCH SHOULD BE REMOVED FROM THE FLYWHEEL TO PROPERLY CLEAN THE CLUTCH SPLINES, BECAUSE IT IS NOT POSSIBLE TO THOROUGHLY CLEAN...

ENGINE QUIT WITH NO WARNING. STEERING AND BRAKES COMPROMISED. SHIFTED INTO NEUTRAL WHILE IN TRAFFIC.HAS BEEN OCCURRING MORE AND MORE FREQUENTLY. DEALER REPORTS CANNOT REPLICATE. SOUNDS JUST LIKE THE RECALLED GM'S. *TR

2009-2010 DODGE CHALLENGERS CAME OUT WITH GREASE ON THE INPUT SHAFT THAT PRETTY MUCH TURNED TO GLUE WHEN HOT. THE STAR CASE # IS [XXX]. DODGE NEVER ISSUED A RECALL. THERE ARE THREADS ALL OVER THE INTERNET THAT SHOW AS MANY AS 50% OF THE TREMEC 6060 6-SPEEDS WERE AFFECTED, BUT UNLESS YOU TOOK IT TO THE DEALER BY CHANCE, OR HAPPENED UPON A FORUM, YOU WERE OUT OF LUCK. I RECENTLY TOOK MY CAR IN DUE TO PROBLEMS SHIFTING. THE THROW OUT BEARING AND PILOT BEARING WERE FUSED TO THE INPUT SHAFT CAUSING IT TO WARP AND DAMAGE THE TRANSMISSION. THIS IS EXACTLY WHY DODGE HAD THE STAR CASE NUMBER ISSUED. SO, THEY DECLINED MY CLAIM. THE INITIAL REPAIR ESTIMATES WERE 3500.00, NOW IT IS 5100.00 BECAUSE YOU CANNOT BUY THE 2009-2010 PARTS ANY LONGER AND MUST UPGRADE TO THE CARBON FIBER PARTS USED IN 2011 AND UP (ADDITIONAL...

I WAS DRIVING NORMAL AT ABOUT 70MPH AND WAS EXITING HIGHWAY AND THE CAR JUST DIED. I PULLED OVER AND TRIED TO CRANK IT AND NOTHING. CALLED A WRECKER AND THEY TOOK ME TO THE PARTS HOUSE TO GET A CODE CHECKED AND IT SAID CAMSHAFT POSITION SENSOR. I BOUGHT ONE AND TOOK IT HOME AND REPLACED IT AND STILL NOTHING. YOU COULD SEE THAT THE TIMING CHAIN HAD BROKE THROUGH THE HOLE WHERE THE SENSOR WENT. OVER A FEW WEEKS I HAD TO REPLACE THE TIMING CHAIN, PLASTIC GUIDE AND TENSIONER (THEY GAVE ME METAL PARTS AS A REPLACEMENT), HSD TO REMOVE THE HEADS AND REPLACE ALL VALVES BECAUSE THEY WERE BENT, HAD TO FIND AND REPLACE BROKEN A VALVE GUIDE. THIS WAS CAUSED FROM WHAT I WAS TOLD BY THE PLASTIC PARTS WEARING OUT AND CHRYSLER IS QUIETLY REPLACING THEM AS PEOPLE BRING THEM IN, I FIXED MY...

I WAS DRIVING ON THE HIGHWAY, TRAVELING AT AN APPROXIMATE SPEED OF 65 MILES PER HOUR, WHEN ALL OF A SUDDEN THE CAR LOSES POWER, AND AT THAT POINT I COULD NO LONGER ACCELERATE MY VEHICLE. FORTUNATELY, TRAFFIC WASN'T TOO BAD, SO I WAS ABLE TO SAFELY PULL OVER TO SHOULDER WITHOUT GETTING REAR ENDED BY THE CARS THAT WERE TRAVELING AT VERY HIGH SPEEDS. SOON THEREAFTER, I HAD MY 2009 RT DODGE CHALLENGER TOWED TO THE DEALERSHIP, APPARENTLY, THE TIMING CHAIN BROKE. IT DOESN'T END THERE, NOT ONLY IS THIS VEHICLE FAIRLY NEW, BUT I ATTEMPTED TO FIX IT ALREADY ON MULTIPLE OCCASIONS, BUT IT SEEMS AS IF NOTHING HELPED. CURRENTLY MY VEHICLE NOW HAS ACQUIRED ENGINE DAMAGE AS A RESULT OF THE DEALERSHIP BEING UNABLE TO PROPERLY DIAGNOSE AND ADDRESS THESE ISSUES, FOR LACK OF KNOWING WHAT THE REAL ISSUE WAS ALL ALONG. IN ALL HONESTY, I FEEL...

HELLO! HARD SHIFTING 6SPEED MANUAL: I HAVE BEEN HAVING SHIFTING PROBLEMS WITH MY MANUAL TRANS FOR A COUPLE OF MONTHS. IT STARTED BACK IN NOV 11 WHEN TRAVELING OUT OF TOWN,GOT STOUCK IN TRAFIC AND CLUTCH STARTED TO NOT DISINGAUGE ALL THE WAY (WOULD CREEP) HAD TO HOLD FOOT ON BRAKE OR PUT IN NEUTRAL EVEN AFTER PULLING OFF THE ROAD. LATTER WHEN COMING HOME BAKED INTO PARKING SPACE TURN KEY OFF WANTED TO PUT IN OTHER GEAR WAS VERY HARD TO PULL OUT OF REVERSE. HAS GOTTEN WORSE, IT IS GETTING HARDER TO SHIFT WHILE DRIVING. MY WIFE WENT TO GET ON THE HIWAY AND HAD VERY HARD TIME GOING INTO LOWER GEAR ALMOAST GETTING HIT IN THE REAR.DODGE SAYS WORN CLUTCH,BUT IT DOESN'T SLIP, BUT THEY HAVE A NOTICE ABOUT GREASE BEING ON INPUT SPLINE THATS THE CLUTCH SLIDES ON GETTING DIRTY FROM TO MUCH GREASE AND DIRT,...

OVERVIEW: MY 2009 DODGE CHALLENGER R/T, WITH THE 5.7L HEMI ENGINE AND MANUAL 6-SPEED TRANSMISSION, HAS AN EXCESSIVE DELAY BETWEEN PRESSING THE THROTTLE AND ACHIEVING ENGINE RESPONSE. THIS OCCURS ONLY IN GEARS 4-6, AND IS THE RESULT OF A POWERTRAIN CONTROL MODULE (PCM) UPDATE. BACKGROUND: THIS VEHICLE HAS AN ELECTRONIC THROTTLE ("DRIVE BY WIRE") SYSTEM, WHERE THROTTLE RESPONSE IS CONTROLLED BY THE PCM AND NOT VIA A THROTTLE CABLE. HISTORY: ON OCTOBER 14, 2011, I BROUGHT MY VEHICLE TO MY LOCAL DODGE/CHRYSLER DEALERSHIP DUE TO A ROUGH ENGINE IDLE. THEY INFORMED ME THAT A PCM UPDATE WAS AVAILABLE, BASED ON TECHNICAL SERVICE BULLETIN (TSB) 18-014-10. THIS UPDATE CHANGED THE ENGINE CALIBRATION ID FROM 05187899AE TO 05187899AG. EVER SINCE THIS UPDATE WAS PERFORMED, THE VEHICLE HAS A SIGNIFICANT (AND UNSAFE) THROTTLE DELAY WHILE IN GEARS 4-6. BASICALLY, WHEN THE THROTTLE IS DEPRESSED, IT TAKES ABOUT 2 SECONDS FOR THE ENGINE TO...

2009 CHALLENGER R/T STALLED,CRANKED AND WOULD NOT RESTART. THE CAR HAS STALLED 5 TIMES ONCE GETTING ON A HIGHWAY. I HAD IT TOWED TO A DEALER THEY REPLACED THE VALVE BODY AND MAP SENSOR. THE CAR HAS STALLED A FEW DAYS LATER AND IS NOW AT ANOTHER DEALER. THEY CAN'T SEEM TO FIND THE PROBLEM AND I DON'T WANT TO PUT I 3 KIDS IN THE CAR TILL I KNOW ITS FIXED. IT SEEMS TO STALL IN DIFFERENT CONDITIONS (HOT , COLD, MOVING, WHEN FIRST STARTED,ETC). *TR